IllustrationFREEZER PLUGS IN ENGINE ARE RUSTING OUT WHICH RESULTED IN ENGINE OVERHEATING. DEALER HAS BEEN CONTACTED. PLEASE PROVIDE ANY FURHTER INFORMATION.*AK
2000 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
4425–50K
5450–75K
3875–100K
64100–150K
29150K+
248 reports with mileage · 194 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports13 fire reports15 injury reports
What owners actually said
442 reportsWE WERE ON VACATION TO THE MOUNTAINS AND HAD JUST HAPPENED TO STOP AT A VISITORS CENTER. WE HEARD A LOUD POPPING NOISE. THE CAR WOULD MOVE FORWARD AND BACKWARDS BUT THE POWER STEERING WAS NOT WORKING LEAVING US UNABLE TO STEER THE CAR. HAD WE BEEN ON THE HIGHWAY GOING 65 MPH OR IN THE MOUNTAINS ON SWITCH BACKS WHEN IT BROKE TH…
Read full complaint
WE WERE ON VACATION TO THE MOUNTAINS AND HAD JUST HAPPENED TO STOP AT A VISITORS CENTER. WE HEARD A LOUD POPPING NOISE. THE CAR WOULD MOVE FORWARD AND BACKWARDS BUT THE POWER STEERING WAS NOT WORKING LEAVING US UNABLE TO STEER THE CAR. HAD WE BEEN ON THE HIGHWAY GOING 65 MPH OR IN THE MOUNTAINS ON SWITCH BACKS WHEN IT BROKE THIS COULD HAVE PROVED FATAL. THE DODGE DEALER SAID THE TENSIONER HAD BROKEN AND THEY HAD TO REPLACE THE WHOLE PIECE. *AK *NLM **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS*753523
THE CONSUMERS CHILD DOES NOT FIT PROPERLY INTO THE INTEGRATED CHILD SAFETY SEAT WHICH SAY IT HOLDS CHILDREN 22 LBS. AND OVER, THE STRAPS ARE VERY LOOSE EVEN AT THE TIGHTEST POSITION. NLM
THERE IS A NOISE IN STEERING WHEEL, VEHICLE VIBRATES WHEN CHANGING FROM DRIVE TO REVERSE GEAR. CONTACTED DEALER. ELECTRICAL SYSTEM PROBLEM *AK
1ST INCIDENT: JOHN ELWAY DODGE SERVICE ON 12/27/2000 FOR FINAL INSPECTION FROM THE SALE. ASKED TO CHECK RATTLE IN THE FRONT RIGHT DASH AND THE BRAKES, WHICH ACTED SOFT. NO PAPERWORK WAS GIVEN. 2ND TIME OCCURRED 11/13/2001: THE BRAKE PROBLEMS REPORTED TO JOHN ELWAY DODGE SERVICE, UNABLE TO GET IN BEFORE 2+ WEEKS. BROUGHT TO CHRI…
Read full complaint
1ST INCIDENT: JOHN ELWAY DODGE SERVICE ON 12/27/2000 FOR FINAL INSPECTION FROM THE SALE. ASKED TO CHECK RATTLE IN THE FRONT RIGHT DASH AND THE BRAKES, WHICH ACTED SOFT. NO PAPERWORK WAS GIVEN. 2ND TIME OCCURRED 11/13/2001: THE BRAKE PROBLEMS REPORTED TO JOHN ELWAY DODGE SERVICE, UNABLE TO GET IN BEFORE 2+ WEEKS. BROUGHT TO CHRISTOPHER'S DODGE WORLD, INC. 16655 W. COLFAX AVE. GOLDEN, CO 80401 303-238-7311. STATED THAT THE BRAKES FAILED WHEN TRIED TO STOP (PETAL FELT LIKE IT WENT TO THE FLOOR, BUT YET THE VAN DID NOT STOP.) ALSO COMPLAINED ABOUT THE RATTLE IN THE DASH AND ENGINE VIBRATION AT IDLE. INVOICE #24497 WHICH STATES EACH COMPLAINT AND THE FINDINGS A) ENGINE VIBRATION - UNABLE TO DUPLICATE CUSTOMERS COMPLAINT. B) RATTLE NOISE IN R/DASH - CAUSE: REPLACED BELT AND TENSIONER AND REPOSITIONED FUEL LINES. C) BRAKES - CLEAN, INSPECT, AND ADJUST REAR BRAKES. D) THE TRANSMISSION NEEDED TO BE SERVICED- BUT MY WIFE DECLINED. THE BILL WAS $62.00 AND THE MILEAGE WAS 13362. THE 3RD TIME @ A WEEK PRIOR TO 1/10/2002. COMPLAINED THE BRAKES WHEN DRIVING ON DRY GROUND WILL ACT AS IF THE ABS IS WORKING, THE VEHICLE SEEMS TO HAVE A SOFT PETAL AND NOT STOP THE VEHICLE PROPERLY. FINDINGS: A) TRANSMISSION - NOT DUE FOR SERVICE UNTIL 40K (FLUID CONFIRMED BY SERVICE MANAGER AT MY WIFE'S REQUEST DUE TO LAST SERVICE AT CHRISTOPHER' DODGE.) B) BRAKES- FOUND TO BE OPERATING NORMAL. MILEAGE WAS 15747. THE FOURTH TIME JUNE 2002- PUSHED ON BRAKES BUT WENT THROUGH STOP SIGN. THE 5TH TIME 7/1/02 UNDER 15 MPH PRESSED ON BRAKES, FOOT FELT LIKE IT WENT TO THE FLOOR NOT STOPPING, PUMPED BRAKES TWICE THEN PUSHED AGAIN FELT LIKE FOOT TO THE FLOOR HIT FROM BEHIND. DRIVER STATED THAT THE BRAKE LITE FLICKERED ONCE, VAN STILL GOING THEN BRAKE LITE ON WHEN HIT. NO DAMAGE, NO MAJOR INJURIES (WIFE'S RIGHT COLLAR BONE RED) 2 TODDLERS AND 2 ADULTS IN VAN. CALLED JOHN ELWAY- VAN IN NEXT DAY. MILES 22772. FINDINGS: COULD NOT VERIFY CONCERN AT THIS TIME. CHRYSLER INSPECTS SAME FINDINGS. VAN AT JOHN ELWAY.*
FUSE FOR TURN SIGNALS AND ABS LIGHT ON DASH KEEPS BLOWING, DEALER REPLACED FUSE 4 TIMES IN 3 WEEKS.*AK. CONSUMER STATED THE DEALER FOUND THE WIRE CASING RUNNING UNDER THE VEHICLE HITTING THE TRANSMISSION AND OVER TIME IT HAD WORN THROUGH THE COATING.*JB
REQUESTED INSPECTION DISCLOSED " FRONT BRAKES WERE OVERHEATED ANND WERE BLUED AND HAD FRONT BRAKE PADS SEPARATING FROM THE PAD BACKING WE AVOID CRASH STOPS AND DO LITTLE HILL DRIVING. PROBABLE MANUFACTURING DEFECT.*AK
VAN DROPS INTO NUETRAL WHEN DRIVING, DEALER CAN'T FIND ANYTHING, DODGE WON'T DO ANYTHING. BEEN IN SHOP REPEATEDLY. NOT REPAIRED GOINTTO KILL SOMEONE NEARLY REARENDED.*AK
VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE AND DRIVER'S SIDE SEATBACK COLLAPSED. CONSUMER STATED THAT SEATBACK SHOULD NOT HAVE COLLAPSED SO THAT DRIVER COULD HAVE NECK SUPPORT. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
AS THE CONSUMER TURNED THE KEY IN THE IGNITION, NOT EVEN HAVING TIME TO PLACE THE GEAR INTO DRIVE, THE VEHICLE TOOK OFF WITH A POWER SURGE IN REVERSE.*YHCONSUMER WAS PARKED IN THE DRIVEWAY IN THE PARK POSITION, WHILE TURNING THE IGNITION, STILL IN PARK, THE VEHICLE TOOK OFF IN REVERSE DOWN THE DRIVEWAY, ACROSS THE ALLEY, AND LAN…
Read full complaint
AS THE CONSUMER TURNED THE KEY IN THE IGNITION, NOT EVEN HAVING TIME TO PLACE THE GEAR INTO DRIVE, THE VEHICLE TOOK OFF WITH A POWER SURGE IN REVERSE.*YHCONSUMER WAS PARKED IN THE DRIVEWAY IN THE PARK POSITION, WHILE TURNING THE IGNITION, STILL IN PARK, THE VEHICLE TOOK OFF IN REVERSE DOWN THE DRIVEWAY, ACROSS THE ALLEY, AND LANDED IN THE NEIGHBORS POOL. *JG
Official recalls
510V270000 · Seats
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
04V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V505000 · Equipment:other:labels
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available