Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 255 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Seat Belts. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports4 fire reports20 injury reports
What owners actually said
255 reports
Mileage unknown · Jan 11, 2002
Equipment Adaptive/mobilityCrash
THIS INCIDENT WAS REPORTED BY FAMILY OF THE DRIVER. VEHICLE HAD BEEN MODIFIED FOR USE BY A DISABLED PERSON. STEERING SYSTEM WAS CONTROLLED BY AN "ELECTRONIC MOBILITY SYSTEM (MODEL DS2000)". WHILE DRIVING APPROXIMATELY 30 TO 35 MPH, DRIVER LOST ALL DIRECTIONAL CONTROL OF THE VEHICLE, AND WAS INVOLVED IN A HEAD-ON COLLISION W…
Read full complaint
THIS INCIDENT WAS REPORTED BY FAMILY OF THE DRIVER. VEHICLE HAD BEEN MODIFIED FOR USE BY A DISABLED PERSON. STEERING SYSTEM WAS CONTROLLED BY AN "ELECTRONIC MOBILITY SYSTEM (MODEL DS2000)". WHILE DRIVING APPROXIMATELY 30 TO 35 MPH, DRIVER LOST ALL DIRECTIONAL CONTROL OF THE VEHICLE, AND WAS INVOLVED IN A HEAD-ON COLLISION WHEN HIS VEHICLE WANDERED INTO ONCOMING TRAFFIC. THE DRIVER WAS KILLED . PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION / PHOTOGRAPHS.*AK
NHTSA ODI #8001980
Mileage unknown · Jan 9, 2002
Electrical System
VEHICLE WOULD NOT START. CONSUMER OPENED THE HOOD AND NOTICED SMOKE AND MELTED WIRES ON RIGHT SIDE. VEHICLE NOT TAKEN TO DEALER YET. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK
NHTSA ODI #8001833
Mileage unknown · Jan 4, 2002
Air BagsSeat BeltsCrashInjury
CONSUMER'S VEHICLE WAS INVOLVED IN A FRONTAL CRASH TRAVELING AT AN UNKNOWN SPEED. DRIVER'A AIR BAG FAILED TO DEPLOY, AND SEAT BELT RETRACTOR FAILED TO CATCH. CONSUMERS HEAD HIT WINDSHIELD, KNOCKING OUT TWO TEETH, AND ARMS WERE INJURED. THE VEHICLE HAS NOT BEEN EXAMINED TO DETERMINE CAUSE OF PROBLEM. PLEASE PROVIDE ANY…
Read full complaint
CONSUMER'S VEHICLE WAS INVOLVED IN A FRONTAL CRASH TRAVELING AT AN UNKNOWN SPEED. DRIVER'A AIR BAG FAILED TO DEPLOY, AND SEAT BELT RETRACTOR FAILED TO CATCH. CONSUMERS HEAD HIT WINDSHIELD, KNOCKING OUT TWO TEETH, AND ARMS WERE INJURED. THE VEHICLE HAS NOT BEEN EXAMINED TO DETERMINE CAUSE OF PROBLEM. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION. *AK
NHTSA ODI #8001519
Mileage unknown · Oct 29, 2001
Service Brakes, Hydraulic
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
NHTSA ODI #753854
Mileage unknown · Aug 30, 2001
Electrical SystemFire
WHILE DRIVING VEHICLE CAUGHT ON FIRE UNDER THE DASH NEAR BASE OF STEERING COLUMN. VEHICLE WAS TOTALED. PLEASE PROVIDE FURTHER INFORMATION.*AK
NHTSA ODI #895489
Mileage unknown · Jul 6, 2001
Latches/locks/linkages
WHILE DRIVING 55 MPH HOOD FLEW OPEN. NO ACCIDENT, DAMAGE TO VEHICLE WAS $ 1300.00.*AK
NHTSA ODI #892072
Mileage unknown · Jun 20, 2001
Power Train
THIS IS THE SECOND TRANSMISSION FIRST AT 48,600 MILES (THEY WOULD NOT REPLACE IT BECAUSE 48000 MILE WARRANTY) NOW AT 129.999 MILES. *AK
NHTSA ODI #747148
Mileage unknown · May 25, 2001
Air BagsInjury
WHILE REVERSING TO EXIT OUT OF A PARKING SPACE, DRIVER'S SIDE AIRBAG DEPLOYED, CAUSING MINOR INJURIES TO CONSUMER. VEHICLE WAS NOT STRUCK WITH ANY TYPE OF OBJECT WHEN AIRBAG DEPLOYED. A DODGE REPRESENTATIVE ADVISED CONSUMER THAT BOTTOM OF VEHICLE WAS SCRATCHED WHICH MAY HAVE CAUSED AIRBAG TO DEPLOY. HOWEVER, VEHICLE WAS NO…
Read full complaint
WHILE REVERSING TO EXIT OUT OF A PARKING SPACE, DRIVER'S SIDE AIRBAG DEPLOYED, CAUSING MINOR INJURIES TO CONSUMER. VEHICLE WAS NOT STRUCK WITH ANY TYPE OF OBJECT WHEN AIRBAG DEPLOYED. A DODGE REPRESENTATIVE ADVISED CONSUMER THAT BOTTOM OF VEHICLE WAS SCRATCHED WHICH MAY HAVE CAUSED AIRBAG TO DEPLOY. HOWEVER, VEHICLE WAS NOT SCRATCHED AT THE TIME OF DEPLOYMENT, BUT AT AN EARLIER OCCASION, AND AIRBAG HAD A LONG DELAY OF DEPLOYMENT. *AK
NHTSA ODI #889211
Mileage unknown · May 22, 2001
Seat Belts
MIDDLE ROW ON RIGHT OUTBOARD POSITION LAP AND SHOULDER BELT BUCKLE FAILS TO LOCK IN PLACE. CONSUMER HAD RECALL 97V149OOO WORK PERFORMED, AND REMEDY HAS NOT CORRECTED DEFECT. *AK THE CONSUMER POINTS OUT THAT THE SHOULDER BELT SHOULD LOCK IN PLACE DURING HARD BRAKING. *YH
NHTSA ODI #888821
Mileage unknown · Apr 20, 2001
Seat Belts
DRIVER SIDE SEAT BELT RETRACTOR LOCKS UP, SEAT BELT BECOMES LOOSE, DOES NOT RETRACK TO ITS BASE.*AK
VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.
Consequence & remedy
Consequence: THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.
THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence & remedy
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence & remedy
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR ARMATURE CRACKS IN THE CENTER HUB ATTACHMENT AREA. ANY STEERING WHEELS SHOWING CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBURSED FOR PREVIOUS ABS COMPONENT REPAIR COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA97005 · Safety Belt Anchorage Failures
Opened Apr 10, 1997 · Closed Dec 23, 1997
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
There is no summary currently available
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
EA95029 · Steering Wheel Separation
Opened Sep 26, 1995 · Closed Nov 13, 1996
Status: closed (inferred from source dates) · Steering
AFTER AN EXTENSIVE INVESTIGATION AND ANALYSIS, CHRYSLER HAS IDENTIFIED THE DEFECT AS A FATIGUE FAILURE, ORIGINATION IN THE HEAT AFFECTED REGION OF THE PROJECTION WELDS OF THE STEERING WHEEL HUB TO STEERING WHEEL ARMATURE ATTACHMENT.THE HUB IS THE PORTION OF THE STEERING WHEEL ASSEMBLY THAT CONNECTS IT TO THE STEERING COLUMN SHAFT AND IS ATTACHED TO THE UNDERSIDE OF THE STEERING WHEEL ASSEMBLY BY 4 WELDS.IF CRACKS DEVELOP IN THE HEAT AFFECTED REGION OF THE WELDS AND PROPAGATE THROUGH THE STEERING WHEEL ARMATURE TO EACH OF THE WELDS, THE STEERING WHEEL CAN SEPARATE FROM THE HUB.THIS IS A SLOW PROGRESSIVE FAILURE WHICH NORMALLY OCCURS AT HIGH MILEAGE.IN SOME CASES COMPLAINANTS HAVE REPORTED A LOOSENESS OR WOBBLING OF THE STEERING WHEEL PRIOR TO SEPARATION.TO REMEDY THIS DEFECT, CHRYSLER WILL INSPECT THE STEERING WHEELS OF THE AFFECTED VEHICLES FOR CRACKS IN THE HUB AREA.IF ANY CRACKS ARE FOUND, THE STEERING WHEEL WILL BE REPLACED.ALL OTHER VEHICLES WILL HAVE REINFORCING PLATES INSTALLED WHICH WOULD PREVENT A STEERING WHEEL SEPARATION SHOULD CRACKING OCCUR.
EA94028 · Abs Braking System Fails
Opened Jul 29, 1994 · Closed Jun 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94024 · Abs Braking System Fails
Opened Mar 7, 1994 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA94005 · Liftgate Latches
Opened Jan 31, 1994 · Closed Oct 25, 1995
Status: closed (inferred from source dates) · Structure
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER AWARENESS OF THE CAMPAIGN; QUARTERLY REPORTS REGARDING CAMPAIGN COMPLETION RATES; AS WELL AS ADDITIONAL MEASURES TO ENSURE A HIGH COMPLETION RATE, ABOVE AND BEYOND THE ACTIONS THAT NORMALLY WOULD BE TAKEN IN A FORMAL SAFETY RECALL.THESE INCLUDE FOLLOW UP WRITTEN AND TELEPHONIC NOTIFICATIONS TO OWNERS WHO DO NOT BRING THEIR VEHICLES IN FOR CORRECTIVE ACTION.NHTSA FIRMLY BELIEVES THAT THE CRASH PERFORMANCE OF THE LATCHES ON THESE MINIVANS RAISES SERIOUS SAFETY CONCERNS, AND THAT THE CAMPAIGN ADDRESSES THESE CONCERNS.THE CHRYSLER CORRECTIVE ACTION WILL INCREASE THE STRENGTH OF THE LIFTGATE LATCHES AND DECREASE THE POTENTIAL FOR INERTIAL UNLATCHING, THEREBY REDUCING THE RISK OF CRASH-RELATED OPENINGS OF THE LIFTGATE AND POSSIBLE OCCUPANT EJECTION THROUGH THE LIFTGATE OPENING.OWNERS OF CHRYSLER MINIVANS WILL GET A STRONGER, SAFER LATCH FREE OF CHARGE AT THE EARLIEST POSSIBLE TIME, WITHOUT THE NEED FOR FURTHER TECHNICAL INVESTIGATION AND COMPLEX AND TIME-CONSUMING LITIGATION WITH AN UNCERTAIN OUTCOME.BASED ON THE ABOVE, ODI IS CLOSING THIS INVESTIGATION.
1992 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration