NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
40 reportsClear category filter63,300 miles · Aug 22, 2007
Engine And Engine Cooling
WE BOUGHT A 2003 DODGE DURANGO ON JUNE 26, 2007. ON AUGUST 8, 2007 ALL OF A SUDDEN, WITH NO WARNING IT STARTED SOUNDING FUNNY, LIKE A DIESEL, A FEW MINUTES LATER THE OIL PRESSURE DROPPED TO ZERO AND JUST A FEW SECONDS AFTER THAT THE ENGINE LOCKED UP. WE WERE ON THE INTERSTATE ABUT 50 MILES FROM HOME WITH 2 CHILDREN. LUCKILY WE G…
Read full complaint
WE BOUGHT A 2003 DODGE DURANGO ON JUNE 26, 2007. ON AUGUST 8, 2007 ALL OF A SUDDEN, WITH NO WARNING IT STARTED SOUNDING FUNNY, LIKE A DIESEL, A FEW MINUTES LATER THE OIL PRESSURE DROPPED TO ZERO AND JUST A FEW SECONDS AFTER THAT THE ENGINE LOCKED UP. WE WERE ON THE INTERSTATE ABUT 50 MILES FROM HOME WITH 2 CHILDREN. LUCKILY WE GOT A RIDE HOME AND HAD THE VEHICLE TOWED LATER ON THAT NIGHT. THE VEHICLE WAS UNDER A 7 YR./70,000 MILE WARRANTY, BUT DODGE DOESN'T WANT TO HONOR IT. WE HAD THE VEHICLE BARELY OVER A MONTH WHEN THIS HAPPENED. I HAD JUST GOTTEN IT REGISTERED AND TAGGED 5 DAYS BEFORE IT HAPPENED AND MADE THE FIRST PAYMENT 7 DAYS BEFORE IT HAPPENED. NOW WE DON'T KNOW WHAT TO DO. I HAVE READ HUNDREDS OF OTHER REPORTS EXACTLY LIKE OUR SITUATION. PLEASE DO SOMETHING AND MAKE DODGE ACKNOWLEDGE THAT THERE IS A HUGE PROBLEM WITH THEIR ENGINES!!! *TR
NHTSA ODI #10200462
Mileage unknown · Jun 26, 2007
Engine And Engine Cooling
THE COOLING AND HEATING SYSTEM IN THE REAR OF THE VEHICLE HAS GIVEN WAY. ONLY THE FRONT OF THE VEHICLE HAS A/C WORKING. WILL TAKE VEHICLE TO DEALER TO ADDRESS PROBLEM. *AK
NHTSA ODI #10194247
56,235 miles · Nov 2, 2006
Engine And Engine CoolingFire
HAVE A 2003 DODGE DURANGO. WAS DRIVING DOWN THE HIGHWAY WHEN IT SOUNDED LIKE SOMETHING FELL OFF THE CAR THE CAR WAS IMMEDIATELY PULLED OVER AND THERE WERE FLAMES COMING FROM UNDER THE ENGINE. THE CAR QUICKLY BECAME TOTAL ENGULFED IN FLAMES AND BURNED UP. THE CAR IS A 100% LOSE. *NM
NHTSA ODI #10172458
54,881 miles · Jul 17, 2006
Engine And Engine Cooling
WHILE DRIVING DOWN HIGHWAY, THE OIL WARNING LIGHT CAME ON. IMMEDIATELY WE PULLED OVER AND CHECKED OIL, WHICH WAS FINE. WE STARTED THE CAR AND BEGAN DRIVING. WHILE DRIVING, THE ENGINE BEGAN TO MAKE A CLICKING NOISE. IMMEDIATELY, I PULLED OVER AGAIN AND HAD TO HAVE THE CAR TOWED TO A DODGE DEALERSHIP. I WAS TOLD BY THE DODGE …
Read full complaint
WHILE DRIVING DOWN HIGHWAY, THE OIL WARNING LIGHT CAME ON. IMMEDIATELY WE PULLED OVER AND CHECKED OIL, WHICH WAS FINE. WE STARTED THE CAR AND BEGAN DRIVING. WHILE DRIVING, THE ENGINE BEGAN TO MAKE A CLICKING NOISE. IMMEDIATELY, I PULLED OVER AGAIN AND HAD TO HAVE THE CAR TOWED TO A DODGE DEALERSHIP. I WAS TOLD BY THE DODGE SERVICE DEPARTMENT THAT THE ENGINE FAILURE WAS DUE TO SLUDGE IN THE OIL THAT BLOCKED THE SCREEN TO THE OIL PUMP. WE WOULD REQUIRE A NEW ENGINE. DODGE HAS DENIED OUR POWER TRAIN WARRANTY DUE TO THE SLUDGE. *JB
NHTSA ODI #10162691
100 miles · Jul 5, 2006
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
VEHICLE HAS A BRAKE PULSATION AND HAD A BRAKE SQUEAK. THIS HAS BEEN GOING ON SINCE VEHICLE WAS PURCHASED IN 10-03. VEHICLE WAS RETURNED TO DEALERSHIP WHILE UNDER WARRANTY. THEY REPLACED THE BRAKE PADS AND RESURFACED THE ROTORS. THIS DID NOT ELIMINATE THE PULSATION BUT DID ELIMINATE THE SQUEAK. THE TRANSMISSION BANGS INTO GEA…
Read full complaint
VEHICLE HAS A BRAKE PULSATION AND HAD A BRAKE SQUEAK. THIS HAS BEEN GOING ON SINCE VEHICLE WAS PURCHASED IN 10-03. VEHICLE WAS RETURNED TO DEALERSHIP WHILE UNDER WARRANTY. THEY REPLACED THE BRAKE PADS AND RESURFACED THE ROTORS. THIS DID NOT ELIMINATE THE PULSATION BUT DID ELIMINATE THE SQUEAK. THE TRANSMISSION BANGS INTO GEAR AND HAS A LONG DELAY GOING FROM PARK INTO REVERSE. THIS IS AN ONGOING PROBLEM. THE VEHICLE HAS BEEN RETURNED TO THE DEALER MORE THAN 10 TIMES. THEY CLAIMED THEY COULD NOT DUPLICATE THE PROBLEM. THIS IS AFTER TELLING US THEY FELT SOMETHING BUT DID NOT KNOW WHAT IT WAS. ENGINE STALLS AND RUNS ROUGH. THIS IS INTERMITTENT AND DEALER COULD NOT DUPLICATE IT. I HAVE SPOKEN WITH SEVERAL TRANSMISSION SHOPS AND THEY HAVE STATED THAT THERE IS A FIX FOR THE TRANSMISSION PROBLEM. CHRYSLER WILL NOT PERFORM THE REPAIR. THEY DID AGREE TO INSTALL THE NECESSARY PARTS IF I PURCHASED THEM BUT THEN THIS WOULD VOID MY WARRANTY. AND WHY SHOULD I PAY FOR A REPAIR THAT SHOULD BE COVERED UNDER MY WARRANTY?? *JB
NHTSA ODI #10161536
8,908 miles · Jan 23, 2006
Engine And Engine Cooling
SUDDEN ENGINE FAILURE WHILE DRIVING.*AK
NHTSA ODI #10148331
Mileage unknown · Dec 13, 2005
Engine And Engine Cooling
I HAVE A 2003 DURANGO, FOR THE PAST SEVERAL WEEKS, THE TRUCK WILL NOT START IN THE MORNING, YOU ARE FORCED TO HOLD YOU FOOT ON THE GAS UNTIL THE TRUCK IS WARMED UP. WHEN DRIVING, WHEN YOU COME TO A STOP THE IDLE OF THE TRUCK DROPS SO LOW, FEELS LIKE THE TRUCK IS GOING TO STALL, THEN IT CAUGHT ITSELF AT THE LAST MOMENT. TRUCK H…
Read full complaint
I HAVE A 2003 DURANGO, FOR THE PAST SEVERAL WEEKS, THE TRUCK WILL NOT START IN THE MORNING, YOU ARE FORCED TO HOLD YOU FOOT ON THE GAS UNTIL THE TRUCK IS WARMED UP. WHEN DRIVING, WHEN YOU COME TO A STOP THE IDLE OF THE TRUCK DROPS SO LOW, FEELS LIKE THE TRUCK IS GOING TO STALL, THEN IT CAUGHT ITSELF AT THE LAST MOMENT. TRUCK HAS BEEN BACK TO THE DEALER NO LESS THEN 9 TIMES FOR THIS PROBLEM. THEY HAVE NOT BEEN ABLE TO DUPLICATE THE PROBLEM. THE TRUCK JUST WENT OUT OF WARRANTY, SO I SURE NEXT TIME I BRING IT BACK, THEY WILL FIND WHAT THE PROBLEM IS. I WILL NEVER PURCHASE ANOTHER DODGE AGAIN! *NM
NHTSA ODI #10145066
42,361 miles · Nov 3, 2005
Engine And Engine Cooling
DT: THE CONTACT STATED WHILE DRIVING AN INDICATOR LIGHT CAME ON. ALSO, THE VEHICLE MADE A LOUD NOISE. THE ENGINE LOCKED. WAS THEN ABLE TO PULL OFF THE ROAD WITHOUT INCIDENT AND CHECKED THE MOTOR. THE VEHICLE WAS THEN TOWED A DEALERSHIP , WHO DETERMINED THAT THE DEFECT WAS THE OIL PICKUP IN THE ENGINE, THAT CAUSED IT TO LOCK…
Read full complaint
DT: THE CONTACT STATED WHILE DRIVING AN INDICATOR LIGHT CAME ON. ALSO, THE VEHICLE MADE A LOUD NOISE. THE ENGINE LOCKED. WAS THEN ABLE TO PULL OFF THE ROAD WITHOUT INCIDENT AND CHECKED THE MOTOR. THE VEHICLE WAS THEN TOWED A DEALERSHIP , WHO DETERMINED THAT THE DEFECT WAS THE OIL PICKUP IN THE ENGINE, THAT CAUSED IT TO LOCK. THE DEALERSHIP TOLD THE CONTACT THAT THE ENGINE WOULD NEED TO BE REPLACED. THE VEHICLE HAS BEEN IN A REPAIR SHOP FOR 4 MONTHS. *AK
NHTSA ODI #10141699
30,000 miles · Sep 28, 2005
Engine And Engine CoolingLatches/locks/linkagesPower Train
FRONT SUSPENSION - DRIVE TRAIN - LOCKS - AXLE - POWER STEERING PUMP VEHICLE HAS HAD CONSISTENT FRONT END GRINDING NOISE SINCE 30,000 KM'S. BALL JOINTS HAVE BEEN REPLACED, FRONT AXLE SPYDER GEARS HAVE BEEN REPLACED. PREVIOUS 1998 DURANGO HAD SAME PROBLEM - FIX WAS FRONT WHEEL BEARINGS. 2003 DURANGO - DEALER SAYS THAT IT DOESN'T …
Read full complaint
FRONT SUSPENSION - DRIVE TRAIN - LOCKS - AXLE - POWER STEERING PUMP VEHICLE HAS HAD CONSISTENT FRONT END GRINDING NOISE SINCE 30,000 KM'S. BALL JOINTS HAVE BEEN REPLACED, FRONT AXLE SPYDER GEARS HAVE BEEN REPLACED. PREVIOUS 1998 DURANGO HAD SAME PROBLEM - FIX WAS FRONT WHEEL BEARINGS. 2003 DURANGO - DEALER SAYS THAT IT DOESN'T REQUIRE REPLACEMENT. NOISE AND GRINDING ONLY HAPPEN AT SLOW SPEED TURNS LEFT OR RIGHT. FROM STOP TO LIGHT ACCELERATION TO HARD LEFT OR RIGHT TURN, NEW NOISE FROM REAR AXLE - LIMITED SLIP UNIT NOW GETTING LOUDER. AXLE OIL AND LIMITED SLIP ADDITIVE HAVE BEEN REPLACED WITH FACTORY CHRYSLER OIL ADDITIVE. INDICATIVE OF SAME PROBLEM WITH 1998 DURANGO THAT I HAD, WHEN REAR AXLE PINION BEARING WAS HEAVILY SCORED. IN THAT INCIDENT THE SAME MAINTENANCE WAS DONE, BUT REPAIR WAS OUT OF WARRANTY BY 3,000 KM'S AND CHRYSLER ONLY PAID 50% OF REPAIR OF $700.00. OIL CHANGES ON COMPLETE DRIVETRAIN WAS $590.00 (4X4 WITH SKID PLATES). THIS APPEARS TO BE A METAL FATIGUE PROBLEM IN COMBINATION WITH ENGINEERING SPECIFICATIONS THAT ARE TOO WIDE IN TOLERANCES, WHICH ALLOWS FAILURE OF COMPONENTS TO COMPOUND PROBLEMS AND CREATE LONGER TERM DAMAGING RESULTS. EVER SINCE DODGE TRUCKS WENT TO MAINTENANCE FREE FRONT AXLE BEARINGS (YOU CAN'T PACK BEARINGS WITH GREASE), POOR LIMITED SLIP TOLERANCES IN REAR AXLE, AND TRANSFER CASE THAT'S ELECTRONICALLY OPERATED, THE DRIVETRAIN AND FRONT SUSPENSION COMPONENTS HAVE EXCESSIVE LOADS AND POOR QUALITY COMPONENTS. BOTH DURANGOS THAT I'VE OWNED HAVE HAD 5 WHEEL ALIGNMENTS (CONSTANT PULLING TO THE LEFT) AND NO OFF ROAD DRIVING. STRICTLY HIGHWAY AND CITY DRIVING. I PURCHASED FACTORY EXTENDED WARRANTY ON 2003 DURANGO WHICH I HIGHLY RECOMMEND. SO FAR, OUT OF POCKET EXPENSES HAVE BEEN MINIMAL, BUT DURANGO SPENDS TOO MUCH TIME IN THE SHOP AND IS VERY INCONVENIENT TO HAVE SERVICED CONSTANTLY. NEVER HAD ISSUES WITH WARRANTY PARTS OR DEALER NOT DOING WARRANTY RECALL WORK. *JB
NHTSA ODI #10137978
33,593 miles · Aug 30, 2005
Engine And Engine CoolingSuspension
SLUDGE BUILD UP OCCURRED IN THE DODGE DURANGO.*MR THE DEALER INFORMED THE CONSUMER THAT THERE WAS SLUDGE IN THE ENGINE AND THAT IT WAS AS A RESULT OF NEGLECT WHICH THEN VOIDED THE WARRANTY. THE CONSUMER EXPLAINED THAT THE VEHICLE OIL HAD BEEN CHANGED NUMEROUS TIME BY NON-DEALER MECHANIC. THE DEALER NOR MANUFACTURER PROVIDED A…
Read full complaint
SLUDGE BUILD UP OCCURRED IN THE DODGE DURANGO.*MR THE DEALER INFORMED THE CONSUMER THAT THERE WAS SLUDGE IN THE ENGINE AND THAT IT WAS AS A RESULT OF NEGLECT WHICH THEN VOIDED THE WARRANTY. THE CONSUMER EXPLAINED THAT THE VEHICLE OIL HAD BEEN CHANGED NUMEROUS TIME BY NON-DEALER MECHANIC. THE DEALER NOR MANUFACTURER PROVIDED ANY FINANCIAL ASSISTANCE. THE CONSUMER HAD THE ENGINE REPLACED BY A LOCAL REPAIR FACILITY. THE CONSUMER'S VEHICLE WAS MAKING NOISE IN THE FRONT END. *NM
NHTSA ODI #10135598
Official recalls
4Sep 7, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A HIGH RESISTIVE SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE CONSOLE WIRING CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT ADDITIONAL FLUID FROM CONTAMINATING THE CONNECTOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT DAIMLER CHRYSLER AT 1-800-853-1403.
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 2, 2002
ON CERTAIN PICKUP TRUCKS, THE CENTRAL TIMER MODULE (CTM) HAS AN IMPROPERLY SIZED CIRCUIT BOARD TRACE THAT COULD POTENTIALLY CAUSE THE RIGHT HEADLAMP LOW BEAM TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE CTM. OWNER NOTIFICATION BEGAN DECEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA06011 · Vehicle UNDER-SEAT Fire
Opened Jun 19, 2006 · Closed Sep 22, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
PE06008 · Fire Under The Driver's Seat
Opened Feb 2, 2006 · Closed Jun 19, 2006
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash; Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Additional source detail variants (2)
Electrical System:wiring:interior/under Dash
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration