1. HAD A FLAT AND TRIED TO LOWER THE SPARE TIRE WHICH IS HELD UP BY A WINCH UNDERNEATH THE VEHICLE. 2. FOLLOWED THE INSTRUCTIONS IN THE VEHICLE TO LOWER THE SPARE TIRE USING THE SUPPLIED WRENCH; HOWEVER, THE TIRE WOULD ONLY LOWER ABOUT TWO INCHES AND NOT LOWER FAR ENOUGH FOR THE SPARE TO BE REMOVED FROM THE 'T' THAT HOLDS IT IN…
Read full complaint
1. HAD A FLAT AND TRIED TO LOWER THE SPARE TIRE WHICH IS HELD UP BY A WINCH UNDERNEATH THE VEHICLE. 2. FOLLOWED THE INSTRUCTIONS IN THE VEHICLE TO LOWER THE SPARE TIRE USING THE SUPPLIED WRENCH; HOWEVER, THE TIRE WOULD ONLY LOWER ABOUT TWO INCHES AND NOT LOWER FAR ENOUGH FOR THE SPARE TO BE REMOVED FROM THE 'T' THAT HOLDS IT IN PLACE WHEN THE WHEEL IS SECURED. 3. THE SPARE WOULD NOT COME DOWN SO I HAD TO REMOVE THE FLAT TIRE FROM THE VEHICLE AND GET A RIDE TO GET THE WHEEL FIXED THEN GET A RIDE BACK TO THE VEHICLE TO RE-INSTALL THE TIRE. AFTER SEVERAL ATTEMPTS AT LOWERING THE SPARE, I STILL COULD NOT GET IT TO COME DOWN SO I TOOK THE VEHICLE TO AND AUTO REPAIR SHOP. THE REPAIR SHOP WAS NOT ABLE TO GET THE WHEEL TO COME DOWN EITHER AND HAD TO CUT THE "T" TO REMOVE THE WHEEL. *TR
NHTSA ODI #10232281
Mileage unknown · Jan 4, 2008
Wheels
WE HIT A POT HOLE IN THE ROAD GOING ABOUT 40MPH, THE RIGHT FRONT ALLOY WHEEL ON OUR DODGE GRAND CARAVAN ACTUALLY SPIT IN HALF. THIS COULD HAVE CAUSE SERIOUS ACCIDENT, THANKFULLY IT DIDN'T. CHRYSLER SHOULD HAVE TO DO SOMETHING ABOUT THIS AS THIS SHOULD NEVER HAPPEN TO A WHEEL LIKE THIS.*CN
NHTSA ODI #10213740
60,000 miles · Oct 7, 2005
StructureWheels
2000 GRAND CARAVAN HAS MULTIPLE RUST POINTS. THE MOST DANGEROUS OF WHICH IS THE RUSTING AND DETERIORATION OF THE FRONT LEFT STRUT. THE TOP PORTION OF THE STRUT COVER IS RUSTED AND FALLING APART, WITH A CRACK IN IT. OTHER PARTS OF THE CAR THAT ARE SHOWING MANY RUST AREAS INCLUDE: PASSENGER DOOR (CAN PUT FINGER THROUGH RU…
Read full complaint
2000 GRAND CARAVAN HAS MULTIPLE RUST POINTS. THE MOST DANGEROUS OF WHICH IS THE RUSTING AND DETERIORATION OF THE FRONT LEFT STRUT. THE TOP PORTION OF THE STRUT COVER IS RUSTED AND FALLING APART, WITH A CRACK IN IT. OTHER PARTS OF THE CAR THAT ARE SHOWING MANY RUST AREAS INCLUDE: PASSENGER DOOR (CAN PUT FINGER THROUGH RUST), HOOD (BUBBLING PAINT AND CRACKING), PAINT PEELING FROM ANTENNA HOUSING, REAR HATCH RUST, LEFT REAR WHEEL BASIN. MY LARGEST CONCERN IS THE STRUT RUST FOR SAFETY ISSUES, BUT THIS VEHICLE SHOULD NOT BE RUSTING SO POORLY BEING ONLY 5 YEARS OLD! *NM
NHTSA ODI #10139022
Mileage unknown · Apr 30, 2002
Wheels
VEHICLE HAS 16 INCH WHEELS AND FULL WHEEL COVERS (HUB CAPS). I REMOVED THE WHEEL COVERS AT ABOUT 56000 MILES TO ROTATE THE TIRES. THIS IS THE FIRST TIME THAT I HAD REMOVED THE COVERS. WHEN I REMOVED THE COVERS THREE OR FOUR OF THE MOLDED PLASTIC CLIPS BROKE OFF ALL FOUR COVERS. I CONTACTED THE DEALER WHO CONTACTED CHRYSLER REP G…
Read full complaint
VEHICLE HAS 16 INCH WHEELS AND FULL WHEEL COVERS (HUB CAPS). I REMOVED THE WHEEL COVERS AT ABOUT 56000 MILES TO ROTATE THE TIRES. THIS IS THE FIRST TIME THAT I HAD REMOVED THE COVERS. WHEN I REMOVED THE COVERS THREE OR FOUR OF THE MOLDED PLASTIC CLIPS BROKE OFF ALL FOUR COVERS. I CONTACTED THE DEALER WHO CONTACTED CHRYSLER REP GREG JANKOWSKI WHO REFUSED ANY ASSISTANCE DUE TO MILEAGE. I CONTACTED CHRYSLER CUSTOMER RELATIONS REP MARTIN SHAGER WHO REFUSED ANY ASSISTANCE DUE TO MILEAGE. I HAVE LOST ONE COVER ON THE ROAD. WHEN WHEEL COVERS COME OFF AT ROAD SPEEDS, I SEE THAT AS A SAFETY PROBLEM. I DO NOT SEE MILEAGE AS AN ISSUE. IF THE PLASTIC RETAINING CLIPS BREAK OFF IN TWO YEARS, I SEE THAT AS A STRUCTURE OR MATERIAL PROBLEM.*AK
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2000 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration