IllustrationAIRBAG LIGHT KEEPS COMING ON & OFF INTERMITTENTLY ALONG WITH WARNING BELL. TOOK TO DEALERSHIP. DEALER SAID DRIVER SQUIBB CIRCUIT OPEN & THEY REPLACED THE CLOCKSPRING ASSEMBLY.*JB
2001 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
5325–50K
5150–75K
4175–100K
31100–150K
11150K+
200 reports with mileage · 98 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports1 fire reports8 injury reports
What owners actually said
298 reportsLAST WEDNESDAY MORNING ON MY WAY TO WORK ABOUT 4AM, WHILE PASSING A SEMI ON THE FREEWAY, MY HEADLIGHTS WENT OUT FOR ABOUT 4-5 SECONDS. THEY CAME BACK ON AND HAVE OPERATED WITHOUT A PROBLEM SINCE. I PURCHASED THE MINVAN NEW, (ORDERED IT), AND IT HAS GIVEN ME TROUBLEFREE MILES SINCE IT'S INCEPTION ON THE ROADS IN MICHIGAN, AS EXPE…
Read full complaint
LAST WEDNESDAY MORNING ON MY WAY TO WORK ABOUT 4AM, WHILE PASSING A SEMI ON THE FREEWAY, MY HEADLIGHTS WENT OUT FOR ABOUT 4-5 SECONDS. THEY CAME BACK ON AND HAVE OPERATED WITHOUT A PROBLEM SINCE. I PURCHASED THE MINVAN NEW, (ORDERED IT), AND IT HAS GIVEN ME TROUBLEFREE MILES SINCE IT'S INCEPTION ON THE ROADS IN MICHIGAN, AS EXPECTED BY A DAIMLERCHRYSLER MINIVAN. THERE WAS A CAUSE FOR CONCERN ON THIS SINGLE ISSUE ONLY, AND AS I DID CALL THE DEALER ABOUT IT, IT WAS SIMPLY SUGGESTED THAT I GET IT IN FOR THEM TO LOOK AT IT. WHAT GOOD IS THAT WHEN IT HAS OCCURED ONLY ONCE...............SO FAR. JUST WANTED IT ON THE RECORD WITHOUT GETTING "TOSSED OR SIDELINED". THANK YOU KINDLY.
THE CHECK ENGINE LIGHT CAME ON. I HAD IT CHECKED AND WAS TOLD THAT IT IS A COMPUTER FAILURE. (PCM HAS FAILURE.) THE VAN ONLY HAS 59,000 MILES ON IT. THE DODGE DEALERSHIP SAYS PCM IS NOT COVERED UNDER WARRANTY AND THERE IS A $900 CHARGE FOR REPLACEMENT. THE VAN HAS BEEN SERVICED REGULARLY AND I FEEL THAT SOMETHING THIS ESSENTIAL …
Read full complaint
THE CHECK ENGINE LIGHT CAME ON. I HAD IT CHECKED AND WAS TOLD THAT IT IS A COMPUTER FAILURE. (PCM HAS FAILURE.) THE VAN ONLY HAS 59,000 MILES ON IT. THE DODGE DEALERSHIP SAYS PCM IS NOT COVERED UNDER WARRANTY AND THERE IS A $900 CHARGE FOR REPLACEMENT. THE VAN HAS BEEN SERVICED REGULARLY AND I FEEL THAT SOMETHING THIS ESSENTIAL AND EXPENSIVE SHOULD NOT GO OUT ON A VAN THIS AGE WITH THIS MILEAGE. *NM
ENGINE HESITATES AND SPUTTERS BADLY WHEN PLACED INTO GEAR WITH BRAKE ON AND SPUTTERS BADLY WHEN ACCELERATING FROM A STOP. THIS PROBLEM HAPPENS MOSTLY WHEN THE AIR CONDITIONING IS ON. IT HAS BEEN IN THE SHOP TWICE FOR THIS PROBLEM. BUILT UP CARBON WAS CLEANED FROM THE INTAKE, BUT THE PROBLEM PERSISTS. ALSO, THE FAN SPEED SWI…
Read full complaint
ENGINE HESITATES AND SPUTTERS BADLY WHEN PLACED INTO GEAR WITH BRAKE ON AND SPUTTERS BADLY WHEN ACCELERATING FROM A STOP. THIS PROBLEM HAPPENS MOSTLY WHEN THE AIR CONDITIONING IS ON. IT HAS BEEN IN THE SHOP TWICE FOR THIS PROBLEM. BUILT UP CARBON WAS CLEANED FROM THE INTAKE, BUT THE PROBLEM PERSISTS. ALSO, THE FAN SPEED SWITCH WAS REPLACED BECAUSE IT ONLY WORKED ON HIGH. IT HAS FAILED AGAIN WITH THE SAME PROBLEM. *JB
DT: THE PROBLEM FIRST STARTED WITH THE DRIVER'S SIDE WINDOW IN APRIL 2005. THE WINDOW STARTED MOVING SLOWER AND THEN IT LOCKED. THE CONTACT TOOK VEHICLE TO THE DEALERSHIP ON APRIL 18, 2005, AND THEY REPLACED THE WINDOW MOTOR REGULATOR. THEN, THE PASSENGER'S SIDE WINDOW DID THE SAME THING OVER A PERIOD OF TIME. ON OCTOBE…
Read full complaint
DT: THE PROBLEM FIRST STARTED WITH THE DRIVER'S SIDE WINDOW IN APRIL 2005. THE WINDOW STARTED MOVING SLOWER AND THEN IT LOCKED. THE CONTACT TOOK VEHICLE TO THE DEALERSHIP ON APRIL 18, 2005, AND THEY REPLACED THE WINDOW MOTOR REGULATOR. THEN, THE PASSENGER'S SIDE WINDOW DID THE SAME THING OVER A PERIOD OF TIME. ON OCTOBER 7, 2005 IT LOCKED IN A LOWER POSITION. THE CONTACT WAS TAKING VEHICLE TO THE DEALERSHIP. *AK
I CURRENTLY OWN A 2001 DODGE GRAND CARAVAN-SPORT EDITION. THE VEHICLE HAD AN AIRBAG CLOCK SPRING REPLACED WHEN THE VEHICLE HAD ABOUT 25,000 MILES. TODAY THE VEHICLE HAS 48,600 MILES ON IT. THE AIRBAG LIGHT HAS COME ON ONCE AGAIN JUST LIKE THE FIRST TIME THE CLOCK SPRING FAILED. WHEN THE VEHICLE IS IN WARM WEATHER THE LIGHT GOES …
Read full complaint
I CURRENTLY OWN A 2001 DODGE GRAND CARAVAN-SPORT EDITION. THE VEHICLE HAD AN AIRBAG CLOCK SPRING REPLACED WHEN THE VEHICLE HAD ABOUT 25,000 MILES. TODAY THE VEHICLE HAS 48,600 MILES ON IT. THE AIRBAG LIGHT HAS COME ON ONCE AGAIN JUST LIKE THE FIRST TIME THE CLOCK SPRING FAILED. WHEN THE VEHICLE IS IN WARM WEATHER THE LIGHT GOES OFF. THIS HAS HAPPENED SEVERAL TIMES IN THE LAST FEW WEEKS. I HAVE CONTACTED THE DEALER THAT REPAIRED IT, I HAVE BEEN TOLD THAT THERE IS NO CURRENT RECALL FOR THIS PROBLEM. I HAVE BEEN ABLE TO FIND A RECALL FOR MODEL YEARS 1998-2000 THAT DESCRIBES THE SAME ISSUE WITH THE CLOCK SPRING. I FEEL THAT THE PROBLEM WAS NOT CORRECTED FOR THIS MODEL YEAR AS WELL. CAN YOU PLEASE INVESTIGATE THIS SIMILAR PROBLEM? *NM
TWO INCIDENTS: IN FEB 05, DAYLIGHT DRIVING APPROXIMATELY 4 MINUTES @45 MPH DURING RAINFALL, ALL THE DASH INFORMATION LIGHTS CAME ON AND WIPERS WOULD NOT TURN ON. PULLING OFF THE ROAD TO ASSESS THE SITUATION WITH THE VAN STILL RUNNING ALL THE DASH LIGHTS SUDDENLY WENT OUT. I CONTINUED TO DRIVE AND 1 MINUTE LATER ALL DASH LIGHTS …
Read full complaint
TWO INCIDENTS: IN FEB 05, DAYLIGHT DRIVING APPROXIMATELY 4 MINUTES @45 MPH DURING RAINFALL, ALL THE DASH INFORMATION LIGHTS CAME ON AND WIPERS WOULD NOT TURN ON. PULLING OFF THE ROAD TO ASSESS THE SITUATION WITH THE VAN STILL RUNNING ALL THE DASH LIGHTS SUDDENLY WENT OUT. I CONTINUED TO DRIVE AND 1 MINUTE LATER ALL DASH LIGHTS CAME ON AGAIN. AFRAID TO GO ON, PULLED INTO A PARKING LOT, PLACED VAN IN PARK AND DASH LIGHTS WOULD NOT GO OUT. TURNED OFF ENGINE, TRIED TO RESTART CAR. FIRST FEW TURNS OF KEY, NOTHING HAPPENED AND THEN THE CAR FINALLY TURNED OVER WITHOUT ANY DASH LIGHTS. DRIVING HOME IN RAIN, TURNED ON HEADLIGHTS/WIPERS AND MOMENTS LATER ALL DASH LIGHTS AGAIN CAME ON. AT THAT SAME TIME, THE HEADLIGHTS WENT OUT/WINDSHIELD WIPERS STOPPED UNCOMMANDED. MADE IT HOME/TURNED OFF ENGINE. SEVERAL ATTEMPTS TO RESTART ENGINE FAILED, NO DASH INFORMATION LIGHTS DURING START SEQUENCE, HAD TO HAVE VAN TOWED TO DODGE DEALER. THE DEALER DISCOVERED MAIN COMPUTER WAS FRIED. AFTER MANY HOURS/DAYS OF TROUBLE SHOOTING, WE WERE TOLD THE WIRING HARNESS TO COMPUTER WAS CHAFFED CAUSING THE PROBLEM WITH THE COMPUTER. DEALERSHIP REPAIRED THE WIRING HARNESS AND REPLACED THE COMPUTER WITH A REBUILT ONE. IN EARLY AUGUST 05 WHILE DRIVING IN DARKNESS, THE DASH LIGHTS/HEADLIGHTS STARTED TO CYCLE ON AND OFF UNCONTROLLED, ALL GAUGES WENT TO ZERO AND ALL SQUARES AROUND THE TRANSMISSION STATUS LIGHTS (P,R,N,D,L) WOULD ALL LIGHT UP. THE FAN WOULD ALL OF A SUDDEN TURN ON UNCOMMANDED AND NOT GO OFF UNTIL THE CAR WAS TURNED OFF. TOOK VAN UNDER OWN POWER TO DEALER. DETERMINED WIRING HARNESS BAD. TOOK ABOUT 3 WEEKS FOR HARNESS TO ARRIVE (9/23/05). EXPECT WORK TO BE COMPLETED BY 30 SEPTEMBER????? *NM
HEADLIGHT MALFUNCTION. 1 DAYTIME RUNNING LIGHT COMES ON. WHEN I TURN ON HEADLIGHTS, THE ONE THAT IS ON DURING DAYTIME RUNNING LIGHT OPERATION TURNS OFF, AND OTHER LIGHT TURNS ON. WHEN I SWITCH LIGHTS INTO HIGH BEAM MODE, THE LIGHTS REVERSE TO THE WAY THEY OPERATE WHILE IN DAYTIME RUNNING LIGHT OPERATION. I'VE ALREADY INVESTED $…
Read full complaint
HEADLIGHT MALFUNCTION. 1 DAYTIME RUNNING LIGHT COMES ON. WHEN I TURN ON HEADLIGHTS, THE ONE THAT IS ON DURING DAYTIME RUNNING LIGHT OPERATION TURNS OFF, AND OTHER LIGHT TURNS ON. WHEN I SWITCH LIGHTS INTO HIGH BEAM MODE, THE LIGHTS REVERSE TO THE WAY THEY OPERATE WHILE IN DAYTIME RUNNING LIGHT OPERATION. I'VE ALREADY INVESTED $200 INTO THE DIAGNOSIS OF THIS PROBLEM. THE REPAIR SHOP REPLACED THE LIGHT SWITCH AND TURN SIGNAL SWITCH WHICH DID NOT CORRECT ISSUE. SHOP SPENT TWO DAYS CHECKING ALL CONNECTIONS, LEADS AND GROUND AND THEY CAN NOT DIAGNOSE THE CAUSE OF THE PROBLEM. *JB
AIR BAG LIGHT IS ON WHEN CAR IS IN MOTION. DEALER SAID IT WAS A "CLOCKSPRING FAILURE" AND THAT IT NEEDED TO BE REPLACED.
DT: 2001 DODGE GRAND CARAVAN. THE CONSUMER STATES THE ABS WARNING LIGHT CAME ON TWICE. ALSO, THE MASTER CYLINDER WENT OUT. IT HAS BEEN REPLACED THREE TIMES. THE ABS SENSOR HAS BEEN REPLACED ON THE BACK WHEELS TWICE. NEARLY EVERYTHING ON THE BRAKE SYSTEM HAD TO BE REPLACED.*AK
Official recalls
304V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
01V152000 · Suspension:front:control Arm:lower Arm
May 8, 2001
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.