BAD PAINT ITS PEELING FLAKEING THE WOOD GRAIN TOO FAIDING BAD TRANS I JUST PAID A DEALERSHIP OVER 2 GRAND FOR A NEW ONE WARRANTEED FOR ONLY 3 YEARS OR 36,000 MILES. BAD POWER WINDOWS CABLE BROKE=OVER $400.= ME GETTINGSCREWD BAD LUG NUTS LITTLE METAL CAPS OVER LUGNUTS COME OFF AND THEN TIRE TOOL DOSENT FIT SO YOU END UP AT…
Read full complaint
BAD PAINT ITS PEELING FLAKEING THE WOOD GRAIN TOO FAIDING BAD TRANS I JUST PAID A DEALERSHIP OVER 2 GRAND FOR A NEW ONE WARRANTEED FOR ONLY 3 YEARS OR 36,000 MILES. BAD POWER WINDOWS CABLE BROKE=OVER $400.= ME GETTINGSCREWD BAD LUG NUTS LITTLE METAL CAPS OVER LUGNUTS COME OFF AND THEN TIRE TOOL DOSENT FIT SO YOU END UP AT THE DEALERSHIP GETTING THEM CUT OFF. KEEPS STALLING HEADLINER FALLING DOWN HEADLIGHTS ARE TOTALLY YELLOW AT NIGHT YOU CANT SEE MORE THAN 50 FEET ON LOW BEAMS SO YOU HAVE TO HAVE HIGH BEAMS ON JUST TO GET LOW BEAM QUALITY. BREAKS NEW ROTORS, MASTERCILLENDER, HARDWEAR, DRUMS, SHOES, PADS, FLUID, MASTERCILLENDER CAPS, WEEL CILLENDERS,= OVER $500. TO THE DEALER AND ME AND MY FAM STRANDED ON THE ROADSIDE FOR 4 HOURES GETTING RECALLED PARTS FITTED ONLY TAKES AN ACT OF CONGRESS AND ABOUT THREE DAYS WITH OUT A CAR UNLESS THEY GIVE YOU THERE "LOANER" LOANER=CAR NO ONE WOULD BUT TWELVE YEARS AGO. JAMES REYNOLDS SHARON TENN GOOBERCLESE@HOTMAIL.COM OWNER OF A 92 DODGE GRAND CARAVAN LE
NHTSA ODI #10070192
Mileage unknown · Jun 24, 2002
Engine And Engine CoolingEquipmentExterior Lighting
DRIVER'S SIDE SEATBELT RETRACTOR IS STUCK AND WILL NOT COME APART. ALSO, TRANSMISSION FAILED WITHOUT PRIOR WARNING. THIS WAS THE SIXTH TRANSMISSION.*AK AFTER TRANSMISSION WAS REPLACED, THE ENGINE BEGAN TO STALL. GAS GAUGE FAILED. DASHBOARD LIGHT SHORTENED OUT. SPEEDOMETER FAILED AND HAD TO BE REPLACED 4 TIMES. TRANSMISSIO…
Read full complaint
DRIVER'S SIDE SEATBELT RETRACTOR IS STUCK AND WILL NOT COME APART. ALSO, TRANSMISSION FAILED WITHOUT PRIOR WARNING. THIS WAS THE SIXTH TRANSMISSION.*AK AFTER TRANSMISSION WAS REPLACED, THE ENGINE BEGAN TO STALL. GAS GAUGE FAILED. DASHBOARD LIGHT SHORTENED OUT. SPEEDOMETER FAILED AND HAD TO BE REPLACED 4 TIMES. TRANSMISSION NOT SHIFTING PROPERLY. FRONT END VIBRATES ESPECIALLY WHEN TURNING. BRAKES ARE GRINDING. REAR VIEW MIRROR FELL OFF. HIGH MOUNT BRAKE LIGHT SHORTENED OUT. SIDE WINDOW AND DOOR RATTLING. REAR WIPER FAILED. MUFFLER NEEDS TO BE REPLACED. EXHAUST SMELL IN VAN. ENGINE OVERHEATING. AIR CONDITIONER FAILED. VEHICLE PULLS. CONSUMER IS REQUESTING REIMBURSEMENT. *TT
NHTSA ODI #8012476
Mileage unknown · Dec 20, 2000
Visibility
I CONCERNED ABOUT A PROBLEM WITH THE REAR WINDOW ON MY MINI-VAN. PLEASE LET ME KNOW IF THERE IS OR WILL BE A RECALL TO FIX A PROBLEM WITH THE REAR WINDOW SEAL OF THE HATCH FOR THE 1992 DODGE GRAND CARAVANS. THE SEAL IS LOOSE AND CAN CAUSE THE REAR WINDOW TO FALL OUT... IF THE WINDOW DOES FALL OUT, THIS COULD SERIOUSLY INJURE SOM…
Read full complaint
I CONCERNED ABOUT A PROBLEM WITH THE REAR WINDOW ON MY MINI-VAN. PLEASE LET ME KNOW IF THERE IS OR WILL BE A RECALL TO FIX A PROBLEM WITH THE REAR WINDOW SEAL OF THE HATCH FOR THE 1992 DODGE GRAND CARAVANS. THE SEAL IS LOOSE AND CAN CAUSE THE REAR WINDOW TO FALL OUT... IF THE WINDOW DOES FALL OUT, THIS COULD SERIOUSLY INJURE SOMEONE, ESPECIALLY A CHILD. EVEN WORSE, THIS WINDOW COULD FALL OUT ON THE HIGHWAY AND CAUSE SERIOUS AND FATAL ACCIDENTS. I BELIEVE THAT THIS IS A SERIOUS MATTER AND A RECALL SHOULD BE SENT OUT TO HAVE THE REAR WINDOWS RESEALED BEFORE PEOPLE ARE SERIOUSLY INJURED AND/OR KILLED. THIS MATTER IS FAR MORE SERIOUS THAN THE RECALL RECENTLY SENT OUT BY DAIMLERCHRYSLER ABOUT A WIPER MOTOR (#836). THANK YOU.
NHTSA ODI #738062
Mileage unknown · Nov 30, 2000
Visibility
CONSUMER CONCERNED ABOUT THE AMOUNT OF TIME IT MAT TAKE TO HAVE RECALL REPAIR 99V-189, DEALER REFUSES TO GIVE CONSUMER LOANER VEHICLE WHILE REPAIRS ARE BEING MADE. NLM
NHTSA ODI #558212
Mileage unknown · Aug 25, 2000
Seat BeltsVisibility
AFTER ARRIVNG FOR SCHEDULE APPOINTMENT FOR RECALL CAMPAIGNS(742&836) DEALER REFUSED TO SERVICE VEHICLE BECAUSE THEY HAD MANY OTHER SERVICES SCHEDULED AND WERE MORE IMPORTANT. THEY ALSO REFUSED TO MAKE ANY EFFORT TO ORDER ANY PARTS FOR THE RECALL. *CJ
NHTSA ODI #554059
Mileage unknown · Apr 26, 2000
Visibility
REAR WINDSHIELD WIPERS FAILED TO OPERATE. MOTOR WOULD RUN, BUT WIPERS WOULD NOT MOVE. DEALER NOTIFIED, AND INFORMED CONSUMERTHAT REPAIRS WOULD BE MADE AT CONSUMER'S COST. *AK
NHTSA ODI #860995
Mileage unknown · Apr 6, 2000
Visibility
WHILE DRIVING REAR WINDSHIELD WIPERS STOPPED WORKING. TOOK VEHICLE TO DEALER, AND THEY SAID DON'T WORRY IT WILL BE A RECALL SOON, THESE VANS HAVE THIS PROBLEM ALL THE TIME. CONSUMER HAS NO REAR WINDSHIELD WIPERS WHICH IMPAIRS DRIVER'S VISIBILITY. ALSO, 94 AND 95 DODGE GRAND CARAVANS HAVE BEEN RECALLED FOR THE SAME PROBLEM.…
Read full complaint
WHILE DRIVING REAR WINDSHIELD WIPERS STOPPED WORKING. TOOK VEHICLE TO DEALER, AND THEY SAID DON'T WORRY IT WILL BE A RECALL SOON, THESE VANS HAVE THIS PROBLEM ALL THE TIME. CONSUMER HAS NO REAR WINDSHIELD WIPERS WHICH IMPAIRS DRIVER'S VISIBILITY. ALSO, 94 AND 95 DODGE GRAND CARAVANS HAVE BEEN RECALLED FOR THE SAME PROBLEM. *AK
NHTSA ODI #859814
Mileage unknown · Apr 6, 2000
Visibility
THE REAR WINDSHIELD WIPER IS STUCK IN THE MIDDLE OF THE WINDSHIELD. MANUFACTURER HAS BEEN NOTIFIED ABOUT THE PROBLEM. PROBLEM HAS NOT BEEN CORRECTED. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
NHTSA ODI #859798
Mileage unknown · Oct 20, 1999
Visibility
THE REAR WINDSHIELD WIPER BLEW A FUSE WHEN IT WAS ACTIVATED. THIS WOULD HAPPEN EACH & EVERY TIME THE WIPER WOULD BE IN USE. HAS NOT BEEN TO DEALER TO CHECK THE FUSE.*AK
NHTSA ODI #851279
Mileage unknown · Oct 6, 1999
Visibility
HATCHBACK WINDOW EXPLODED WHILE DRIVING . PRIOR TO THIS INCIDENT, THE DRIVER'S SIDE WINDOW EXPLODED. DEALER AND MANUFACTURER HAS BEEN NOTIFIED. *AK
VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.
Consequence & remedy
Consequence: THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.
THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence & remedy
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence & remedy
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR ARMATURE CRACKS IN THE CENTER HUB ATTACHMENT AREA. ANY STEERING WHEELS SHOWING CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBURSED FOR PREVIOUS ABS COMPONENT REPAIR COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA97005 · Safety Belt Anchorage Failures
Opened Apr 10, 1997 · Closed Dec 23, 1997
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
There is no summary currently available
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
EA95029 · Steering Wheel Separation
Opened Sep 26, 1995 · Closed Nov 13, 1996
Status: closed (inferred from source dates) · Steering
AFTER AN EXTENSIVE INVESTIGATION AND ANALYSIS, CHRYSLER HAS IDENTIFIED THE DEFECT AS A FATIGUE FAILURE, ORIGINATION IN THE HEAT AFFECTED REGION OF THE PROJECTION WELDS OF THE STEERING WHEEL HUB TO STEERING WHEEL ARMATURE ATTACHMENT.THE HUB IS THE PORTION OF THE STEERING WHEEL ASSEMBLY THAT CONNECTS IT TO THE STEERING COLUMN SHAFT AND IS ATTACHED TO THE UNDERSIDE OF THE STEERING WHEEL ASSEMBLY BY 4 WELDS.IF CRACKS DEVELOP IN THE HEAT AFFECTED REGION OF THE WELDS AND PROPAGATE THROUGH THE STEERING WHEEL ARMATURE TO EACH OF THE WELDS, THE STEERING WHEEL CAN SEPARATE FROM THE HUB.THIS IS A SLOW PROGRESSIVE FAILURE WHICH NORMALLY OCCURS AT HIGH MILEAGE.IN SOME CASES COMPLAINANTS HAVE REPORTED A LOOSENESS OR WOBBLING OF THE STEERING WHEEL PRIOR TO SEPARATION.TO REMEDY THIS DEFECT, CHRYSLER WILL INSPECT THE STEERING WHEELS OF THE AFFECTED VEHICLES FOR CRACKS IN THE HUB AREA.IF ANY CRACKS ARE FOUND, THE STEERING WHEEL WILL BE REPLACED.ALL OTHER VEHICLES WILL HAVE REINFORCING PLATES INSTALLED WHICH WOULD PREVENT A STEERING WHEEL SEPARATION SHOULD CRACKING OCCUR.
EA94028 · Abs Braking System Fails
Opened Jul 29, 1994 · Closed Jun 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94024 · Abs Braking System Fails
Opened Mar 7, 1994 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA94005 · Liftgate Latches
Opened Jan 31, 1994 · Closed Oct 25, 1995
Status: closed (inferred from source dates) · Structure
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER AWARENESS OF THE CAMPAIGN; QUARTERLY REPORTS REGARDING CAMPAIGN COMPLETION RATES; AS WELL AS ADDITIONAL MEASURES TO ENSURE A HIGH COMPLETION RATE, ABOVE AND BEYOND THE ACTIONS THAT NORMALLY WOULD BE TAKEN IN A FORMAL SAFETY RECALL.THESE INCLUDE FOLLOW UP WRITTEN AND TELEPHONIC NOTIFICATIONS TO OWNERS WHO DO NOT BRING THEIR VEHICLES IN FOR CORRECTIVE ACTION.NHTSA FIRMLY BELIEVES THAT THE CRASH PERFORMANCE OF THE LATCHES ON THESE MINIVANS RAISES SERIOUS SAFETY CONCERNS, AND THAT THE CAMPAIGN ADDRESSES THESE CONCERNS.THE CHRYSLER CORRECTIVE ACTION WILL INCREASE THE STRENGTH OF THE LIFTGATE LATCHES AND DECREASE THE POTENTIAL FOR INERTIAL UNLATCHING, THEREBY REDUCING THE RISK OF CRASH-RELATED OPENINGS OF THE LIFTGATE AND POSSIBLE OCCUPANT EJECTION THROUGH THE LIFTGATE OPENING.OWNERS OF CHRYSLER MINIVANS WILL GET A STRONGER, SAFER LATCH FREE OF CHARGE AT THE EARLIEST POSSIBLE TIME, WITHOUT THE NEED FOR FURTHER TECHNICAL INVESTIGATION AND COMPLEX AND TIME-CONSUMING LITIGATION WITH AN UNCERTAIN OUTCOME.BASED ON THE ABOVE, ODI IS CLOSING THIS INVESTIGATION.
1992 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration