Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
1625–50K
4950–75K
5575–100K
68100–150K
24150K+
216 reports with mileage · 343 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 129 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports20 fire reports24 injury reports
What owners actually said
559 reports
Mileage unknown · Oct 2, 2000
Power TrainService Brakes, Hydraulic
WHEN DRIVING AND UPON DEPRESSING BRAKE PEDAL TO MAKE A SUDDEN STOP PEDAL TRAVELED TO FLOORBOARD, CAUSING EXTENDED STOPPING DISTANCE. ALSO, SMOKE CAME FROM BRAKES. CONSUMER HAS CONTACTED DEALER, DEALER HAS REPLACED ENTIRE BRAKE SYSTEM. ALSO, WHEN GEAR WAS PLACED IN DRIVE IT POPPED OUT OF GEAR. PLEASE PROVIDE ANY FURTHER…
Read full complaint
WHEN DRIVING AND UPON DEPRESSING BRAKE PEDAL TO MAKE A SUDDEN STOP PEDAL TRAVELED TO FLOORBOARD, CAUSING EXTENDED STOPPING DISTANCE. ALSO, SMOKE CAME FROM BRAKES. CONSUMER HAS CONTACTED DEALER, DEALER HAS REPLACED ENTIRE BRAKE SYSTEM. ALSO, WHEN GEAR WAS PLACED IN DRIVE IT POPPED OUT OF GEAR. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
NHTSA ODI #871936
Mileage unknown · Sep 6, 2000
Fuel System, Gasoline
RECENTLY A PLASTIC BAG GOT CAUGHT UNDER MY VAN WHEN I WAS DRIVING 30 MPH. NO SAFETY DEFECT MENTIONED. *AK
NHTSA ODI #730394
Mileage unknown · Aug 30, 2000
Electrical SystemFire
TWO FIRESTONE FR480 TIRES, SIZE: P205/70R15, DOT: UNKNOWN ON 1996, OLDSMOBILE SILHOUETTE HAVE EXPERIENCED FOLLOWING PROBLEMS: 1) FRONT-RIGHT TIRE DEVELOPED A BULGE IN TREAD OF TIRE WITH APPROXIMATELY 10,000 MILES ON THE TIRE WHICH CAUSED A "THUMPING" NOISE DURING OPERATION OF THE VEHICLE. 2) THE RIGHT-REAR TIRE EXPERIENCE…
Read full complaint
TWO FIRESTONE FR480 TIRES, SIZE: P205/70R15, DOT: UNKNOWN ON 1996, OLDSMOBILE SILHOUETTE HAVE EXPERIENCED FOLLOWING PROBLEMS: 1) FRONT-RIGHT TIRE DEVELOPED A BULGE IN TREAD OF TIRE WITH APPROXIMATELY 10,000 MILES ON THE TIRE WHICH CAUSED A "THUMPING" NOISE DURING OPERATION OF THE VEHICLE. 2) THE RIGHT-REAR TIRE EXPERIENCED A BLOWOUT WHILE TRAVELING 60 MPH WITH APPROXIMATELY 13,000 MILES ON THE TIRE. THESE TIRES ARE NOT ORIGINAL EQUIPMENT FOR VEHICLE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.*AK
NHTSA ODI #6900668
Mileage unknown · Aug 24, 2000
Engine And Engine Cooling
THE BELT TENSIONER FROZE ON MY GRAND CARAVAN. AS AN INTEGRAL PART OF THE STEERING THIS PART NEEDS TO BE GIVEN MORE CONSIDERATION. I HAVE FOUND SEVERAL COMPLAINTS ON THIS PROBLEM ON THE INTERNET WWW.ALLPAR.COM . THE DAMAGE THAT CAN BE DONE TO DRIVE PULLEY'S POWER STEERING UNITS CAN BE QUITE EXPENSIVE AND CHRYSLER WILL NOT INCL…
Read full complaint
THE BELT TENSIONER FROZE ON MY GRAND CARAVAN. AS AN INTEGRAL PART OF THE STEERING THIS PART NEEDS TO BE GIVEN MORE CONSIDERATION. I HAVE FOUND SEVERAL COMPLAINTS ON THIS PROBLEM ON THE INTERNET WWW.ALLPAR.COM . THE DAMAGE THAT CAN BE DONE TO DRIVE PULLEY'S POWER STEERING UNITS CAN BE QUITE EXPENSIVE AND CHRYSLER WILL NOT INCLUDE THIS PART IN THEIR WARRANTY'S. ONLY AFTER TELLING THEM I WOULD REPORT THIS TO THE NHTSA DID THEY OFFER TO PAY 1/2 THE REPAIR. IT STILL DID NOT MAKE ME FEEL THAT THE PROBLEM WAS LOOKED AT PROPERLY THERE ARE FAR TOO MANY CARAVANS ON THE ROAD TO HAVE A POTENTIAL PROBLEM WITH THE STEERING.
NHTSA ODI #728880
Mileage unknown · Aug 23, 2000
Steering
SERPINTINE BELT TENSIONER FAILS WHICH CAN CAUSE SERIOUS ACCIDENTS
NHTSA ODI #728812
Mileage unknown · Aug 14, 2000
Seat Belts
BELT KEEPS COMING LOOSE FROM THE SYSTEM, IS EXPENSIVE TO REPLACE ALL THE TIME. I AM SURE THAT THE MANUFACTURER KNOWS THAT THIS IS A PROBLEM. WHAT IS THE PROBLEM AND IS THE MANUFACTURER GOING TO FIX IT? OR DO I GET STUCK FOR THE REPAIRS AGAIN? *AK
NHTSA ODI #727914
Mileage unknown · Aug 11, 2000
Service Brakes, Air
SUDDEN STOPS RESULT IN GRINDING NOISES FROM THE ABS SYSTEM. NOTICED COMPLAINTS FROM OTHER CUSTOMERS.
NHTSA ODI #727598
Mileage unknown · Jul 31, 2000
Service Brakes, Hydraulic
EXITING HIGHWAY AT 43 MPH DEPRESSED BRAKE PEDAL 2 TIMES WITH NO BRAKING ACTION OBSERVED. SLOWED TO 35 MPH AND TRIED PEDAL 1 MORE TIME WITH NO STOPPING ACTION. USED TRANSMISSION AND ENGINE COMPRESSION TO SLOW VEHICLE. COASTED TO A STOP AND NOTICED SMOKE EMINATING FROM REAR OF VEHICLE WITH THE "SMELL" OF BRAKES PREVALENT. NO I…
Read full complaint
EXITING HIGHWAY AT 43 MPH DEPRESSED BRAKE PEDAL 2 TIMES WITH NO BRAKING ACTION OBSERVED. SLOWED TO 35 MPH AND TRIED PEDAL 1 MORE TIME WITH NO STOPPING ACTION. USED TRANSMISSION AND ENGINE COMPRESSION TO SLOW VEHICLE. COASTED TO A STOP AND NOTICED SMOKE EMINATING FROM REAR OF VEHICLE WITH THE "SMELL" OF BRAKES PREVALENT. NO INTERIOR BRAKE LIGHT ILLUMINATED AT ANY TIME. FIX: REPLACED REAR WHEEL CYLINDERS AND SHOES (EXCESSIVE WEAR NOTED), AND DRUMS TURNED. PROBABLE CAUSE UNIDENTIFIED (EXCESSIVE WEAR UNUSUAL FOR HIGHWAY MILES DRIVEN - FRONT BRAKES ALL NORMAL) FELT TO ME LIKE MASTER CYLINDER FAILURE WITH RESULTING ZERO PRESSURE IN SYSTEM AND NO BRAKING ACTION AT ALL. *AK
NHTSA ODI #726275
Mileage unknown · Jul 27, 2000
Air BagsCrashInjury
WHILE DRIVING AT APPROXIMATELY 65 MPH HIT A COYOTE THAT HAD RAN IN FRONT OF VEHICLE . ONLY DAMAGE TO VEHICLE WAS LICENSE PLATE HOLDER, BUT MOST DAMAGE CAME FROM DUAL AIRBAG DEPLOYMENT. CONSUMER FELT THAT AIRBAGS WERE TOO SENSITIVE , AND SHOULD NOT HAVE DEPLOYED. ALSO, DRIVER SUSTAINED INJURIES. *AK
NHTSA ODI #866130
Mileage unknown · Jul 26, 2000
Engine And Engine CoolingPower Train
TRANSMISSION: DOWN SHIFTS TO SECOND GEAR AND WILL NOT SHIFT OUT. OCCURRED WHILE ENTERING FREEWAY ON AN ON RAMP. SERPENTINE BELT SLIPPED OFF WHILE DRIVING IN SMALL PUDDLES OF WATER ON HIGHWAY. TOTAL LOSS OF POWER STEERING WHICH RESULTED IN DANGEROUS HANDLING OF VEHICLE ON WET ROADS. *AK
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.
Consequence & remedy
Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
1998 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration