IllustrationWHILE DRIVING MY DURANGO, MY HEADLIGHTS FLASH ON AND OFF. THIS IS VERY UNSAFE AT NIGHT. THIS PROBLEM HAS BEEN RECALLED ON OTHER DURANGOS BUT MINE WAS NOT INCLUDED, THOUGH IT IS THE SAME PROBLEM. I HAVE TAKEN IT TO A MECHANIC ONLY TO BE TOLD THEY CAN NOT FIX IT, I HAVE TO USE A DODGE DEALER. *TR
2003 Dodge Durango
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Dodge Durango do not stand out strongly from the model-year median of 231.
About this comparison →How this year compares
Owner complaints by model year
Compare all Durango years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
660–25K
3925–50K
3350–75K
3675–100K
42100–150K
24150K+
240 reports with mileage · 99 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports18 fire reports16 injury reports
Exterior Lighting complaints
39 reportsTL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, HE HEARD CLICKING NOISE COMING FOR THE RIGHT SIDE OF THE INSTRUMENT PANEL. THE CONTACT THEN NOTICED THAT THE HEADLIGHTS WERE FLICKING ON AND OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY WO…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, HE HEARD CLICKING NOISE COMING FOR THE RIGHT SIDE OF THE INSTRUMENT PANEL. THE CONTACT THEN NOTICED THAT THE HEADLIGHTS WERE FLICKING ON AND OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY WOULD CONTACT HIM AT A LATER DATE. THE FAILURE MILEAGE WAS 145,000 AND THE CURRENT MILEAGE WAS 165,000.
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING, THE HEADLIGHTS AND THE INSTRUMENT PANEL LIGHTS STOPPED ILLUMINATING. THE CONTACT TURNED THE SWITCH AND THE LIGHTS CAME BACK ON, BUT THEN FAILED FIFTEEN MINUTES LATER. THE VEHICLE WAS NOT TAKEN TO A DEALER OR MECHANIC FOR INSPECTION. THE VEHICLE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING, THE HEADLIGHTS AND THE INSTRUMENT PANEL LIGHTS STOPPED ILLUMINATING. THE CONTACT TURNED THE SWITCH AND THE LIGHTS CAME BACK ON, BUT THEN FAILED FIFTEEN MINUTES LATER. THE VEHICLE WAS NOT TAKEN TO A DEALER OR MECHANIC FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE CONTACT NOTIFIED THE MANUFACTURER AND THEY STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 99,000.
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT THE AUTOMATIC KEY FOB FAILED AND ALL OF THE INTERIORS WARNING LAMPS WERE ILLUMINATED. IN ADDITION, THE CONTACT MENTIONED THAT THE ALL OF THE GAUGES WERE PROVIDING ERRONEOUS READINGS. THE HEAD LIGHTS HAD ALSO FAILED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO D…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT THE AUTOMATIC KEY FOB FAILED AND ALL OF THE INTERIORS WARNING LAMPS WERE ILLUMINATED. IN ADDITION, THE CONTACT MENTIONED THAT THE ALL OF THE GAUGES WERE PROVIDING ERRONEOUS READINGS. THE HEAD LIGHTS HAD ALSO FAILED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE CENTRAL TIMING MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 02V322000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 98,000 AND THE CURRENT MILEAGE WAS 104,230.
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING AT NIGHT AT HIGHWAY SPEEDS, THE EXTERIOR AND INTERIOR LIGHTS WOULD ILLUMINATE INTERMITTENTLY. BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT THE VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 02V322000 (EXTERIOR LIG…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING AT NIGHT AT HIGHWAY SPEEDS, THE EXTERIOR AND INTERIOR LIGHTS WOULD ILLUMINATE INTERMITTENTLY. BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT THE VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 02V322000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 108,000 AND THE CURRENT MILEAGE WAS 111,000.
TL* THE CONTACT OWNS A 2003 DODGE DURANGO SLT. THE CONTACT STATED THAT THE HEADLIGHTS FAILED AND WOULD FLICKER ON AND OFF. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE HEADLIGHT TIMING MODULE. THE MANUFACTURER ADVISED THE CONTACT THAT THE FAILURE WAS NOT RECALLED AND DENIED ASSIS…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO SLT. THE CONTACT STATED THAT THE HEADLIGHTS FAILED AND WOULD FLICKER ON AND OFF. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE HEADLIGHT TIMING MODULE. THE MANUFACTURER ADVISED THE CONTACT THAT THE FAILURE WAS NOT RECALLED AND DENIED ASSISTANCE WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 130,000.
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT THE EXTERIOR LIGHTS WERE INOPERATIVE. IN ADDITION, THE LOCKS, ALARM SYSTEM AND WINDSHIELD WIPERS WERE DEFECTIVE. A LOCAL MECHANIC STATED THAT THE CENTRAL TIMER MODULE WOULD NEED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECA…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT THE EXTERIOR LIGHTS WERE INOPERATIVE. IN ADDITION, THE LOCKS, ALARM SYSTEM AND WINDSHIELD WIPERS WERE DEFECTIVE. A LOCAL MECHANIC STATED THAT THE CENTRAL TIMER MODULE WOULD NEED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 02V322000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE MANUFACTURER DENIED ANY ASSISTANCE, BUT THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 83,926 AND THE CURRENT MILEAGE WAS 85,000.
TL*THE CONTACT OWNS A 2003 DODGE DURANGO. THE RIGHT SIDE OF THE VEHICLE WAS REPAIRED DUE TO BODY DAMAGE AND THE CONTACT WAS TOLD THAT THE RIGHT TURN SIGNAL WAS NOT WORKING. THE WINDSHIELD WIPERS, HEADLIGHTS AND TURN SIGNALS ALSO STOPPED WORKING. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THAT THE CENTRAL TIMING MODULE…
Read full complaint
TL*THE CONTACT OWNS A 2003 DODGE DURANGO. THE RIGHT SIDE OF THE VEHICLE WAS REPAIRED DUE TO BODY DAMAGE AND THE CONTACT WAS TOLD THAT THE RIGHT TURN SIGNAL WAS NOT WORKING. THE WINDSHIELD WIPERS, HEADLIGHTS AND TURN SIGNALS ALSO STOPPED WORKING. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THAT THE CENTRAL TIMING MODULE FAILED. RECALL CAMPAIGN NUMBER 02V322000, EXTERIOR LIGHTING: HEADLIGHT SWITCH WAS RELATED TOT HE FAILURE; HOWEVER, THE MANUFACTURER STATED THAT THE VIN WAS NOT A PART OF THE RECALL. THE FAILURE MILEAGE WAS 81000 AND THE CURRENT MILEAGE WAS 84000.
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT THE FRONT HEADLIGHTS WERE TOO LOW TO PROPERLY SEE THE ROADWAY WHEN DRIVING AT NIGHT. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC AND WAS ADVISED THAT THE CENTRAL TIMER MODULE ON THE VEHICLE WAS FAILING AND WAS ALSO UNDER RECALL. THE CONTACT WAS INFORM…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT THE FRONT HEADLIGHTS WERE TOO LOW TO PROPERLY SEE THE ROADWAY WHEN DRIVING AT NIGHT. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC AND WAS ADVISED THAT THE CENTRAL TIMER MODULE ON THE VEHICLE WAS FAILING AND WAS ALSO UNDER RECALL. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 02V322000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH).THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 155,632.
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT WAS TRAVELING IN INCLEMENT WEATHER WHEN THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTS FAILED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY FOR DIAGNOSIS. THE MECHANIC ADVISED THAT THE FAILURE WAS CAUSED BY THE CTM. THE CONTACT INQUIRED WITH THE MANUFACTURER ABOUT NHTSA CAMP…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT WAS TRAVELING IN INCLEMENT WEATHER WHEN THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTS FAILED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY FOR DIAGNOSIS. THE MECHANIC ADVISED THAT THE FAILURE WAS CAUSED BY THE CTM. THE CONTACT INQUIRED WITH THE MANUFACTURER ABOUT NHTSA CAMPAIGN ID NUMBER: 02V322000 (EXTERIOR LIGHTING: HEADLIGHTS: SWITCH) BUT WAS ADVISED HIS VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WOULD NOT PROVIDE ANY FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 51,000.
Official recalls
406V339000 · Electrical System
Sep 7, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A HIGH RESISTIVE SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE CONSOLE WIRING CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT ADDITIONAL FLUID FROM CONTAMINATING THE CONNECTOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT DAIMLER CHRYSLER AT 1-800-853-1403.
04V596000 · Suspension:front:control Arm:upper Ball Joint
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V216000 · Visibility:windshield Wiper/washer
May 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V322000 · Exterior Lighting:headlights:switch
Dec 2, 2002
ON CERTAIN PICKUP TRUCKS, THE CENTRAL TIMER MODULE (CTM) HAS AN IMPROPERLY SIZED CIRCUIT BOARD TRACE THAT COULD POTENTIALLY CAUSE THE RIGHT HEADLAMP LOW BEAM TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE CTM. OWNER NOTIFICATION BEGAN DECEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA06011 · Vehicle UNDER-SEAT Fire
Opened Jun 19, 2006 · Closed Sep 22, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
PE06008 · Fire Under The Driver's Seat
Opened Feb 2, 2006 · Closed Jun 19, 2006
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash; Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Additional source detail variants (2)
Electrical System:wiring:interior/under Dash
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.