IllustrationHEATING/AIRCONDITIONING FAN SWITCH WOULD NOT FUNCTION IN ONE POSITION, TRACED PROBLEM TO BURNED UP AND SHORT OUT CONNECTOR AND RESISITOR CONNECTOR IN ENGINE COMPARTMENT THAT OPERATED HEATING/AIR CONDITIONING FAN SPEED. REPLACED PARTS. POOR DESIGN, WILL NOT ACCEPT ELECTRICAL LOAD OVER EXTENDED OPERATION. OLD PARTS AVALIBLE. *AK
2000 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
4425–50K
5450–75K
3875–100K
64100–150K
29150K+
248 reports with mileage · 194 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports13 fire reports15 injury reports
Electrical System complaints
34 reportsDT*: THE CONTACT STATED, THE AIR BAG WARNING LIGHT FAILED TO ILLUMINATE DURING AN EMISSIONS TEST PERFORMED ON 7/21/06. THE LIGHT WORKED UNTIL 6/23/2006, WHEN THE SERVICE DEALER PERFORMED RECALL #04V480000. THE SERVICE DEALER INFORMED THE CONTACT THE WARNING LIGHT WAS NOT PART OF THE RECALL.
LOCK CYLINDER ENGAGES COLUMN LOCK AND WILL NOT DISENGAGE. ONGOING PROBLEM THAT HAS GOTTEN INCREASING HARDER TO GET THE COLUMN TO RELEASE. PER DEALER TSB ON PROBLEM. WILL HAVE TO HAVE DRILLED OUT AND REPLACED. *NM
DT: THE CONTACT STATED THERE HAVE BEEN NUMEROUS ELECTRICAL PROBLEMS WHICH RESULTED IN THE DASHBOARD PANEL LIGHTS FLASHING ON AND OFF WHILE DRIVING. SHE TOOK THE VEHICLE TO A DEALER FOR MULTIPLE ATTEMPTS TO CORRECT THIS PROBLEM. ALSO, THERE WAS A LEAK WITHIN THE ROOF, RESULTING IN DAMAGE TO THE CARPETING. THERE IS A SLASHING…
Read full complaint
DT: THE CONTACT STATED THERE HAVE BEEN NUMEROUS ELECTRICAL PROBLEMS WHICH RESULTED IN THE DASHBOARD PANEL LIGHTS FLASHING ON AND OFF WHILE DRIVING. SHE TOOK THE VEHICLE TO A DEALER FOR MULTIPLE ATTEMPTS TO CORRECT THIS PROBLEM. ALSO, THERE WAS A LEAK WITHIN THE ROOF, RESULTING IN DAMAGE TO THE CARPETING. THERE IS A SLASHING SOUND WITHIN THE ROOF COMPARTMENT AFTER A HEAVY RAIN. THE CARPET HAS BEEN REPLACED FIVE TIMES, AND THE TELEVISION WAS REPLACED ONCE AS A RESULT OF THE LEAK. *AK. UPDATED 11/30/2005 - GLAZED SERPENTINE BELT CAUSED GRINDING NOISE WHEN TURNING. THE LEFT MIDDLE SEAT HEAD REST CAME LOOSE FROM THE GUIDE ROD. THE DOOR STICKS AND THE SIDING DOOR MAKES NOISE WHEN OPENING. THE REAR WINDOW RATTLES WHEN OPENED. THE FOG LIHJT ARE IONPERTIVE. THE HORN SPUNDED WEAK BECAUSE THE KEYLESS ENTRY REMOTE NEEDED TO BE REPROGRAMMED. THE TAIL LIGHT HAD MOISTURE IN IT. THE LOCKING GAS CAP WAS HARD TO OPEN. THE REAR TIRE HAD A SLOW LEAK. *NM
2000 PONTIAC GRAND AM SAFETY RECALL REGARDING CLOCKSPRING REPLACEMENT.*MR THE CLOCKSPRING RECALL WAS REPAIRED THE FUSE FOR THE BLOWER MOTOR, THE BACK UP LAMPS AND TURN SIGNAL BLEW OUT WHEN THE VEHICLE WAS PUT IN REVERSE. *NM
WHILE DRIVING VEHICLE SHUTS DOWN COMPLETLY IF KEY IS TURNED OFF VEHICLE WILL MOST TIMES RESTART,SEVERAL TIMES VEHICLE WOULD ONLY START AFTER WAITING SEVERAL HOURS THIS HAPPENS SPORATICALLY ABOUT ONCE A WEEK VEHICLE HAS LESS THAN 20,000 MILES FUEL FILTER REPLACED OLD FILTER UNAVAILABLE STARTER RELAY REPLACED OLD RELAY IS …
Read full complaint
WHILE DRIVING VEHICLE SHUTS DOWN COMPLETLY IF KEY IS TURNED OFF VEHICLE WILL MOST TIMES RESTART,SEVERAL TIMES VEHICLE WOULD ONLY START AFTER WAITING SEVERAL HOURS THIS HAPPENS SPORATICALLY ABOUT ONCE A WEEK VEHICLE HAS LESS THAN 20,000 MILES FUEL FILTER REPLACED OLD FILTER UNAVAILABLE STARTER RELAY REPLACED OLD RELAY IS AVAILABLE
I PURCHASED MY VEHICLE 2 WEEKS AGO WHEN I WAS DRIVING DOWN THE FREEWAY, IT FELT LIKE I HIT SOMETHING BUT NOTHING WAS IN THE ROAD. I ASSUMED I HAD A BLOWOUT. WHEN I PULLED TO THE SIDE OF THE ROAD THE HOOD WAS SMOKING, AND THE TIRES WERE FINE. I THEN PROCEEDED TO OPEN THE HOOD TO FIND A FIRE. THE FIRE DEPARTMENT CAME TO PUT OUT TH…
Read full complaint
I PURCHASED MY VEHICLE 2 WEEKS AGO WHEN I WAS DRIVING DOWN THE FREEWAY, IT FELT LIKE I HIT SOMETHING BUT NOTHING WAS IN THE ROAD. I ASSUMED I HAD A BLOWOUT. WHEN I PULLED TO THE SIDE OF THE ROAD THE HOOD WAS SMOKING, AND THE TIRES WERE FINE. I THEN PROCEEDED TO OPEN THE HOOD TO FIND A FIRE. THE FIRE DEPARTMENT CAME TO PUT OUT THE FIRE AND SUGGESTED THAT IT WAS AN ELECTRICAL MALFUNCTION. I AM CURRENTLY IN THE PROCESS OF HAVING THE VEHICLE EVALUATED TO FIND OUT IF THIS IS TRUE. *JB
THE SWITCH THAT CONTROLS THE LIGHTING ON THE INSTRUMENT PANEL AND THE DOME LIGHTS WOULD INTERMITTENTLY MAKE A BUZZING NOISE, AND CAUSES THE PANEL LIGHTS TO FLICKER WHILE DRIVING AT NIGHT DURING VARIOUS SPEEDS OF 0-60 MPH. DEALER WAS NOTIFIED.*AK
PROBLEMS WITH VEHICLE'S ALTERNATOR, BATTERY, BRAKES AND ELECTRICAL SYSTEM.*MR THE CONSUMER FEELS THAT THE ELECTRICAL PROBLEM CAUSED THEM THE REPLACE THE BATTERY THREE TIMES AND THE ALTERNATOR TWICE IN FOUR YEARS. THE SERPENTINE BELT BROKE AND LEFT THE DRIVER STRANDED IN RUSH HOUR TRAFFIC. THE BRAKES FAILED WHICH RESULTED IN A…
Read full complaint
PROBLEMS WITH VEHICLE'S ALTERNATOR, BATTERY, BRAKES AND ELECTRICAL SYSTEM.*MR THE CONSUMER FEELS THAT THE ELECTRICAL PROBLEM CAUSED THEM THE REPLACE THE BATTERY THREE TIMES AND THE ALTERNATOR TWICE IN FOUR YEARS. THE SERPENTINE BELT BROKE AND LEFT THE DRIVER STRANDED IN RUSH HOUR TRAFFIC. THE BRAKES FAILED WHICH RESULTED IN AN ACCIDENTS. MULTIPLE BRAKE COMPONENTS HAD BEEN REPLACED PRIOR TO THIS ACCIDENT. THE CONSUMER BELIEVES THE VEHICLE IS UNSAFE AND REQUEST REIMBURSEMENT. *NM
THERE WAS A FIRE UNDER THE HOOD WHICH CAUSED 2 EXPLOSIONS. THE FIRST EXPLOSION APPEARS TO HAVE BEEN AN ELECTRICAL FIRE. THE SECOND EXPLOSION WAS IN THE GAS OR FUEL LINE. THE ENTIRE ENGINE AREA WAS BURNED AND THE FIRE CRACKED THE WINDSHIELD AND STARTED MOVING INTO THE FRONT OF THE CAR. NO ONE WAS HURT. THE CAR WAS DETERMINED…
Read full complaint
THERE WAS A FIRE UNDER THE HOOD WHICH CAUSED 2 EXPLOSIONS. THE FIRST EXPLOSION APPEARS TO HAVE BEEN AN ELECTRICAL FIRE. THE SECOND EXPLOSION WAS IN THE GAS OR FUEL LINE. THE ENTIRE ENGINE AREA WAS BURNED AND THE FIRE CRACKED THE WINDSHIELD AND STARTED MOVING INTO THE FRONT OF THE CAR. NO ONE WAS HURT. THE CAR WAS DETERMINED TO BE A TOTAL LOSS. NO REPAIRS WERE MADE. THIS IS A CLAIM TO REPLACE OR REPAIR THE CAR. POLICE AND FIREMEN WERE CALLED TO THE FIRE. FIRE REPORT WAS MADE.*AK
Official recalls
510V270000 · Seats
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
04V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V505000 · Equipment:other:labels
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available