NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
39 reportsClear category filterMileage unknown · Jul 14, 2025
EngineExterior LightingStructure
The obd reader on my 2003 Durango brings up code for central timing module and eeprm checksum error were the safety recall is in order but the vin number is not in the list of recall. It has all the specification of recall but vin number isn't in the list of recalls. I'm driving around in a unsafe vehicle due to manufacturing er…
Read full complaint
The obd reader on my 2003 Durango brings up code for central timing module and eeprm checksum error were the safety recall is in order but the vin number is not in the list of recall. It has all the specification of recall but vin number isn't in the list of recalls. I'm driving around in a unsafe vehicle due to manufacturing error that my vin number is the only thing why they won't fix it. Why do they not care if I kill myself or others from this that the recall is
NHTSA ODI #11673302
Mileage unknown · Nov 20, 2019
Exterior Lighting
I WAS DRIVING ALONG WHEN ALL LIGHTS INSIDE AND OUT STARTED TO FLASH ON AND OFF AT A VERY FAST RAT. THE CAR CONTINUED TO DRIVE OK. EVER SINCE THESE LIGHTS CONTINUE TO FLASH. I HAVE TALKED TO A FEW MECHANICS AND HAVE HAD DIFFERENT IDEAS. I CAN'T INVEST A FEW HUNDRED DOLLARS ON MAYBE S. PLEASE HELP. MILLAGE IS 126000
NHTSA ODI #11281410
Mileage unknown · Jun 29, 2018
Electrical SystemExterior Lighting
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTING FLICKERED ON AND OFF. THE VEHICLE WAS TAKEN TO DESERT 215 SUPERSTORE (8030 RAFAEL RIVERA WAY, LAS VEGAS, NV, (702) 963-8000) WHERE IT WAS DIAGNOSED THAT THE BODY MODULE COMPARTMENT NEEDED REPLACEMENT; HOWEVER, THE PART…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. THE CONTACT STATED THAT THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTING FLICKERED ON AND OFF. THE VEHICLE WAS TAKEN TO DESERT 215 SUPERSTORE (8030 RAFAEL RIVERA WAY, LAS VEGAS, NV, (702) 963-8000) WHERE IT WAS DIAGNOSED THAT THE BODY MODULE COMPARTMENT NEEDED REPLACEMENT; HOWEVER, THE PART WAS NO LONGER MANUFACTURED. THE DEALER STATED THAT THE PART COULD BE PURCHASED ONLINE AND THEY WOULD BE ABLE TO REPAIR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11104724
104,000 miles · May 16, 2016
Electrical SystemExterior Lighting
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. WHILE DRIVING APPROXIMATELY 20 MPH, THE HEADLAMP FLICKERED ON AND OFF. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CENTRAL TIMER MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V322000 (EXTERIOR LIGHT…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. WHILE DRIVING APPROXIMATELY 20 MPH, THE HEADLAMP FLICKERED ON AND OFF. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CENTRAL TIMER MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V322000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.
NHTSA ODI #10865080
98,000 miles · Oct 23, 2015
Electrical SystemExterior Lighting
SINCE PURCHASING THIS VEHICLE NEW IT HAS HAD MAJOR ELECTRICAL ISSUES. THE SAD PART, NOBODY AT DODGE CARED. IT WOULD SHIFT INTO 4WD LOW AT DANGEROUS SPEEDS. AFTER TAKING TO SEVERAL DODGE DEALERS NONE COULD OR WOULD FIX IT. DODGE THEMSELVES BASICALLY LAUGHED AT RIPPING OFF YET ANOTHER CUSTOMER. NHTSB HAS TOTALLY IGNORED THE THOUSA…
Read full complaint
SINCE PURCHASING THIS VEHICLE NEW IT HAS HAD MAJOR ELECTRICAL ISSUES. THE SAD PART, NOBODY AT DODGE CARED. IT WOULD SHIFT INTO 4WD LOW AT DANGEROUS SPEEDS. AFTER TAKING TO SEVERAL DODGE DEALERS NONE COULD OR WOULD FIX IT. DODGE THEMSELVES BASICALLY LAUGHED AT RIPPING OFF YET ANOTHER CUSTOMER. NHTSB HAS TOTALLY IGNORED THE THOUSANDS OF CONSUMERS WITH ISSUES ON THESE VEHICLES. OURS IS ANOTHER THAT HAVE THE PULSATING LIGHTS PROBLEM THAT APPARENTLY NHTSA AND DODGE FEEL IT ISN'T AN ISSUE TO HAVE YOUR LIGHTS TURN OFF WHILE DRIVING IN TRAFFIC AT 70 MPH. APPARENTLY IN THE AUTOMOTIVE/GOVT. RELATIONSHIP AS LONG AS THE VEHICLE HASN'T KILLED ALL OF US YET EVERYTHING IS OKAY. AT LEAST THE DODGE DEALERS ARE DOING WELL. THEY'VE RAKED IN MORE CASH BY DENYING THE ISSUE AND THROWING EXPENSIVE PARTS AT THESE LEMONS. MY QUESTION IS THIS: IF THESE VEHICLES HAVE HAD A RECALL ON :"SPECIFIC" VIN'S YET THOUSANDS OF OTHERS HAVE THE SAME ISSUE HOW DOES THE NHTSA JUSTIFY LEAVING THOSE CONSUMERS WITHOUT HELP OR PROTECTION?
NHTSA ODI #10785710
199,800 miles · Aug 16, 2015
Electrical SystemExterior LightingUnknown Or Other
THE PROBLEM ORIGINALLY STARTED ABOUT 2 WEEKS AGO. WHEN I SWITCHED ON THE REAR FAN (HEAT OR AC DID NOT MATTER), THE ENTIRE CENTER CONSOLE (RADIO, BLOWER SWITCHES, AND ELECTRONIC 4WD SWITCH) WOULD GO COMPLETELY DEAD, AND THE "SERVICE 4WD" LIGHT WOULD COME ON. THEN THIS STARTED HAPPENING WHEN I TURNED ON THE FRONT BLOWER OR THE R…
Read full complaint
THE PROBLEM ORIGINALLY STARTED ABOUT 2 WEEKS AGO. WHEN I SWITCHED ON THE REAR FAN (HEAT OR AC DID NOT MATTER), THE ENTIRE CENTER CONSOLE (RADIO, BLOWER SWITCHES, AND ELECTRONIC 4WD SWITCH) WOULD GO COMPLETELY DEAD, AND THE "SERVICE 4WD" LIGHT WOULD COME ON. THEN THIS STARTED HAPPENING WHEN I TURNED ON THE FRONT BLOWER OR THE REAR BLOWER. THEN IT STARTED HAPPENING WITH BOTH BLOWERS OFF AND THE HEADLIGHTS ON HIGH. NOW IT DOES IT SPONTANEOUSLY FOR NO APPARENT REASON WITH ALL EXTRA ELECTRICAL COMPONENTS (THE HEADLIGHTS, RADIO, AND BLOWERS) ALL OFF. I'M THINKING THERE IS A SHORT SOMEWHERE, BUT CANNOT IDENTIFY IT. SO FAR, I HAVE REPLACED THE BLOWER MOTOR RESISTOR, THE TCCM, AND THE IGNITION SWITCH WITH NO APPARENT IMPROVEMENT. I'VE ALSO HAD THE DASH APART AND CHECKED EVERY ELECTRICAL WIRE I COULD GET TO FOR OBVIOUS SHORTS. NO LUCK. THE PROBLEM IS GETTING PROGRESSIVELY WORSE. I TALKED TO THE MECHANIC AT THE LOCAL DODGE DEALER, AND HE SAID HE THINKS IT'S THE TIPM (MAIN FUSE BOX) IN THE ENGINE COMPARTMENT. HE SAID HE SEES THEM SHORT OUT "ALL THE TIME, SOME OF THEM SO BAD THEY ACTUALLY CATCH FIRE!" (DIRECT QUOTE FROM HIM.) I AM NOW TERRIFIED TO DRIVE MY DURANGO, BUT I CANNOT AFFORD THE HUNDREDS, IF NOT THOUSANDS, OF DOLLARS IT'S GOING TO COST TO FIX THE TIPM, IF THAT'S WHAT IT REALLY IS. BUT I DO NOT WANT DRIVE IT WITH THE POSSIBILITY OF A VEHICLE FIRE. I'VE DONE ALL KINDS OF INTERNET RESEARCH ON THIS, AND IT SEEMS LIKE A REALLY COMMON PROBLEM IN THE DURANGOS. ALSO, MY FRIEND WHO WORKS AT A SALVAGE YARD SAYS THESE FUSE BOXES ARE ONE OF THEIR MOST SOUGHT AFTER PARTS. SURELY AN ELECTRICAL PROBLEM THAT IS THIS COMMON AND OF SUCH A CATASTROPHIC MAGNITUDE SHOULD BE A RECALL!
NHTSA ODI #10748940
119,000 miles · Jul 31, 2015
Electrical SystemExterior LightingInterior Lighting
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. AFTER STARTING THE VEHICLE, THE HEADLIGHTS, TAIL LIGHTS, AND INTERIOR LIGHTS STARTED TO FLASH ON AND OFF WITH THE EMERGENCY INDICATOR ILLUMINATING ON THE INSTRUMENT PANEL. THE CONTACT MENTIONED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS D…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE DURANGO. AFTER STARTING THE VEHICLE, THE HEADLIGHTS, TAIL LIGHTS, AND INTERIOR LIGHTS STARTED TO FLASH ON AND OFF WITH THE EMERGENCY INDICATOR ILLUMINATING ON THE INSTRUMENT PANEL. THE CONTACT MENTIONED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE CENTRAL TIMER MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 119,000.
NHTSA ODI #10745456
190,000 miles · Jun 20, 2014
Electrical SystemExterior LightingVisibility/wiper
MY HEADLIGHTS AND INTERIOR LIGHTS STARTED BLINKING ACCOMPANIED BY A CLICKING SOUND COMING FROM THE LEFT SIDE OF THE STEERING PANEL. THE WINDSHIELD WIPERS ALSO DO NOT WORK UNLESS PUT ON HIGH, AND THE GAS LIGHT SOUND BEEPS EVERY 20-30 SECONDS CONTINUOUSLY UNTIL GAS IS PUT IN. THE BEEPING SOUND FOR THE GAS LIGHT WILL STOP ONCE REFI…
Read full complaint
MY HEADLIGHTS AND INTERIOR LIGHTS STARTED BLINKING ACCOMPANIED BY A CLICKING SOUND COMING FROM THE LEFT SIDE OF THE STEERING PANEL. THE WINDSHIELD WIPERS ALSO DO NOT WORK UNLESS PUT ON HIGH, AND THE GAS LIGHT SOUND BEEPS EVERY 20-30 SECONDS CONTINUOUSLY UNTIL GAS IS PUT IN. THE BEEPING SOUND FOR THE GAS LIGHT WILL STOP ONCE REFILLED BUT LIGHTS CONTINUE TO BLINK, INTERIOR AND EXTERIOR WHILE VEHICLE IS IN MOTION. I HAVE DONE RESEARCH ON THIS PROBLEM AND IT SEEMS LIKE EVERY OTHER PERSON WITH A 2003 DODGE DURANGO IS EXPERIENCING THE EXACT SAME PROBLEM BUT DODGE REFUSES TO RECALL THE PART, SAYING IT WAS FIXED, WHICH IS THE CTM MODULE CAUSING THIS PROBLEM, WHEN TAKEN INTO A DEALERSHIP IT IS THE CTM THAT NEEDS TO BE FIXED AND IS ABSURD THAT MORE VEHICLES HAVE NOT BEEN RECALLED FOR THIS PROBLEM WHEN EVERY SINGLE ONE IS EXPERIENCING THE EXACT SAME PROBLEMS. *TR
NHTSA ODI #10604738
134,000 miles · Jan 11, 2014
Exterior Lighting
WHILE DRIVING HEADLIGHTS WILL BLINK ON AND OFF. DASHBOARD LIGHTS WILL BLINK ON AND OFF. WIPERS ACT UP AND DON'T ALWAYS WORK. DOOR LOCKS WONT WORK. *TR
NHTSA ODI #10559476
128,259 miles · Aug 31, 2013
Electrical SystemExterior Lighting
WHILE DRIVING AT NIGHT HEADLIGHTS AND DASHBOARD LIGHTS START TO FLICKER. CLICKING SOUND HEARD WHILE THE FLASH OFF AND ON. *JS
NHTSA ODI #10538181
Official recalls
4Sep 7, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A HIGH RESISTIVE SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE CONSOLE WIRING CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT ADDITIONAL FLUID FROM CONTAMINATING THE CONNECTOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT DAIMLER CHRYSLER AT 1-800-853-1403.
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 2, 2002
ON CERTAIN PICKUP TRUCKS, THE CENTRAL TIMER MODULE (CTM) HAS AN IMPROPERLY SIZED CIRCUIT BOARD TRACE THAT COULD POTENTIALLY CAUSE THE RIGHT HEADLAMP LOW BEAM TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE CTM. OWNER NOTIFICATION BEGAN DECEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA06011 · Vehicle UNDER-SEAT Fire
Opened Jun 19, 2006 · Closed Sep 22, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
PE06008 · Fire Under The Driver's Seat
Opened Feb 2, 2006 · Closed Jun 19, 2006
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash; Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Additional source detail variants (2)
Electrical System:wiring:interior/under Dash
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration