NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
298 reportsMileage unknown · Jan 7, 2004
Structure
MY 2001 DODGE GRAND CARAVAN SPORT HAD ITS SERPENTINE BELT SHREDDED AND ALTERNATOR BLOWN DUE TO SNOW PACKED UP IN THE ENGINE. THE ANGLE OF THE UNDERCARRIAGE AND THE FACT THAT THERE IS NO BLOCKER ON THE UNDERNEATH TO PREVENT THIS FROM OCCURING MADE THIS AN EXPENSIVE ORDEAL. I WAS TOLD BY DAIMLER/CHRYSLER THAT THERE WAS NO WAY TH…
Read full complaint
MY 2001 DODGE GRAND CARAVAN SPORT HAD ITS SERPENTINE BELT SHREDDED AND ALTERNATOR BLOWN DUE TO SNOW PACKED UP IN THE ENGINE. THE ANGLE OF THE UNDERCARRIAGE AND THE FACT THAT THERE IS NO BLOCKER ON THE UNDERNEATH TO PREVENT THIS FROM OCCURING MADE THIS AN EXPENSIVE ORDEAL. I WAS TOLD BY DAIMLER/CHRYSLER THAT THERE WAS NO WAY THEY COULD CONTROL THE SNOW SO THIS WASN'T THEIR PROBLEM TO FIX. WHEN I BUY A VEHICLE, I EXPECT IT TO WORK IN ALL WEATHER AND ROAD CONDITIONS. IT SHOULD NOT MATTER IF THERE IS SNOW ON THE GROUND OR NOT. THEY SHOULD BE REQUIRED TO PREVENT THIS FROM HAPPENING.*AK
NHTSA ODI #10052595
35,000 miles · Jan 6, 2004
Electrical SystemPower Train
DODGE GC 2001 STALLED WHILE IN MOTION WITH NO WARNING DURING A VERY HEAVILY TRAVELED AREA IN A SCHOOL ZONE WITH MANY POTENTIAL HAZARDS. LUCKILY I WAS ONLY GOING ABOUT 10 MPHS AND COMING TO A STOP. I INTERRUPTED FLOW OF TRAFFIC AT TIME OF FAILURE AND WHEN THE TOW TRUCK CAME. A POLICE OFFICER HELPED DIRECT TRAFFIC. MECHANIC SA…
Read full complaint
DODGE GC 2001 STALLED WHILE IN MOTION WITH NO WARNING DURING A VERY HEAVILY TRAVELED AREA IN A SCHOOL ZONE WITH MANY POTENTIAL HAZARDS. LUCKILY I WAS ONLY GOING ABOUT 10 MPHS AND COMING TO A STOP. I INTERRUPTED FLOW OF TRAFFIC AT TIME OF FAILURE AND WHEN THE TOW TRUCK CAME. A POLICE OFFICER HELPED DIRECT TRAFFIC. MECHANIC SAID LEAK DETECTION PUMP WENT OUT WHICH CAUSED THE PCM (POWER TRAIN CONTROL MODULE) TO SHORT OUT. THIS PCM CONTROLS MANY ELECTRICAL ELEMENTS. THE ENGINE LIGHT IS ON, THE SPEEDOMETER AND PASSENGER WINDOW DOESNT WORK AND I AM TOLD THAT SEVERAL SYSTEMS COULD FAIL BUT IT IS DRIVEABLE. I HAVE SEARCHED MANY DEALERSHIPS IN MANY STATES WITH ALL THE SAME ANSWER. THE PART I NEED, THE PCM, IS ON NATIONAL BACK ORDER. THERE ARE NONE AVAILABLE IN THE US. THIS IS THE ONLY VEHICLE I HAVE TO TRANSPORT MY CHILDREN. I CONTACTED DC CORP AND THEY WILL NOT TELL ME IF IT IS SAFE TO DRIVE W/ A FAULTY PCM. IT HAS BEEN 3 WEEKS AND MY VAN IS NOT FIXED. I AM AT THEIR MERCY AND THEY HAVE DENIED RESPONSIBILITY AS WELL AS A RENTAL REQUEST UNTIL MY VAN CAN BE FIXED PROPERLY. "UNFORTUNATELY, YOUR REQUEST FOR A RENTAL VEHICLE HAS BEEN DECLINED." THEY CLAIM "WE ARE UNABLE TO BE OF ASSISTANCE IN EXPEDITING PARTS THAT ARE NOT ON ORDER" THE PART HAS BEEN ORDERED. AGAIN I QUESTIONED THE SAFETY OF DRIVING THE VEHICLE WITH A FAULTY PCM WITH NO ANSWER AS OF YET. THEIR ARE OVER 250 PCM'S ON BACK ORDER.*AK
NHTSA ODI #10052514
47,000 miles · Jan 5, 2004
Seat Belts
THE INTEGRATED CHILD SEAT BUCKLE DOESN'T LATCH ALL THE TIME, AND IT IS HARD TO RELEASE. THE INTEGRATED SEAT IS LOCATED ON THE PASSENGER'S SIDE MIDDLE BENCH SEAT. MECHANIC STATED TO THE CONSUMER THAT THE BUCKLE WAS DEFECTIVE. *AK
NHTSA ODI #10053316
55,000 miles · Jan 2, 2004
Power Train
2001 DODGE GRAND CARAVAN- BAD PUMP & TORQUE CONVERTER ON TRANSMISSION. NLY 55, 000 MILES! ARRANTY IS INSUFFICIENT.*AK
NHTSA ODI #10051521
57,400 miles · Dec 24, 2003
Power Train
2001 DODGE GRAND CARAVAN. AT 57,000 MILES THE FRONT PUMP ON THE AUTOMATIC TRANSMISSION FAILED, RESULTING IN COMPLETE TRANSMISSION FAILURE. $3,500 TO REPLACE WITH RECONDITIONED TRANSMISSION. DAIMLER-CHRYSLER CUSTOMER SERVICE REFUSED TO PAY ANY AMOUNT FOR REPAIRS.*AK
NHTSA ODI #10051047
40,000 miles · Dec 21, 2003
Visibility
I OWN A 2001 DODGE GRAND CARAVAN SPORT. I HAVE EXPERIENCED PROBLEMS WITH THE POWER WINDOWS ON BOTH THE DRIVERSIDE AND PASSENGER SIDE. THE WINDOWS WILL INTERMITTENLY WORK. I HAVE TAKEN THE VEHICLE TO THE DEALERSHIP AND PAID 210.72 JUST FOR THE REPAIR OF DRIVERSIDE. THE DEALER DID NOT HAVE THE PART IN STOCK FOR THE PASSENGERSI…
Read full complaint
I OWN A 2001 DODGE GRAND CARAVAN SPORT. I HAVE EXPERIENCED PROBLEMS WITH THE POWER WINDOWS ON BOTH THE DRIVERSIDE AND PASSENGER SIDE. THE WINDOWS WILL INTERMITTENLY WORK. I HAVE TAKEN THE VEHICLE TO THE DEALERSHIP AND PAID 210.72 JUST FOR THE REPAIR OF DRIVERSIDE. THE DEALER DID NOT HAVE THE PART IN STOCK FOR THE PASSENGERSIDE. THE DEALER STATED THAT THEY REPLACED THE POWER WINDOW REGULATOR. I AM STILL WAITING FOR THE PASSENGERSIDE REGULATOR TO COME IN SO THAT TOO CAN BE REPLACED. THIS CONCERNS ME BECAUSE I WOULD NOT BE ABLE TO OPEN THE WINDOWS IN CASE OF AN EMERGENCY, WHEREAS I WOULD NOT BE ABLE TO OPEN THE DOOR.*AK
NHTSA ODI #10050876
Mileage unknown · Dec 13, 2003
Service Brakes, Hydraulic
BRAKES PULSE WHEN STOPPING, ESPECIALLY NOTICEABLE AT LOWER SPEEDS. VAN MILEAGE IS ABOUT 22,000 MILES. FIRST NOTICED THE PROBLEM AT ABOUT 8000-10,000 MILES, AND IT HAS STEADILY GOTTEN WORSE. IT IS QUITE PROMINENT NOW. PRESUMABLY THE ROTORS ARE WARPED. THE (ORIGINAL) BRAKE PADS ARE STILL IN VERY GOOD CONDITION. WE ARE VERY CONSE…
Read full complaint
BRAKES PULSE WHEN STOPPING, ESPECIALLY NOTICEABLE AT LOWER SPEEDS. VAN MILEAGE IS ABOUT 22,000 MILES. FIRST NOTICED THE PROBLEM AT ABOUT 8000-10,000 MILES, AND IT HAS STEADILY GOTTEN WORSE. IT IS QUITE PROMINENT NOW. PRESUMABLY THE ROTORS ARE WARPED. THE (ORIGINAL) BRAKE PADS ARE STILL IN VERY GOOD CONDITION. WE ARE VERY CONSERVATIVE DRIVERS AND RARELY MAKE FAST STOPS. DEALER SAYS BRAKES ARE WARRANTEED FOR ONLY A YEAR. APPARENTLY, SO ARE THE ROTORS. THE INCIDENT DATE IS THE DATE I POSTED THIS NOTICE. THE PROBLEM HAS BEEN ONGOING FOR WELL OVER A YEAR. WE DIDN'T NOTICE IT MUCH AT FIRST, BUT IT IS NOW PRONOUNCED ENOUGH ONE CANNOT MISS IT. *AK
