Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 255 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Seat Belts. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports4 fire reports20 injury reports
What owners actually said
255 reports
167,000 miles · Jan 15, 2004
Engine And Engine CoolingPower TrainSeat Belts
BAD PAINT ITS PEELING FLAKEING THE WOOD GRAIN TOO FAIDING BAD TRANS I JUST PAID A DEALERSHIP OVER 2 GRAND FOR A NEW ONE WARRANTEED FOR ONLY 3 YEARS OR 36,000 MILES. BAD POWER WINDOWS CABLE BROKE=OVER $400.= ME GETTINGSCREWD BAD LUG NUTS LITTLE METAL CAPS OVER LUGNUTS COME OFF AND THEN TIRE TOOL DOSENT FIT SO YOU END UP AT…
Read full complaint
BAD PAINT ITS PEELING FLAKEING THE WOOD GRAIN TOO FAIDING BAD TRANS I JUST PAID A DEALERSHIP OVER 2 GRAND FOR A NEW ONE WARRANTEED FOR ONLY 3 YEARS OR 36,000 MILES. BAD POWER WINDOWS CABLE BROKE=OVER $400.= ME GETTINGSCREWD BAD LUG NUTS LITTLE METAL CAPS OVER LUGNUTS COME OFF AND THEN TIRE TOOL DOSENT FIT SO YOU END UP AT THE DEALERSHIP GETTING THEM CUT OFF. KEEPS STALLING HEADLINER FALLING DOWN HEADLIGHTS ARE TOTALLY YELLOW AT NIGHT YOU CANT SEE MORE THAN 50 FEET ON LOW BEAMS SO YOU HAVE TO HAVE HIGH BEAMS ON JUST TO GET LOW BEAM QUALITY. BREAKS NEW ROTORS, MASTERCILLENDER, HARDWEAR, DRUMS, SHOES, PADS, FLUID, MASTERCILLENDER CAPS, WEEL CILLENDERS,= OVER $500. TO THE DEALER AND ME AND MY FAM STRANDED ON THE ROADSIDE FOR 4 HOURES GETTING RECALLED PARTS FITTED ONLY TAKES AN ACT OF CONGRESS AND ABOUT THREE DAYS WITH OUT A CAR UNLESS THEY GIVE YOU THERE "LOANER" LOANER=CAR NO ONE WOULD BUT TWELVE YEARS AGO. JAMES REYNOLDS SHARON TENN GOOBERCLESE@HOTMAIL.COM OWNER OF A 92 DODGE GRAND CARAVAN LE
NHTSA ODI #10070192
Mileage unknown · Jan 1, 2004
Power TrainInjury
GEAR SHIFT DISENGAGED FROM PARK WHILE VEHICLE IGNITION WAS OFF. PURSE STRAP LOOPED OVER GEAR SHIFT AS OWNER WAS EXITING VEHICLE CAUSING VEHICLE GEAR SHIFT TO MOVE FROM PARK, VEHICLE BEGAN TO ROLL BACKWARDS CAUSING OWNER TO SLIP UNDER LEFT FRONT WHEEL. *AK
NHTSA ODI #10051493
150,490 miles · Dec 31, 2003
EquipmentStructure
THE HATCHBACK SUPPORT STRUT ON MY CARAVAN FAILED TODAY - THE BOLT THAT SUPPORTS THE STRUT IN THE CAR BODY SHEARED OFF, WHILE THE VEHCILE WAS STOPPED AT A STOP SIGN. THE STRUT EXPANDED INSIDE THE CAVITY IN THE BODY AS FAR AS IT COULD ONCE THE BOLT SHEARED. I BROUGHT MY CAR IN FOR THE RECALL (97V079000) IN ABOUT 1997. I KNOW CH…
Read full complaint
THE HATCHBACK SUPPORT STRUT ON MY CARAVAN FAILED TODAY - THE BOLT THAT SUPPORTS THE STRUT IN THE CAR BODY SHEARED OFF, WHILE THE VEHCILE WAS STOPPED AT A STOP SIGN. THE STRUT EXPANDED INSIDE THE CAVITY IN THE BODY AS FAR AS IT COULD ONCE THE BOLT SHEARED. I BROUGHT MY CAR IN FOR THE RECALL (97V079000) IN ABOUT 1997. I KNOW CHRYSLER PERFORMED THE RECALL BECAUSE THE NEW "BIGGER" WASHERS ARE ON THE LIFT SUPPORTS. AS I HAVE NO WAY TO EXAMINE THE BOLTS FOR STRESS CRACKING, THERE IS NO MAINTENANCE I CAN PERFORM TO INSURE THE REAR LIFTGATE WON'T FALL ONTO THE HEAD OF ME OR SOMEONE IN MY FAMILY. WAS THIS SUPPOSED TO BE A ONE-TIME RECALL FOR CHRYSLER? I GOT THE IMPRESSION THAT THIS RECALL WAS SUPPOSED TO "FIX" THE SHEARING BOLT PROBLEM, BUT IT IS SURPRISING TO ME THAT IT HAS RETURNED. I THINK IT IS VERY DANGEROUS.
NHTSA ODI #10051394
5,000 miles · Sep 15, 2003
Fuel System, Gasoline
ON AT LEAST FIVE OCCASIONS WHILE DRIVING ON HIGHWAY VEHICLE STALLED. ONCE VEHICLE CAME TO A COMPLETE STOP IT COULD BE RESTARTED. MANUFACTURER AND DEALER HAVE BEEN INFORMED OF THE PROBLEM.*AK
NHTSA ODI #10039975
38,000 miles · Aug 22, 2003
Service Brakes, Hydraulic
WHILE DRIVING WHEN ATTEMPTING TO STOP THE VEHICLE EXCESSIVE FORCE HAD TO BE APPLIED TO THE BRAKE PEDAL TO DEPRESS THE BRAKES. VEHICLE FAILED TO STOP, CAUSING EXTENDED STOPPING DISTANCE. EMERGENCY BRAKES HAD TO BE DEPRESSED TO STOP THE VEHICLE. THE CAUSE OF THE FAILURE IS UNDETERMINED. CONSUMER MADE CONTACT WITH THE DEALERSHIP…
Read full complaint
WHILE DRIVING WHEN ATTEMPTING TO STOP THE VEHICLE EXCESSIVE FORCE HAD TO BE APPLIED TO THE BRAKE PEDAL TO DEPRESS THE BRAKES. VEHICLE FAILED TO STOP, CAUSING EXTENDED STOPPING DISTANCE. EMERGENCY BRAKES HAD TO BE DEPRESSED TO STOP THE VEHICLE. THE CAUSE OF THE FAILURE IS UNDETERMINED. CONSUMER MADE CONTACT WITH THE DEALERSHIP. *AK
NHTSA ODI #10034297
Mileage unknown · Jul 30, 2003
SteeringSuspensionCrash
WHILE DRIVING, CONSUMER MADE A RIGHT TURN. THE TURN WAS COMPLETED SUCCESSFULLY, BUT THE STEERING WHEEL WOULD NOT RECOVER, RESULTING IN A COLLISION. DEALER DIAGNOSED FAILURE OF THE SPINDLE AND CONTROL ARM.*AK
NHTSA ODI #10031480
Mileage unknown · Jul 11, 2003
Service Brakes, Hydraulic
IN 1997 CONSUMER WAS DRIVING AND LOST BRAKE POWER. ABS PISTON WAS REPLACED PER THE RECALL # 96V099000 SUBJECT: BRAKES: HYDRAULIC: ANTI-SKID SYSTEM. ON 7/9/2003 THE CONSUMER WAS DRIVING AND LOST BRAKE POWER AGAIN. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT PISTON ON THE VEHICLE WAS THE SAME PISTON THAT WAS RECALLED,…
Read full complaint
IN 1997 CONSUMER WAS DRIVING AND LOST BRAKE POWER. ABS PISTON WAS REPLACED PER THE RECALL # 96V099000 SUBJECT: BRAKES: HYDRAULIC: ANTI-SKID SYSTEM. ON 7/9/2003 THE CONSUMER WAS DRIVING AND LOST BRAKE POWER AGAIN. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT PISTON ON THE VEHICLE WAS THE SAME PISTON THAT WAS RECALLED, WHICH HAD A LIFETIME WARRANTY. THE DEALER WILL NOT REPLACE THE PISTON BECAUSE THE WARRANTY STATED THAT PISTON WILL ONLY BE REPLACED IF FROZEN.*AK
NHTSA ODI #10027087
Mileage unknown · Jul 11, 2003
Service Brakes, Hydraulic
THE RECALL REMEDY FOR THE ABS 96 V 099 000 FAILED, AND THE DEFECT ACCRUED.*AK
NHTSA ODI #10027083
163,000 miles · Apr 16, 2003
Structure
THE FRONT PASSENGER BOTTOM HINGE THE WELD BROKE FROM THE DOOR AND BROKE THE HINGE IT SELF. CAN NO LONGER USE THE DOOR SAFELY. *NLM
NHTSA ODI #10014470
Mileage unknown · Dec 13, 2002
SeatsCrash
MY HUSBAND WAS REAR-ENDED BY A CAR AT APPROXIMATELY 30MPH IN OUR 1992 DODGE GRAND CARAVAN. THE BACK OF THE DRIVERS SEAT COLLAPSED. FORTUNATELY HE WAS NOT HURT, BUT HE COULD EASILY HAVE LOST CONTROL OF THE VEHICLE. ALSO, IF OUR 8 YEAR OLD CHILD HAD BEEN WITH HIM, SHE WOULD HAVE BEEN RIDING IN THE SEAT DIRECTLY BEHIND THE DRIVE…
Read full complaint
MY HUSBAND WAS REAR-ENDED BY A CAR AT APPROXIMATELY 30MPH IN OUR 1992 DODGE GRAND CARAVAN. THE BACK OF THE DRIVERS SEAT COLLAPSED. FORTUNATELY HE WAS NOT HURT, BUT HE COULD EASILY HAVE LOST CONTROL OF THE VEHICLE. ALSO, IF OUR 8 YEAR OLD CHILD HAD BEEN WITH HIM, SHE WOULD HAVE BEEN RIDING IN THE SEAT DIRECTLY BEHIND THE DRIVER AND COULD HAVE BEEN SEVERLY INJURED.
VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.
Consequence & remedy
Consequence: THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.
THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence & remedy
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence & remedy
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR ARMATURE CRACKS IN THE CENTER HUB ATTACHMENT AREA. ANY STEERING WHEELS SHOWING CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBURSED FOR PREVIOUS ABS COMPONENT REPAIR COSTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA97005 · Safety Belt Anchorage Failures
Opened Apr 10, 1997 · Closed Dec 23, 1997
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
There is no summary currently available
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
EA95029 · Steering Wheel Separation
Opened Sep 26, 1995 · Closed Nov 13, 1996
Status: closed (inferred from source dates) · Steering
AFTER AN EXTENSIVE INVESTIGATION AND ANALYSIS, CHRYSLER HAS IDENTIFIED THE DEFECT AS A FATIGUE FAILURE, ORIGINATION IN THE HEAT AFFECTED REGION OF THE PROJECTION WELDS OF THE STEERING WHEEL HUB TO STEERING WHEEL ARMATURE ATTACHMENT.THE HUB IS THE PORTION OF THE STEERING WHEEL ASSEMBLY THAT CONNECTS IT TO THE STEERING COLUMN SHAFT AND IS ATTACHED TO THE UNDERSIDE OF THE STEERING WHEEL ASSEMBLY BY 4 WELDS.IF CRACKS DEVELOP IN THE HEAT AFFECTED REGION OF THE WELDS AND PROPAGATE THROUGH THE STEERING WHEEL ARMATURE TO EACH OF THE WELDS, THE STEERING WHEEL CAN SEPARATE FROM THE HUB.THIS IS A SLOW PROGRESSIVE FAILURE WHICH NORMALLY OCCURS AT HIGH MILEAGE.IN SOME CASES COMPLAINANTS HAVE REPORTED A LOOSENESS OR WOBBLING OF THE STEERING WHEEL PRIOR TO SEPARATION.TO REMEDY THIS DEFECT, CHRYSLER WILL INSPECT THE STEERING WHEELS OF THE AFFECTED VEHICLES FOR CRACKS IN THE HUB AREA.IF ANY CRACKS ARE FOUND, THE STEERING WHEEL WILL BE REPLACED.ALL OTHER VEHICLES WILL HAVE REINFORCING PLATES INSTALLED WHICH WOULD PREVENT A STEERING WHEEL SEPARATION SHOULD CRACKING OCCUR.
EA94028 · Abs Braking System Fails
Opened Jul 29, 1994 · Closed Jun 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94024 · Abs Braking System Fails
Opened Mar 7, 1994 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA94005 · Liftgate Latches
Opened Jan 31, 1994 · Closed Oct 25, 1995
Status: closed (inferred from source dates) · Structure
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER AWARENESS OF THE CAMPAIGN; QUARTERLY REPORTS REGARDING CAMPAIGN COMPLETION RATES; AS WELL AS ADDITIONAL MEASURES TO ENSURE A HIGH COMPLETION RATE, ABOVE AND BEYOND THE ACTIONS THAT NORMALLY WOULD BE TAKEN IN A FORMAL SAFETY RECALL.THESE INCLUDE FOLLOW UP WRITTEN AND TELEPHONIC NOTIFICATIONS TO OWNERS WHO DO NOT BRING THEIR VEHICLES IN FOR CORRECTIVE ACTION.NHTSA FIRMLY BELIEVES THAT THE CRASH PERFORMANCE OF THE LATCHES ON THESE MINIVANS RAISES SERIOUS SAFETY CONCERNS, AND THAT THE CAMPAIGN ADDRESSES THESE CONCERNS.THE CHRYSLER CORRECTIVE ACTION WILL INCREASE THE STRENGTH OF THE LIFTGATE LATCHES AND DECREASE THE POTENTIAL FOR INERTIAL UNLATCHING, THEREBY REDUCING THE RISK OF CRASH-RELATED OPENINGS OF THE LIFTGATE AND POSSIBLE OCCUPANT EJECTION THROUGH THE LIFTGATE OPENING.OWNERS OF CHRYSLER MINIVANS WILL GET A STRONGER, SAFER LATCH FREE OF CHARGE AT THE EARLIEST POSSIBLE TIME, WITHOUT THE NEED FOR FURTHER TECHNICAL INVESTIGATION AND COMPLEX AND TIME-CONSUMING LITIGATION WITH AN UNCERTAIN OUTCOME.BASED ON THE ABOVE, ODI IS CLOSING THIS INVESTIGATION.
1992 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration