NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
81 reportsClear category filterMileage unknown · Dec 6, 2000
Power Train
NOVEMBER 1999 TRANSMISSION LEAKED. DEALER COULD NOT FIND PROBLEM, AND LEAK STOPPED ON IT'S OWN. ON DECEMBER 4 WHILE DRIVING 55 MPH, HEARD LOUD NOISE, PULLED OVER, AND NOTICED TRANSMISSION FLUID POURING OUT OF VEHICLE, VEHICLE AT DEALER NOW. TRANSMISSION NEEDED TO BE REPLACED. *AK THE MANUFACTURER PAID ONLY HALF OF THE COST …
Read full complaint
NOVEMBER 1999 TRANSMISSION LEAKED. DEALER COULD NOT FIND PROBLEM, AND LEAK STOPPED ON IT'S OWN. ON DECEMBER 4 WHILE DRIVING 55 MPH, HEARD LOUD NOISE, PULLED OVER, AND NOTICED TRANSMISSION FLUID POURING OUT OF VEHICLE, VEHICLE AT DEALER NOW. TRANSMISSION NEEDED TO BE REPLACED. *AK THE MANUFACTURER PAID ONLY HALF OF THE COST OF THE PARTS. *YH
NHTSA ODI #876061
Mileage unknown · Nov 24, 2000
Electrical SystemEngine And Engine CoolingPower Train
CONSUMER HAS HAD PROBLEMS WITH VEHICLE 3 MONTHS AFTER VEHICLE WAS PURCHASED. A VALVE HAD TO BE CHANGED AT 24,000 MILES LATER WHILE VEHICLE WAS BRAND NEW. CURRENTLY, VEHICLE EMITTS BLACK SMOKE. THERE HAS BEEN NO REMEDY THUS FAR FOR PROBLEMS. SLIDING DOOR RATTLES, DEALER MADE AN ADJUSTMENT, FRONT PASSENGER DOOR RATTLES WHEN…
Read full complaint
CONSUMER HAS HAD PROBLEMS WITH VEHICLE 3 MONTHS AFTER VEHICLE WAS PURCHASED. A VALVE HAD TO BE CHANGED AT 24,000 MILES LATER WHILE VEHICLE WAS BRAND NEW. CURRENTLY, VEHICLE EMITTS BLACK SMOKE. THERE HAS BEEN NO REMEDY THUS FAR FOR PROBLEMS. SLIDING DOOR RATTLES, DEALER MADE AN ADJUSTMENT, FRONT PASSENGER DOOR RATTLES WHEN CLOSING. ENGINE HESITATES, MISSES, AND SQUEALS, DEALER REPLACED BELTS FOR THE SQUEALING. WHILE TURNING STEERING WHEEL, THERE IS A GRINDING NOISE IN THE FRONT END, DEALER PERFORMED TSB 19-05-98. SPARK PLUGS WERE REPLACED DUE TO BEING WORN. GEAR LEVEL WAS HARD TO GET OUT OF PARK. THE LEFT VISOR WOULD NOT STAY UP, DELAER FOUND A BROKEN CLIP. *SLC
NHTSA ODI #875435
Mileage unknown · Oct 2, 2000
Power TrainService Brakes, Hydraulic
WHEN DRIVING AND UPON DEPRESSING BRAKE PEDAL TO MAKE A SUDDEN STOP PEDAL TRAVELED TO FLOORBOARD, CAUSING EXTENDED STOPPING DISTANCE. ALSO, SMOKE CAME FROM BRAKES. CONSUMER HAS CONTACTED DEALER, DEALER HAS REPLACED ENTIRE BRAKE SYSTEM. ALSO, WHEN GEAR WAS PLACED IN DRIVE IT POPPED OUT OF GEAR. PLEASE PROVIDE ANY FURTHER…
Read full complaint
WHEN DRIVING AND UPON DEPRESSING BRAKE PEDAL TO MAKE A SUDDEN STOP PEDAL TRAVELED TO FLOORBOARD, CAUSING EXTENDED STOPPING DISTANCE. ALSO, SMOKE CAME FROM BRAKES. CONSUMER HAS CONTACTED DEALER, DEALER HAS REPLACED ENTIRE BRAKE SYSTEM. ALSO, WHEN GEAR WAS PLACED IN DRIVE IT POPPED OUT OF GEAR. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
NHTSA ODI #871936
Mileage unknown · Jul 26, 2000
Engine And Engine CoolingPower Train
TRANSMISSION: DOWN SHIFTS TO SECOND GEAR AND WILL NOT SHIFT OUT. OCCURRED WHILE ENTERING FREEWAY ON AN ON RAMP. SERPENTINE BELT SLIPPED OFF WHILE DRIVING IN SMALL PUDDLES OF WATER ON HIGHWAY. TOTAL LOSS OF POWER STEERING WHICH RESULTED IN DANGEROUS HANDLING OF VEHICLE ON WET ROADS. *AK
NHTSA ODI #726047
Mileage unknown · Jul 10, 2000
Power Train
SERPENTINE DRIVE BELT SLIPPED COMPLETELY OFF THE PULLEY WHICH RESULTED IN LOSS OF THE POWER STEERING CAPABILITY FOR MY WIFE
NHTSA ODI #9001276
Mileage unknown · Jun 7, 2000
Power Train
TRANSMISSION FAILED DUE TO A PIN SHEARING OFF FROM WITHIN, CAUSING A HOLE, AND ALLOWING FLUID TO LEAK. MANUFACTURER NOTIFIED, AND INFORMED CONSUMER THAT VEHICLE WAS OUT OF WARRANTY, AND NOTHING COULD BE DONE. FEEL FREE TO PROVIDE FURTHER DETAILS. *AK
NHTSA ODI #863217
Mileage unknown · Feb 16, 2000
Power TrainCrash
WHILE THE VAN WAS RUNNING TWO YEAR OLD CHILD WAS ABLE TO SHIFT GEAR FROM PARK TO REVERSE WITHOUT BRAKE APPLICATION, CAUSING THE VAN TO CRASH THROUGH THE GARAGE . MANUFACTURER WAS NOTIFIED ABOUT THE PROBLEM. MANUFACTURER STATED THAT THERE WAS NOT A STANDARD THAT WOULD KEEP THIS FROM HAPPENING. PLEASE PROVIDE ANY FURTHER INFO…
Read full complaint
WHILE THE VAN WAS RUNNING TWO YEAR OLD CHILD WAS ABLE TO SHIFT GEAR FROM PARK TO REVERSE WITHOUT BRAKE APPLICATION, CAUSING THE VAN TO CRASH THROUGH THE GARAGE . MANUFACTURER WAS NOTIFIED ABOUT THE PROBLEM. MANUFACTURER STATED THAT THERE WAS NOT A STANDARD THAT WOULD KEEP THIS FROM HAPPENING. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
NHTSA ODI #857053
Mileage unknown · Feb 8, 2000
Electrical SystemPower TrainSteering
TRANSMISSION WAS PUNCTURED FROM INSIDE AND LEAKS FLUID. YH
NHTSA ODI #550797
Mileage unknown · Jan 12, 2000
Power TrainVehicle Speed Control
TRANSMISSION FAILED WHILE OPERATING. ENGINE SURGED SEVERAL TIMES, LOST ACCELERATION, THEN STALLED. VEHICLE OPERATED WITH ONLY PASSENGER WEIGHT. DEALER NO EXPLANATION FOR FAILURE. SUGGEST COMPLETE REPLACEMENT OF TRANSMISSION. *AK
NHTSA ODI #717247
Mileage unknown · Sep 8, 1999
Electrical SystemEngine And Engine CoolingPower Train
TRANSMISSION WAS NOISY--FAULTY FLYWHEEL AND STARTER WERE REPLACED TO CORRECT IT.
NHTSA ODI #609603
Official recalls
4Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 15, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.
Consequence & remedy
Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
Illustration