NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
24 reportsClear category filter63,000 miles · May 7, 2007
Power Train
I CURRENTLY HAVE 65,000 MILES ON A 2003 DODGE DURANGO SLT PLUS. THIS VEHICLE IS 4X4 AND HAS NEVER BEEN USED FOR TOWING. I WAS GETTING A KNOCKING NOISE IN THE FRONT END AT ANYTHING OVER 2700 RPMS. ALSO, I WAS HAVING A DRASTIC LOSE OF POWER ON THIS DURANGO AS WELL. I TOOK IT TO MY TRANSMISSION MECHANIC AND IT WAS FOUND TO BE …
Read full complaint
I CURRENTLY HAVE 65,000 MILES ON A 2003 DODGE DURANGO SLT PLUS. THIS VEHICLE IS 4X4 AND HAS NEVER BEEN USED FOR TOWING. I WAS GETTING A KNOCKING NOISE IN THE FRONT END AT ANYTHING OVER 2700 RPMS. ALSO, I WAS HAVING A DRASTIC LOSE OF POWER ON THIS DURANGO AS WELL. I TOOK IT TO MY TRANSMISSION MECHANIC AND IT WAS FOUND TO BE TROUBLE IN THE TRANSMISSION. I AM HAVING TO GET THE TRANSMISSION REBUILT ALREADY AT 65,000 MILES. *AK
NHTSA ODI #10189967
58,132 miles · Feb 27, 2007
Power TrainSuspension
TL*- THE CONTACT OWNS A 2003 DODGE DURANGO WITH AN ODOMETER READING OF 58132 MILES. THE CONTACT STATED THAT THE UPPER AND LOWER BALL JOINTS HAD BEEN REPLACED TWICE. THE CONTACT TOOK THE VEHICLE TO THE DEALER, AND THEY TOLD THE CONTACT THAT THIS VEHICLE WAS NOT COVERED BY RECALL 04V596000 . THE CONTACT STATED THAT THE VEHICLE…
Read full complaint
TL*- THE CONTACT OWNS A 2003 DODGE DURANGO WITH AN ODOMETER READING OF 58132 MILES. THE CONTACT STATED THAT THE UPPER AND LOWER BALL JOINTS HAD BEEN REPLACED TWICE. THE CONTACT TOOK THE VEHICLE TO THE DEALER, AND THEY TOLD THE CONTACT THAT THIS VEHICLE WAS NOT COVERED BY RECALL 04V596000 . THE CONTACT STATED THAT THE VEHICLE SHOULD BE INCLUDED UNDER THE RECALL BECAUSE IT WAS HAVING THE SAME FAILURE. *AK THE CONSUMER STATED THE CV JOINT FAILED AGAIN. UPDATED 03/30/07. *JB
NHTSA ODI #10183653
42,000 miles · Feb 11, 2007
Power TrainFire
MY WIFE HAD OUR 2003 DURANGO IN TO THE LOCAL DODGE DEALER FOR SERVICE ONE MORNING A FEW WEEKS AGO, SINCE IT WOULD NOT COME OUT OF 4 WHEEL DRIVE AND WAS STEERING FUNNY AND VIBRATING/CLUNKING. THEY TOLD HER IT WAS STILL UNDER WARANTY AND A PART WOULD HAVE TO BE ORDERED (TRANSFER MODULE) FOR THE CONTROL OF IT BUT IT WAS OK TO DRIV…
Read full complaint
MY WIFE HAD OUR 2003 DURANGO IN TO THE LOCAL DODGE DEALER FOR SERVICE ONE MORNING A FEW WEEKS AGO, SINCE IT WOULD NOT COME OUT OF 4 WHEEL DRIVE AND WAS STEERING FUNNY AND VIBRATING/CLUNKING. THEY TOLD HER IT WAS STILL UNDER WARANTY AND A PART WOULD HAVE TO BE ORDERED (TRANSFER MODULE) FOR THE CONTROL OF IT BUT IT WAS OK TO DRIVE TILL IT CAME IN AND COULD BE REPLACED. NONE WERE AVAILABLE AND CLEVELAND SHOWEDED THEM ON BACK-ORDER. MY WIFE DROVE TO OIL CITY, PA TO PICK UP PARTS FOR ME AND IT CAUGHT FIRE ON THE WAY ( SHE HAD TALKED TO THE DEALER A FEW MINUTES EARLIER ON HER CELL PHONE AS THE PROBLEM WAS GETTING WORSE AND THEY ASSURED HER IT WAS OK). SHE HAD TO PULL OVER AND CALL 911. THE FIRE AND POLICE WERE QUICK IN RESPONDING AND THE FIRE WAS PUT OUT AFTER A TOTAL LOSS OF THE VEHICLE. NOW THE DEALER WON'T DO ANYTHING ABOUT IT. MY WIFE COULD HAVE EASILY BEEN KILLED. *NM
NHTSA ODI #10182264
55,500 miles · Feb 5, 2007
Power Train
2003 DODGE DURANGO 2WD SLT HAS HAD TRANNY FAILURES CONSISTING OF ELECTRONIC COIL PACKS THAT CONTROL THE BAND LOCK-UP IN TRANNY FAILING TO ENGAGE OR DISENGAGE. THIS PROBLEM HAS CAUSED MY SPOUSE TO BE STUCK SEVERAL TIMES AND IN SEVERAL DIFFERENT PLACES. I HAVE FOUND THAT THE COST AND THE AVAILABLE PROCEDURE TO FIX IT IS TO PUT AN…
Read full complaint
2003 DODGE DURANGO 2WD SLT HAS HAD TRANNY FAILURES CONSISTING OF ELECTRONIC COIL PACKS THAT CONTROL THE BAND LOCK-UP IN TRANNY FAILING TO ENGAGE OR DISENGAGE. THIS PROBLEM HAS CAUSED MY SPOUSE TO BE STUCK SEVERAL TIMES AND IN SEVERAL DIFFERENT PLACES. I HAVE FOUND THAT THE COST AND THE AVAILABLE PROCEDURE TO FIX IT IS TO PUT ANOTHER TRANNY IN IT WITH POSSIBILITIES OF SAME PROBLEMS. *NM
NHTSA ODI #10181734
12,000 miles · Jan 19, 2007
Electrical SystemPower Train
WHILE DRIVING THE VEHICLE WILL SWITCH INTO FOUR WHEEL LOW. THE INDICATOR LIGHT FLASHES AS IF IT IS IN FOUR LOW. THE LAST TIME WE WERE TRAVELING 35 MILES PER HOUR AND IT HAPPENED. I'VE READ ABOUT THE VARIETY OF ELECTRICAL PROBLEMS AND BELIEVE THIS IS ONE MORE. THE KEY FOBS QUIT WORKING AND WE HAD A STRANGE "P D ONE" MESSAGE FLASH…
Read full complaint
WHILE DRIVING THE VEHICLE WILL SWITCH INTO FOUR WHEEL LOW. THE INDICATOR LIGHT FLASHES AS IF IT IS IN FOUR LOW. THE LAST TIME WE WERE TRAVELING 35 MILES PER HOUR AND IT HAPPENED. I'VE READ ABOUT THE VARIETY OF ELECTRICAL PROBLEMS AND BELIEVE THIS IS ONE MORE. THE KEY FOBS QUIT WORKING AND WE HAD A STRANGE "P D ONE" MESSAGE FLASH ON THE ODOMETER. IT HAS BEEN TO THE DEALER THREE SEPARATE TIMES AND THEY HAVE TOLD US WE WERE SWITCHING THE KNOB. THEY WON'T BELIEVE US BECAUSE THEY CAN'T MAKE IT HAPPEN. THIS, ALONG WITH THE TRANSMISSION AND OTHER ELECTRICAL COMPLAINTS MAKE ME THINK THESE ARE VERY UNSAFE VEHICLES TO BE ON THE ROAD. *JB
NHTSA ODI #10179167
100 miles · Jul 5, 2006
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
VEHICLE HAS A BRAKE PULSATION AND HAD A BRAKE SQUEAK. THIS HAS BEEN GOING ON SINCE VEHICLE WAS PURCHASED IN 10-03. VEHICLE WAS RETURNED TO DEALERSHIP WHILE UNDER WARRANTY. THEY REPLACED THE BRAKE PADS AND RESURFACED THE ROTORS. THIS DID NOT ELIMINATE THE PULSATION BUT DID ELIMINATE THE SQUEAK. THE TRANSMISSION BANGS INTO GEA…
Read full complaint
VEHICLE HAS A BRAKE PULSATION AND HAD A BRAKE SQUEAK. THIS HAS BEEN GOING ON SINCE VEHICLE WAS PURCHASED IN 10-03. VEHICLE WAS RETURNED TO DEALERSHIP WHILE UNDER WARRANTY. THEY REPLACED THE BRAKE PADS AND RESURFACED THE ROTORS. THIS DID NOT ELIMINATE THE PULSATION BUT DID ELIMINATE THE SQUEAK. THE TRANSMISSION BANGS INTO GEAR AND HAS A LONG DELAY GOING FROM PARK INTO REVERSE. THIS IS AN ONGOING PROBLEM. THE VEHICLE HAS BEEN RETURNED TO THE DEALER MORE THAN 10 TIMES. THEY CLAIMED THEY COULD NOT DUPLICATE THE PROBLEM. THIS IS AFTER TELLING US THEY FELT SOMETHING BUT DID NOT KNOW WHAT IT WAS. ENGINE STALLS AND RUNS ROUGH. THIS IS INTERMITTENT AND DEALER COULD NOT DUPLICATE IT. I HAVE SPOKEN WITH SEVERAL TRANSMISSION SHOPS AND THEY HAVE STATED THAT THERE IS A FIX FOR THE TRANSMISSION PROBLEM. CHRYSLER WILL NOT PERFORM THE REPAIR. THEY DID AGREE TO INSTALL THE NECESSARY PARTS IF I PURCHASED THEM BUT THEN THIS WOULD VOID MY WARRANTY. AND WHY SHOULD I PAY FOR A REPAIR THAT SHOULD BE COVERED UNDER MY WARRANTY?? *JB
NHTSA ODI #10161536
22,000 miles · Nov 12, 2005
Power Train
TRANSMISSION DISENGAGES WHEN ACCELERATING. DEALER REP COULDN'T FIND ANYTHING WRONG AND SAID THEY HAD NOT RECEIVED ANY SERVICE BULLETINS REGARDING THE PROBLEM. *JB
NHTSA ODI #10142513
30,000 miles · Sep 28, 2005
Engine And Engine CoolingLatches/locks/linkagesPower Train
FRONT SUSPENSION - DRIVE TRAIN - LOCKS - AXLE - POWER STEERING PUMP VEHICLE HAS HAD CONSISTENT FRONT END GRINDING NOISE SINCE 30,000 KM'S. BALL JOINTS HAVE BEEN REPLACED, FRONT AXLE SPYDER GEARS HAVE BEEN REPLACED. PREVIOUS 1998 DURANGO HAD SAME PROBLEM - FIX WAS FRONT WHEEL BEARINGS. 2003 DURANGO - DEALER SAYS THAT IT DOESN'T …
Read full complaint
FRONT SUSPENSION - DRIVE TRAIN - LOCKS - AXLE - POWER STEERING PUMP VEHICLE HAS HAD CONSISTENT FRONT END GRINDING NOISE SINCE 30,000 KM'S. BALL JOINTS HAVE BEEN REPLACED, FRONT AXLE SPYDER GEARS HAVE BEEN REPLACED. PREVIOUS 1998 DURANGO HAD SAME PROBLEM - FIX WAS FRONT WHEEL BEARINGS. 2003 DURANGO - DEALER SAYS THAT IT DOESN'T REQUIRE REPLACEMENT. NOISE AND GRINDING ONLY HAPPEN AT SLOW SPEED TURNS LEFT OR RIGHT. FROM STOP TO LIGHT ACCELERATION TO HARD LEFT OR RIGHT TURN, NEW NOISE FROM REAR AXLE - LIMITED SLIP UNIT NOW GETTING LOUDER. AXLE OIL AND LIMITED SLIP ADDITIVE HAVE BEEN REPLACED WITH FACTORY CHRYSLER OIL ADDITIVE. INDICATIVE OF SAME PROBLEM WITH 1998 DURANGO THAT I HAD, WHEN REAR AXLE PINION BEARING WAS HEAVILY SCORED. IN THAT INCIDENT THE SAME MAINTENANCE WAS DONE, BUT REPAIR WAS OUT OF WARRANTY BY 3,000 KM'S AND CHRYSLER ONLY PAID 50% OF REPAIR OF $700.00. OIL CHANGES ON COMPLETE DRIVETRAIN WAS $590.00 (4X4 WITH SKID PLATES). THIS APPEARS TO BE A METAL FATIGUE PROBLEM IN COMBINATION WITH ENGINEERING SPECIFICATIONS THAT ARE TOO WIDE IN TOLERANCES, WHICH ALLOWS FAILURE OF COMPONENTS TO COMPOUND PROBLEMS AND CREATE LONGER TERM DAMAGING RESULTS. EVER SINCE DODGE TRUCKS WENT TO MAINTENANCE FREE FRONT AXLE BEARINGS (YOU CAN'T PACK BEARINGS WITH GREASE), POOR LIMITED SLIP TOLERANCES IN REAR AXLE, AND TRANSFER CASE THAT'S ELECTRONICALLY OPERATED, THE DRIVETRAIN AND FRONT SUSPENSION COMPONENTS HAVE EXCESSIVE LOADS AND POOR QUALITY COMPONENTS. BOTH DURANGOS THAT I'VE OWNED HAVE HAD 5 WHEEL ALIGNMENTS (CONSTANT PULLING TO THE LEFT) AND NO OFF ROAD DRIVING. STRICTLY HIGHWAY AND CITY DRIVING. I PURCHASED FACTORY EXTENDED WARRANTY ON 2003 DURANGO WHICH I HIGHLY RECOMMEND. SO FAR, OUT OF POCKET EXPENSES HAVE BEEN MINIMAL, BUT DURANGO SPENDS TOO MUCH TIME IN THE SHOP AND IS VERY INCONVENIENT TO HAVE SERVICED CONSTANTLY. NEVER HAD ISSUES WITH WARRANTY PARTS OR DEALER NOT DOING WARRANTY RECALL WORK. *JB
NHTSA ODI #10137978
36,199 miles · Jun 17, 2005
EquipmentPower Train
I TOOK MY VEHICLE IN TO THE DEALER FOR AN OIL CHANGE AND WAS TOLD THERE IS METAL IN THE DIFFERENTIAL AND MY WARRANTY HAD EXPIRED, THE DIFFERENTIAL HAD COMPONENTS IN IT THAT CAME APART AND SHATTERED THEY HAVE TO BE REPLACED THE MECHANIC STILL HAS THE VEHICLE AND I BELIEVE I CAN GET THE OLD PARTS
NHTSA ODI #10125583
40,000 miles · Mar 7, 2005
Engine And Engine CoolingPower Train
WHILE DRIVING ANY SPEED, THE VEHICLE STALLED. . THE CAUSE WAS NOT DETERMINED. *JB UPDATED 5/3/2006 - THE CONSUMER SAT FOR ABOUT TEN MINUTES AND THE VEHICLE WAS RESTARTED. WHEN IT WAS RESTARTED IT MADE A LOT OF NOISE. THE CONSUMER DROVE THE VEHICLE HOME ABOUT 10 MPH. THE NEXT MORNING THE VEHICLE WAS TOWED TO A LOCAL REPAIR …
Read full complaint
WHILE DRIVING ANY SPEED, THE VEHICLE STALLED. . THE CAUSE WAS NOT DETERMINED. *JB UPDATED 5/3/2006 - THE CONSUMER SAT FOR ABOUT TEN MINUTES AND THE VEHICLE WAS RESTARTED. WHEN IT WAS RESTARTED IT MADE A LOT OF NOISE. THE CONSUMER DROVE THE VEHICLE HOME ABOUT 10 MPH. THE NEXT MORNING THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY WHO INDICATED THAT THE PROBLEM WAS PROBABLY WITH THE ENGINE OR TRANSMISSION. *NM
NHTSA ODI #10113516
Official recalls
4Sep 7, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A HIGH RESISTIVE SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE CONSOLE WIRING CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT ADDITIONAL FLUID FROM CONTAMINATING THE CONNECTOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT DAIMLER CHRYSLER AT 1-800-853-1403.
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 2, 2002
ON CERTAIN PICKUP TRUCKS, THE CENTRAL TIMER MODULE (CTM) HAS AN IMPROPERLY SIZED CIRCUIT BOARD TRACE THAT COULD POTENTIALLY CAUSE THE RIGHT HEADLAMP LOW BEAM TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE CTM. OWNER NOTIFICATION BEGAN DECEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA06011 · Vehicle UNDER-SEAT Fire
Opened Jun 19, 2006 · Closed Sep 22, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
PE06008 · Fire Under The Driver's Seat
Opened Feb 2, 2006 · Closed Jun 19, 2006
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash; Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Additional source detail variants (2)
Electrical System:wiring:interior/under Dash
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration