IllustrationDT*: THE CONTACT STATED WHEN THE ROAD CONDITIONS ARE WET AND COLD, THE REAR BRAKES FREEZE. THE BRAKES DRAG HARD AND THE REAR WHEELS WILL NOT TURN. THE DEALERSHIP IS UNABLE TO DUPLICATE THE PROBLEM. THE PROBLEM WAS A BUILD UP OF BRAKE DUST. UPDATED 02/27/06
2001 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
5325–50K
5150–75K
4175–100K
31100–150K
11150K+
200 reports with mileage · 98 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports1 fire reports8 injury reports
What owners actually said
298 reports1) EVENTS LEADING UP TO FAILURE: EACH TIME THIS HAS OCCURRED AFTER OR DURING A SUMMER VACATION TRIP THAT INCLUDED 700+ MILES. USE OF THE AC USUALLY CONTINUES ON LOW FAN SPEEDS (1 OR 2). 2) FAILURE AND CONSEQUENCES: FIRST FAILURE WOULD BE THE POWER WINDOWS WOULD BEGIN NOT TO WORK. SECOND A RELAY FUSE WOULD GO BAD. THEN THE SWITC…
Read full complaint
1) EVENTS LEADING UP TO FAILURE: EACH TIME THIS HAS OCCURRED AFTER OR DURING A SUMMER VACATION TRIP THAT INCLUDED 700+ MILES. USE OF THE AC USUALLY CONTINUES ON LOW FAN SPEEDS (1 OR 2). 2) FAILURE AND CONSEQUENCES: FIRST FAILURE WOULD BE THE POWER WINDOWS WOULD BEGIN NOT TO WORK. SECOND A RELAY FUSE WOULD GO BAD. THEN THE SWITCH THAT CONTROLS THE FAN SPEEDS WOULD SHORT OUT ONLY ALLOWING FOR HIGH FAN SPEED ONLY. 3)HAVE NOT BE ABLE TO FIX THE SWITCHES DUE TO DEALER CHARGING HIGH RATES JUST TO LOOK FOR THE ELECTRICAL FAILURE WITH NO GUARANTEE THEY WOULD BE ABLE TO FIND THE FAULT AND STILL WANTING $70+/HOUR BEFORE ANY REPAIR WORK IS STARTED. WE HAVE OWNED A 1996 CARAVAN AND 2001 GR CARAVAN AND THIS PROBLEM HAS HAPPENED ON BOTH VEHICLES. *JB
2001 DODGE GRAND CARAVAN - 41TE TRANSMISSION JUST QUIT AFTER 64,000 MILES WITH NO WARNING. GO TO THE FOLLOWING WEB SITES FOR TRANSMISSION DEFECT INFORMATION: HTTP://WWW.ALLPAR.COM/FIX/TRANS.HTML HTTP://WWW.GEOCITIES.COM/PLUMRAPTOR/ HTTP://WWW.DAIMLERCHRYSLERVEHICLEPROBLEMS.COM/. *JB
2001 DODGE GRAND CARAVAN. SIMILAR TO OTHER COMPLAINTS IN THE DATABASE ABOUT HEADLIGHTS GOING OFF WHILE DRIVING AND THEN AFTER 1 OR 2 SECONDS COMING BACK ON AGAIN. HAPPENS WHILE DRIVING AT ANY SPEED, ALSO SOMETIMES WHILE STOPPED. TOOK TO DEALER AND WAS TOLD THAT THEY COULD NOT FIND ANYTHING WRONG. THIS HAS HAPPENED APPROXIMAT…
Read full complaint
2001 DODGE GRAND CARAVAN. SIMILAR TO OTHER COMPLAINTS IN THE DATABASE ABOUT HEADLIGHTS GOING OFF WHILE DRIVING AND THEN AFTER 1 OR 2 SECONDS COMING BACK ON AGAIN. HAPPENS WHILE DRIVING AT ANY SPEED, ALSO SOMETIMES WHILE STOPPED. TOOK TO DEALER AND WAS TOLD THAT THEY COULD NOT FIND ANYTHING WRONG. THIS HAS HAPPENED APPROXIMATELY 5 TIMES OVER THE PAST 2 MONTHS, THE DATE I ENTERED IS THE MOST RECENT OCCURRENCE. *JB
DT: THE CONTACT STATED THE AIR BAG LIGHT HAS BEEN ILLUMINATING INTERMITTENTLY SINCE 2003. THE CONTACT NOTICED THE LIGHT ILLUMINATES ONCE THE VEHICLE HAS HEATED UP. THE VEHICLE WAS TAKEN TO THE DEALERSHIP ON JULY 1, 2003 BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM THEREFORE NO REPAIRS WERE MADE. ON DECEMBER 27, 2004 THE VEHICL…
Read full complaint
DT: THE CONTACT STATED THE AIR BAG LIGHT HAS BEEN ILLUMINATING INTERMITTENTLY SINCE 2003. THE CONTACT NOTICED THE LIGHT ILLUMINATES ONCE THE VEHICLE HAS HEATED UP. THE VEHICLE WAS TAKEN TO THE DEALERSHIP ON JULY 1, 2003 BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM THEREFORE NO REPAIRS WERE MADE. ON DECEMBER 27, 2004 THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP WHILE THE LIGHT WAS ILLUMINATED. THE DEALERSHIP REPLACED A FAILED CLOCK SPRING BUT THE REPAIR WAS UNSUCCESSFUL.
THE AIR BAG LIGHT GOES ON AND OFF PERIODICALLY. THERE WAS CONCERN THAT THE AIR BAG WOULD NOT DEPLOY WHEN NEEDED OR, CONVERSELY, IT WOULD DEPLOY WITHOUT ANY WARNING. TOOK IT TO THE DEALER, HE INDICATED THAT A SPRING NEEDED TO BE REPLACED. AS I WAS LOOKING INTO RECALLS FOR THIS PROBLEM, I NOTICED THAT, ALTHOUGH THERE WAS NO RECALL…
Read full complaint
THE AIR BAG LIGHT GOES ON AND OFF PERIODICALLY. THERE WAS CONCERN THAT THE AIR BAG WOULD NOT DEPLOY WHEN NEEDED OR, CONVERSELY, IT WOULD DEPLOY WITHOUT ANY WARNING. TOOK IT TO THE DEALER, HE INDICATED THAT A SPRING NEEDED TO BE REPLACED. AS I WAS LOOKING INTO RECALLS FOR THIS PROBLEM, I NOTICED THAT, ALTHOUGH THERE WAS NO RECALL, THERE WERE PLENTY OF COMPLAINTS. WHY IS THIS DEFECT ALLOWED TO CONINUE TO GIVE CONSUMERS PROBLEMS, BUT THERE IS NO ACTION FROM THE MANUFACTURER TO FIX VIA A RECALL? *NM
I PURCHASED A 2001 DODGE GRAND CARAVAN IN AUGUST OF 2005 WITH 73K MILES. VEHICLE SMELLED MUSTY (STAGNANT WATER). THREE TRIPS TO SHOP TO DIAGNOSE AND FIX SWAY BAR LINK, BUSHING, STRUT AND STRUT MOUNT PROBLEM TO CURE A CLUNKING SOUND ON FRONT END. TRANSMISSION SLIPS OUT OF GEAR TO NEUTRAL AT WHIM. ALSO, SHIFTS THROUGH FIRST 3 GE…
Read full complaint
I PURCHASED A 2001 DODGE GRAND CARAVAN IN AUGUST OF 2005 WITH 73K MILES. VEHICLE SMELLED MUSTY (STAGNANT WATER). THREE TRIPS TO SHOP TO DIAGNOSE AND FIX SWAY BAR LINK, BUSHING, STRUT AND STRUT MOUNT PROBLEM TO CURE A CLUNKING SOUND ON FRONT END. TRANSMISSION SLIPS OUT OF GEAR TO NEUTRAL AT WHIM. ALSO, SHIFTS THROUGH FIRST 3 GEARS (AUTOMATIC) AT WHIM CAUSING VEHICLE TO LURCH. HOWEVER, SHOP CANNOT DUPLICATE THESE PROBLEMS OR THE PROBLEM WITH MY NON WORKING CRUISE CONTROL. AT THIS POINT, I HAVE SPENT A LOT OF MONEY FOR NON-DIAGNOSIS. THE DEALERSHIP CHARGES EVERYTIME FOR NOT BEING ABLE TO FIND THE PROBLEM. THEY SAY IT IS FINE. I TELL THEM THAT IT IS NOT FINE THAT THEY JUST CAN'T FIND IT. I AM DISTURBED BY THE NUMBER OF POSTS RE: TO SWAY BAR PROBLEMS AND TRANSMISSION PROBLEMS AND THE FACT THAT NO ONE IS HOLDING CHRYSLER/DODGE ACCOUNTABLE. WILL IT TAKE A NUMBER OF DEATHS TO DETERMINE THAT THIS IS A REAL SAFETY ISSUE? I IMPLORE YOU TO INVESTIGATE THESE PROBLEMS ALONG WITH THE WATER ISSUE. SO FAR IT CAUSED MY BLOWER RESISTOR TO SHORT OUT AND NEED REPLACING. I HAD NO HEAT IN BELOW ZERO WEATHER. *JB
DT: THE CONTACT STATED THE HEADLIGHTS FLICKERED ON AND OFF WHILE ON LOW BEAMS. HE WAS UNSURE WHETHER IT WOULD HAPPEN WITH THE HIGH BEAMS ON. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THEY REPLACED THE MULTIFUNCTION SWITCH. THIS DID NOT CORRECT THE PROBLEM. THE VEHICLE IS CURRENTLY AT THE DEALERSHIP FOR REPAIRS. *AK
RADIO MALFUNCTIONING INTERMITTENTLY OVER APPROXIMATELY ONE MONTH EVENTUALLY LEADING UP TO COMPLETE FAILURE. SMELLED SMOKE. HEARD OF RECALL ON RADIO. SPOKE WITH DEALERSHIP. DEALERSHIP SAID MY VEHICLE IS NOT INVOLVED WITH RECALL ANNOUNCEMENT. DEALER CHECKED AND FOUND NO PROBLEMS RELATED TO RECALL. SUBSEQUENT ELECTRICALLY-RELATED F…
Read full complaint
RADIO MALFUNCTIONING INTERMITTENTLY OVER APPROXIMATELY ONE MONTH EVENTUALLY LEADING UP TO COMPLETE FAILURE. SMELLED SMOKE. HEARD OF RECALL ON RADIO. SPOKE WITH DEALERSHIP. DEALERSHIP SAID MY VEHICLE IS NOT INVOLVED WITH RECALL ANNOUNCEMENT. DEALER CHECKED AND FOUND NO PROBLEMS RELATED TO RECALL. SUBSEQUENT ELECTRICALLY-RELATED FAILURES IN RECENT MONTHS INVOLVING HEADLIGHTS, FUEL GAUGE LIGHT, WINDSHIELD WIPER LIGHT, WASHER FLUID PUMP, DEAD BATTERY. *JB
DT: CONTACT STATES THERE WAS A FAILURE ON THE SIDEWALL OF THE TIRE THAT CAUSED COMPLETE LOSS OF TIRE PRESSURE. THE TIRE WAS A GOODYEAR INTEGRITY. HE HAD THE TIRE REPLACED WITH THE EXACT BRAND OF TIRE. DURING THE SAME MONTH, ANOTHER TIRE EXPERIENCED THE SAME PROBLEM. THE REPLACEMENT AGAIN, WAS THE SAME BRAND OF TIRE. THE TIRE…
Read full complaint
DT: CONTACT STATES THERE WAS A FAILURE ON THE SIDEWALL OF THE TIRE THAT CAUSED COMPLETE LOSS OF TIRE PRESSURE. THE TIRE WAS A GOODYEAR INTEGRITY. HE HAD THE TIRE REPLACED WITH THE EXACT BRAND OF TIRE. DURING THE SAME MONTH, ANOTHER TIRE EXPERIENCED THE SAME PROBLEM. THE REPLACEMENT AGAIN, WAS THE SAME BRAND OF TIRE. THE TIRE DEALER SAID THE FAILURES WERE NOT DUE TO A DEFECT IN THE TIRES. AFTER APPROXIMATELY 7 MONTHS ONE OF THE NEW TIRES STARTED EXPERIENCING THE SAME PROBLEM. *NM
Official recalls
304V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
01V152000 · Suspension:front:control Arm:lower Arm
May 8, 2001
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.