NHTSA ODI #10049687
51,000 miles · Dec 11, 2003
Power Train
TRANSMISSION DISINTEGRATED. AS A RESULT, VEHICLE BECAME INOPERATIVE. *AK
NHTSA ODI #10050438
35,000 miles · Nov 30, 2003
Steering
I AM WRITING IN REQUEST FOR YOUR ASSISTANCE IN A MATTER CONCERNING MY 2001 DODGE GRAND CARAVAN. RECENTLY WE BROUGHT OUR VEHICLE INTO MANAHAWKIN CHRYSLER PLYMOUTH; DODGE ON RT. 72 IN MANAHAWKIN, NEW JERSEY FOR SERVICE. WE WERE INFORMED THAT THE VEHICLE, WHICH HAD ONLY JUST HIT 39,000 MILES, WAS IN NEED OF A NEW STEERING RACK AND …
Read full complaint
I AM WRITING IN REQUEST FOR YOUR ASSISTANCE IN A MATTER CONCERNING MY 2001 DODGE GRAND CARAVAN. RECENTLY WE BROUGHT OUR VEHICLE INTO MANAHAWKIN CHRYSLER PLYMOUTH; DODGE ON RT. 72 IN MANAHAWKIN, NEW JERSEY FOR SERVICE. WE WERE INFORMED THAT THE VEHICLE, WHICH HAD ONLY JUST HIT 39,000 MILES, WAS IN NEED OF A NEW STEERING RACK AND TIE RODS. I HAD THE VEHICLE REPAIRED AND YET THERE CONTINUES TO BE ODD NOISES IN THE FRONT END. A FEW DAYS LATER THE STEERING DID NOT FUNCTION, AS SOMEONE DID NOT CONNECT A POWER STEERING HOSE PROPERLY AND ALL THE FLUID LEAKED OUT. I AM NOW CONCERNED FOR THE SAFETY OF MY FAMILY. AS AN INDIVIDUAL WHO HAS A GOOD UNDERSTANDING OF AUTO MECHANICS, I AM CERTAIN THAT A STEERING RACK DOES NOT NORMALLY GO BAD SO EARLY IN THE LIFE OF A CAR. EVEN THE DODGE MECHANICS I HAVE SPOKEN TO HAVE INDICATED THAT THIS SHOULD NEVER HAVE HAPPENED.*AK
NHTSA ODI #10048863
Mileage unknown · Nov 28, 2003
Vehicle Speed Control
SPEEDOMETER WAS OPERATING ERRATICALLY. SOMETIMES IT WORKED FINE, SOMETIMES IT RACED FROM 0 TO 120 MPH, MOVING BACK AND FORTH RAPIDLY,AND SOMETIMES IT RESTED ON 0 MPH WHILE CAR WAS IN MOTION. WHEN STOPPED AT STOP SIGN AND / OR RED LIGHT AND WHILE VEHICLE IN GEAR, VAN SOMETIMES STALLED. VAN OFTEN STALLED WHEN MOVING IN REVERSE…
Read full complaint
SPEEDOMETER WAS OPERATING ERRATICALLY. SOMETIMES IT WORKED FINE, SOMETIMES IT RACED FROM 0 TO 120 MPH, MOVING BACK AND FORTH RAPIDLY,AND SOMETIMES IT RESTED ON 0 MPH WHILE CAR WAS IN MOTION. WHEN STOPPED AT STOP SIGN AND / OR RED LIGHT AND WHILE VEHICLE IN GEAR, VAN SOMETIMES STALLED. VAN OFTEN STALLED WHEN MOVING IN REVERSE. FEARED THAT VEHICLE WOULD LOSE POWER AT HIGH SPEED, RESULTING IN A COLLISION. DEALER WORKED ON VAN FOR ONE FULL DAY. RETURNED VAN CLAIMING THAT PROBLEM WAS CORRECTED; REPLACED OUTPUT SPEED SENSOR. WITHIN FIVE MINUTES AFTER LEAVING DEALER, SPEEDOMETER BEGAN MOVING ERRATICALLY AGAIN. VEHICLE HAS BEEN WITH DEALER FOR OVER ONE WEEK. DEALER CLAIMED THAT SPEEDOMETER WOULD NOT ACT UP FOR THEM LONG ENOUGH TO DETERMINE PROBLEM. DEALER WANTED LONER VEHICLE RETURNED, BUTOWNER REFUSED; NOT UNTIL PROBLEM WAS CORRECTED. VEHICLE PURCHASED JUNE 2001 AND HAD LESS THAN 29000 MILES WHEN MALFUNCTION WAS NOTICED -- EARLY OCTOBER 2003.*AK
NHTSA ODI #10048791
NHTSA investigations
3EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Illustration