IllustrationWHILE TRAVELING ON HIGHWAY AND WITHOUT PRIOR WARNING POWER STEERING WENT OUT. ALSO, VEHICLE STARTED TO OVERHEAT. DEALERSHIP WAS AWARE OF PROBLEM.*AK
1999 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
2125–50K
3750–75K
4475–100K
51100–150K
19150K+
179 reports with mileage · 253 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports13 fire reports16 injury reports
What owners actually said
432 reportsBRAKE FAILURE DUE TO A CRACKED MASTER CYLINDER. DEALER AND MANUFACTURER HAS BEEN NOTIFIED. *AK *JB
THE REAR SEAT BELT DID NOT WORK. THE DEALER WAS NOTIFIED. *AK THE REAR SEAT BELTS DID NOT CATCH WHEN PULLED OUT QUICKLY. THE FRONT SEAT BELTS CAUGHT NORMALLY WHEN JERKED HARD. THE CONSUMER REQUESTED A WRITTEN REPLY. *SCC *JB
VEHICLE STALLED AT 20 MPH. CONSUMER NOTICED A BELT HANGING FROM UNDERCARRIAGE OF VEHICLE. VEHICLE IS AT DEALERSHIP AT THIS TIME.*AK
WHILE DRIVING ALL DASH INDICATOR LIGHTS WENT OUT, DEALER REPLACED A SENSOR. THIS HAPPENED AGAIN IN JUNE OF 2002, SENSOR WAS REPLACED A SECOND TIME.*AK
WE HAVE LEASED THE VEHICLE SINCE MAY OF 1999. WE HAVE REPLACED THE INPUT SPEED SENSOR TWICE NOW. THE FIRST TIME, THE PARTS AND LABOR WERE FREE UNDER THE MANUFACTURER'S WARRANTY. THIS TIME, BOTH THE INPUT AND THE OUTPUT SPEED SENSORS WENT. AFTER RESEARCHING ON YOUR WEBSITE, I FOUND THAT THIS PROBLEM HAS OCCURRED ON OTHER 199…
Read full complaint
WE HAVE LEASED THE VEHICLE SINCE MAY OF 1999. WE HAVE REPLACED THE INPUT SPEED SENSOR TWICE NOW. THE FIRST TIME, THE PARTS AND LABOR WERE FREE UNDER THE MANUFACTURER'S WARRANTY. THIS TIME, BOTH THE INPUT AND THE OUTPUT SPEED SENSORS WENT. AFTER RESEARCHING ON YOUR WEBSITE, I FOUND THAT THIS PROBLEM HAS OCCURRED ON OTHER 1999 DODGE GRAND CARAVANS. I BELIEVE THERE IS A DEFECT IN THE PART OR SO MANY PEOPLE WOULDN'T BE HAVING THE SAME PROBLEM. ALSO, I DON'T BELIEVE A PART SHOULD NEED TO BE REPLACED TWICE IN 2 1/2 YEARS TIME. THE SECOND REPAIR I HAD DONE ON 8/13/02 FOR BOTH SENSORS. MY MILEAGE AT THE TIME WAS 41,615. I WOULD APPRECIATE YOUR ATTENTION INTO THIS MATTER. THANK YOU..*AK
WINDSHIELD WIPERS/ HORN, AND CRUISE CONTROL ARE INOPERATIVE. CAUSE IS UNKNOWN. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
WE WERE ON THE WAY TO OUR VACATION DESTINATION ON 7/30/02 AND PULLED OFF THE FREEWAY FOR GAS. THE "SERVICE ENGINE SOON" LIGHT CAME ON AS SOON AS WE PULLED INTO THE GAS STATION. ONCE WE WERE ON THE ROAD AGAIN, THE VAN WOULD NOT COME OUT OF SECOND GEAR. WE WERE THEN FORCED TO STOP IN A PARKING LOT AND GOT DIRECTIONS TO THE CLOS…
Read full complaint
WE WERE ON THE WAY TO OUR VACATION DESTINATION ON 7/30/02 AND PULLED OFF THE FREEWAY FOR GAS. THE "SERVICE ENGINE SOON" LIGHT CAME ON AS SOON AS WE PULLED INTO THE GAS STATION. ONCE WE WERE ON THE ROAD AGAIN, THE VAN WOULD NOT COME OUT OF SECOND GEAR. WE WERE THEN FORCED TO STOP IN A PARKING LOT AND GOT DIRECTIONS TO THE CLOSEST FULL SERVICE REPAIR SHOP. (THIS ALL TOOK PLACE AT 8:15PM IN BARSTOW, CA) THE MECHANIC RAN DIAGNOSTICS ON THE VAN AND THOUGHT IT MIGHT BE THE SENSOR BUT WOULD HAVE TO RUN MORE TESTS THE FOLLOWING MORNING. WE WERE, AT THAT POINT FORCED TO STAY IN BARSTOW FOR THE NIGHT. WE CALLED THE MECHANIC IN THE MORNING AND GOT THE UNBELIEVABLE NEWS. AFTER RUNNING MORE DIAGNOSTICS HE FOUND TWO ADDITIONAL ERRORS IN THE TRANSMISSION RELATED TO A PRESSURE PROBLEM AND INFORMED US OUR TRANSMISSION WAS THE PROBLEM AND NEEDED TO BE REPLACED. THE MECHANIC WAS ABLE TO ORDER A FACTORY REBUILT TRANSMISSION AND WE WERE CHARGED A MERE $2,750.00 FOR PARTS AND LABOR. IN THE MEAN TIME WE HAD TO RENT 2 CARS TO GET TO OUR DESTINATION (NO VEHICLES WERE AVAILABLE TO FIT 6 PEOPLE). WE HAD TO STAY AN ADDITIONAL NIGHT IN A HOTEL, AS OUR VAN WOULD NOT BE READY UNTIL FRIDAY NIGHT. OUR VAN HAS LESS THAN 43,000 MILES ON IT AND SHOULD HAVE BEEN MORE RELIABLE THAN WHAT IT WAS. WE NOW HAVE THE FACTORY REBUILT TRANSMISSION, PROBABLY FROM SOMEONE ELSE VAN AND THEREFORE CANNOT BE TRUSTED. WE DO NOT FEEL THE REBUILT TRANSMISSION IS RELIABLE AND NOW WILL NOT DRIVE THIS VEHICLE UNLESS ABSOLUTELY NECESSARY. IT IS UNSAFE!! WE FEEL FORTUNATE THAT WE HAD EXITED THE FREEWAY AT APPARENTLY THE RIGHT TIME, WHO KNOWS WHAT WOULD HAVE HAPPENED HAD THE VAN SHIFTED IN TO SECOND GEAR AT 70MPH. THE STORY WOULD HAVE BEEN MUCH DIFFERENT.*AK
DRIVER'S SEATBACK LEVER BROKE AWAY FROM THE SEAT FRAME, CAUSING THE SEAT TO STICK IN UP-RIGHT POSITION. *AK CONSUMER IS CONCERNED ABOUT THE PERFORMANCE OF THE SEAT IF EVER IN AN ACCIDENT. *SCC
WHILE IN TRAFFIC TRAVELING APROX.35MPH VEHICLE SUDDENLY DROPPED TO LOWEST GEAR,RPMS SHOT UP,SPEEDOMETER FAILED,SERVICE ENGINE LIGHT CAME ON.TO SHOP IMMEDIATELY WHERE MECHANIC SAID HE HAS SEEN MANY DODGE CARVAN TRANSMISSION FAILURES AND TO TAKE IT BACK TO THE DEALER.I AM THE 2ND OWNER AND DON'T KNOW IF THE ORIGINAL OWNER HAD THIS…
Read full complaint
WHILE IN TRAFFIC TRAVELING APROX.35MPH VEHICLE SUDDENLY DROPPED TO LOWEST GEAR,RPMS SHOT UP,SPEEDOMETER FAILED,SERVICE ENGINE LIGHT CAME ON.TO SHOP IMMEDIATELY WHERE MECHANIC SAID HE HAS SEEN MANY DODGE CARVAN TRANSMISSION FAILURES AND TO TAKE IT BACK TO THE DEALER.I AM THE 2ND OWNER AND DON'T KNOW IF THE ORIGINAL OWNER HAD THIS PROBLEM AND PERHAPS THATS WHY HE TRADED IT WITH ONLY ABOUT 40K MILES ON IT?DEALER SAYS PROBABLY A SENSOR,CAN'T FIX TODAY - COME BACK MONDAY.
Official recalls
304V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V116000 · Exterior Lighting:headlights
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available