Engine And Engine CoolingExterior LightingLatches/locks/linkages
WHEN I PURCHASED MY VAN AUGUST 21 2009 IT HAD A PROBLEM WITH THE LEFT TURN SIGNAL. THE SALESPERSON SAID IT WAS FROM THE BULBS BEING BURNT OUT. I WENT TO AUTOZONE THAT DAY TO GET THE BULBS REPLACED, AND THAT WASN'T THE PROBLEM. AUTOZONE TOLD ME IT WAS THE TURN SIGNAL SWITCH THAT HAD WENT BAD AND WAS CAUSING MY LEFT TURN SIGNAL NO…
Read full complaint
WHEN I PURCHASED MY VAN AUGUST 21 2009 IT HAD A PROBLEM WITH THE LEFT TURN SIGNAL. THE SALESPERSON SAID IT WAS FROM THE BULBS BEING BURNT OUT. I WENT TO AUTOZONE THAT DAY TO GET THE BULBS REPLACED, AND THAT WASN'T THE PROBLEM. AUTOZONE TOLD ME IT WAS THE TURN SIGNAL SWITCH THAT HAD WENT BAD AND WAS CAUSING MY LEFT TURN SIGNAL NOT TO WORK. I WENT TO GOODYEAR A FEW DAYS LATER TO HAVE THE TURN SIGNAL SWITCH REPLACED. THEY TOLD ME IT WAS NOT A GUARANTEE THAT IT WOULD HOLD OR WORK FOR A WHILE. SINCE THEN IT STILL HAS NOT BEEN WORKING PROPERLY. SOMETIMES IF I TURNED THE DEFROSTER ON IT WOULD KICK ON, BUT NOW IT WILL TURN ON FOR MAYBE ONE TURN AND TURN OFF RIGHT AND WHEN I GO TO USE IT AGAIN, IT'LL TURN ON THEN CUT OFF AND WONT TURN BACK ON. ALSO MY SLIDING PASSENGER DOORS, THE CHILD LOCK IS STUCK AND NOONE CAN OPEN THE DOOR FROM THE INSIDE. I HAVE TO GET OUT OR THE PASSENGER HAS TO GET OUT TO OPEN THE DOORS. THE DOOR HANDLES ARE HARD TO OPEN ON THE OUTSIDE. EVEN THOUGH THE CHILD LOCK WILL SAY ITS NOT ON, YOU CAN NOT STILL OPEN THE DOORS FROM THE INSIDE. THIS HAS BEEN LIKE THIS SINCE I PURCHASED THE VAN. ALSO I HAVE SOME PANS UNDER MY ENGINE THAT LEAKING FLUIDS AND AS FAR AS I KNOW, ITS THE OIL PAN, COOLANT PAN, AND I HAVE METAL SHAVINGS IN SOME OF MY FLUIDS. THIS WAS ALSO LIKE THIS WHEN I PURCHASE THIS VEHICLE. *TR
STRUT TOWER CORROSION-DRIVER SIDE-RUST AND METAL BREAKING UP-1998 GRAND CARAVAN-PURCHASED NEW-HAS 83,500 MILES- HAVE HAD BELT PROBLEMS SEVERAL TIMES-ALSO WINDSHIELD WIPERS INTERMIT FAILURE -RUSTED OUT POWER STEERING MECH. TOTALLY REPLACED-MANY BRAKE JOBS-AND ALSO HEADLIGHT INTERIOR SWITCH SEEMS TO FAIL AT TIMES. I NEED TO MAKE…
Read full complaint
STRUT TOWER CORROSION-DRIVER SIDE-RUST AND METAL BREAKING UP-1998 GRAND CARAVAN-PURCHASED NEW-HAS 83,500 MILES- HAVE HAD BELT PROBLEMS SEVERAL TIMES-ALSO WINDSHIELD WIPERS INTERMIT FAILURE -RUSTED OUT POWER STEERING MECH. TOTALLY REPLACED-MANY BRAKE JOBS-AND ALSO HEADLIGHT INTERIOR SWITCH SEEMS TO FAIL AT TIMES. I NEED TO MAKE A DECISSION TO BUY A NEW VAN WITH "HAND CONTROLS" OR HAVE THIS VAN "HAND CONTROLS" INSTALLED. ME THINKS I NEED TO BUY A NEW VAN AND BE LOOKING AT ANOTHER MANUFACTOR. AS IT SEEMS LIKE CHRYSLER/DODGE IS NOT STEPPING UP TO ALL THESE FAILURES THAT ARE SEEN BY TOO MANY OTHER VAN OWNERS;OF THIS 1998 MODEL CARAVAN. SAW ON LINE A NEW REPAIR FOR THE STRUT RUSTING CALLED ""FUSOR #112B/MOPAR 05083855AA. CAN BE USED TO FIX THIS PROBLEMTHE TSB #23-044-02 THRU A COMPANY CALLED LORD CORP. LISTED UNDER THEIR OEM BULLETINS AND REPAIR RECOMMENDATIONS USING FUSOR ADHESIVES. THINK I MAY USE THIS ON MINE. HOPE OTHERS CAN USE THIS ALSO. THANKS. *NM
NHTSA ODI #10163402
43,000 miles · Nov 26, 2005
Exterior Lighting
CRAZED, FOGGED HEADLIGHT ENCLOSURES BOTH SIDES; FACTORY DEFECT DUE TO LACK OF DURABILITY. *NM
NHTSA ODI #10143700
Mileage unknown · Jun 8, 2005
Exterior Lighting
REFERENCE DEFECT INVESTIGATION EA05009: I HAVE EXPERIENCED A SIMILAR FAILURE ON MY 1998 DODGE GRAND CARAVAN. THE LOW BEAM HEADLIGHTS CEASED TO WORK. A LOCAL MECHANIC (NOT DEALER) TRACED THE PROBLEM TO A SINGLE BROKEN CONDUCTOR IN ONE OF THE WIRING HARNESSES, AND REPAIRED THE PROBLEM. CAN AND WILL THIS INVESTIGATION BE EX…
Read full complaint
REFERENCE DEFECT INVESTIGATION EA05009: I HAVE EXPERIENCED A SIMILAR FAILURE ON MY 1998 DODGE GRAND CARAVAN. THE LOW BEAM HEADLIGHTS CEASED TO WORK. A LOCAL MECHANIC (NOT DEALER) TRACED THE PROBLEM TO A SINGLE BROKEN CONDUCTOR IN ONE OF THE WIRING HARNESSES, AND REPAIRED THE PROBLEM. CAN AND WILL THIS INVESTIGATION BE EXPANDED TO COVER EARLIER MODEL YEARS? THANK YOU. INCIDENT DATE IS APPROXIMATE.
NHTSA ODI #10124552
59,000 miles · Mar 31, 2005
Electrical SystemExterior Lighting
AN ELECTRICAL FAILURE CAUSED THE HEADLIGHTS TO MALFUNCTION. THEY FLICKERED ON AND OFF WHILE ENGAGED. DEALERSHIP WAS UNABLE TO CORRECT THE PROBLEM DUE TO THE DEFECTIVE PART BEING ON BACK ORDER. THIS WAS A COMMON FAILURE ON THESE VEHICLES. *AK *NM
NHTSA ODI #10117199
95,850 miles · Feb 16, 2005
Exterior Lighting
WHILE DRIVING AT NIGHT HEADLIGHTS WERE VERY DIM AND CLOUDED. THE CONSUMER'S VISIBILITY BECOMES IMPAIRED . *AK *SC *JB
NHTSA ODI #10103594
60,000 miles · Oct 26, 2004
Exterior Lighting
THE HEADLIGHT LENS DEVELOPED A CLOUDY DISCOLORATION THAT REDUCED THE LIGHTS ILLUMINATION. THIS MADE IT DIFFICULT FOR THE DRIVER TO SEE WHEN DRIVING AT NIGHT OR ON A DARK ROAD. THE ENTIRE HEADLIGHT ASSEMBLY HAS TO BE REPLACED TO CORRECT THE PROBLEM, COSTING $200.00 EACH.*AK
NHTSA ODI #10097697
54,000 miles · Feb 24, 2004
Exterior Lighting
THE HEAD LIGHTS ON THE VEHICLE WERE OPAQUE (GREY) WHICH AFFECTED THE AMOUNT OF LIGHT ILLUMINATED ONTO THE ROAD. THIS PROBLEM HAS BEEN ADDRESSED DURING OTHER TRIPS TO THE DEALER. THE MANUFACTURER IS AWARE OF THE PROBLEM. *JB *NM
NHTSA ODI #10055783
Mileage unknown · Nov 16, 2003
Exterior Lighting
OUR 1998 DODGE CARAVAN AND MANY OTHERS HAVE PLASTIC COVERS ON THE HEADLIGHTS (HEADLIGHT ASSEMBLY). THE PLASTIC DETERIORATES IN THE SUN AND SALT AIR WHICH CAUSES THE AMOUNT OF LIGHT GIVEN OFF DRIVING AT NIGHT TO BE MUCH REDUCED. DODGE DEALER SAID BUY NEW ONES AT ALMOST $300 APIECE. I SAY IT IS A MANUFACTURING PROBLEM - CARS SH…
Read full complaint
OUR 1998 DODGE CARAVAN AND MANY OTHERS HAVE PLASTIC COVERS ON THE HEADLIGHTS (HEADLIGHT ASSEMBLY). THE PLASTIC DETERIORATES IN THE SUN AND SALT AIR WHICH CAUSES THE AMOUNT OF LIGHT GIVEN OFF DRIVING AT NIGHT TO BE MUCH REDUCED. DODGE DEALER SAID BUY NEW ONES AT ALMOST $300 APIECE. I SAY IT IS A MANUFACTURING PROBLEM - CARS SHOULD LAST LONGER THAN 5 YEARS AND THE PRODUCT IS POOR QUALITY. *LA
NHTSA ODI #10047024
Mileage unknown · Jan 29, 2002
Exterior LightingService Brakes, Hydraulic
WHEN DRIVING AND UPON APPLYING BRAKES THEY WILL MOMENTARILY LOCK UP, AND HEADLIGHTS WILL GET VERY DIM. ALSO A NOISE WAS COMING FROM DASHBOARD AFTER BRAKES WERE APPLIED. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.
Consequence & remedy
Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
1998 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration