IllustrationDISFUNCTIONAL FRONT END HEIGHT CAUSING FRONT BUMPER TO GRAB WHEN PARKING AT PARKING BUMPERS, WHICH TORE LOOSE THE BUMPER/FENDER. ALSO MAKES IT SO THAT IT BOTTOMS OUT AT NORMAL DRIVING CONDITIONS.
2000 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
4425–50K
5450–75K
3875–100K
64100–150K
29150K+
248 reports with mileage · 194 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports13 fire reports15 injury reports
Suspension complaints
56 reportsVEHICLE CONSTANTLY VIBRATES. FASTER VEHICLE GOES, THE FASTER IT VIBRATES. DEALER HAS REPLACED FRONT AND REAR BEARINGS/ PUT A 2ND SET OF TIRES/ CHANGED STRUTS, AND REALIGNED THE VEHICLE TO RECTIFY PROBLEM, NOTHING WORKS. *AK *SLC
HAVE HAD FRONT-END SUSPENSION CLUNK/KNOCKING SOUND WHEN TRAVELING 30-35 MPH. SERVICE DEPT. HAS NEVER BEEN ABLE TO FIX PROBLEM. THERE HAVE BEEN TSB'S RELATING, BUT PROCEDURE DIDN'T WORK.*AK
OUR VEHICLE IS ON TRANSMISSION #3 AND IT IS LESS THAN 7 MONTHS OLD. IT ALSO HAS A FRONT END SUSPENSION PROBLEM THEY HAVEN'T BEEN ABLE TO FIX. IT HAS BEEN IN THE SHOP A TOTAL OF ALMOST 30 DAYS AND OUT OF COMMISSION FOR ABOUT 37.
THE AUTOMATIC TRANSMISSION SHUDDERS BETWEEN 45-52 (MOST PRONOUNCED AROUND 48) AND DID SO WHEN I DROVE THE CAR OFF THE LOT NEW ON 1/14/00. WHEN I TOOK THE CAR TO THE DEALER FOR SERVICE I WAS FIRST TOLD IT WAS TIRE BALANCE AND THAT THEY FIXED IT. IT DIDN'T AND I BROUGHT IT BACK. THE SERVICE MAN SAID IT SOUNDED LIKE THE TORQUE CONV…
Read full complaint
THE AUTOMATIC TRANSMISSION SHUDDERS BETWEEN 45-52 (MOST PRONOUNCED AROUND 48) AND DID SO WHEN I DROVE THE CAR OFF THE LOT NEW ON 1/14/00. WHEN I TOOK THE CAR TO THE DEALER FOR SERVICE I WAS FIRST TOLD IT WAS TIRE BALANCE AND THAT THEY FIXED IT. IT DIDN'T AND I BROUGHT IT BACK. THE SERVICE MAN SAID IT SOUNDED LIKE THE TORQUE CONVERTER. IT WAS COMPUTER TESTED OK AND THEIR MECHANIC ADDED SOME LIQUID TO THE TRANSMISSION. I'VE DRIVEN IT TO FL AND BACK TO TN AND THE PROBLEM STILL EXISTS. THE OTHER COMPLAINT/DEFECT CONCERNS RUSTED FRONT END COMPONENTS. UPPER AND LOWER CONTROL ARMS LEFT & RIGHT, TORSION BAR AND OTHER PARTS IN THAT AREA ARE VERY RUSTY. I NOTICE IT WHEN I CHANGED OIL. I WENT TO ANOTHER DEALER AND LOOKED UNDER THOSE VANS AND FOUND THOSE PARTS ALSO RUSTY ALSO ON NEW VANS. IT SEEMS THERE IS NO COATING OR ANODIZING ON THESE PARTS AND THEY ARE RUSTING VERY RAPIDLY. I ALSO NOTICED RUST ON THE MAIN CRANK PULLEY OF THIS NEW CAR. *AK
LOWER CONTROL ARM ON MY 2000 GRAND CARAVAN SNAPPED OFF AT 25MPH. AS A RESULT OF THE BROKEN BOLT, THE CAR CAME TO A SCREECHING HALT IN THE MIDDLE OF THE ROAD AND THE LEFT FRONT TIRE WAS AT A 90 DEGREE ANGLE. I AM IN THE STRESS TESTING BUSINESS AND I HAD THE BOLT VISUALLY ANALYZED BY MY ENGINEERS. THEY CONCLUDE THE BOLT HAD CON…
Read full complaint
LOWER CONTROL ARM ON MY 2000 GRAND CARAVAN SNAPPED OFF AT 25MPH. AS A RESULT OF THE BROKEN BOLT, THE CAR CAME TO A SCREECHING HALT IN THE MIDDLE OF THE ROAD AND THE LEFT FRONT TIRE WAS AT A 90 DEGREE ANGLE. I AM IN THE STRESS TESTING BUSINESS AND I HAD THE BOLT VISUALLY ANALYZED BY MY ENGINEERS. THEY CONCLUDE THE BOLT HAD CONSIDERABLE FATIGUE. I AM VERY CONCERNED ABOUT THIS DEFECT. I WOULD HAVE BEEN KILLED IF I WAS GOING FASTER. I HAVE A MEETING WITH CHRYSLER ON MONDAY TO DISCUSS THIS SITUATION AND MY OPTIONS. I AM VERY CONFUSED ABOUT WHAT I SHOULD DO AND WHAT MY RIGHTS ARE. CAN THE NHTSA HELP ME? *AK
Official recalls
510V270000 · Seats
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
04V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V505000 · Equipment:other:labels
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available