IllustrationWHEN DRIVING TO THE STORE I SHUT VEHICLE OFF AND WENT IN . WHEN I CAME OUT I CRANKED IT OVER AND IT STARTERED AND THEN CAUGHT ON FIRE BY FIREWALL AND WAS INGOLFED IN FLAMES
2002 Dodge Durango
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Dodge Durango do not stand out strongly from the model-year median of 231.
About this comparison →How this year compares
Owner complaints by model year
Compare all Durango years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
530–25K
7725–50K
3950–75K
3475–100K
61100–150K
23150K+
287 reports with mileage · 136 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
35 crash reports13 fire reports23 injury reports
Engine complaints
10 reportsWHEN DRIVING, THE STEERING WHEEL LOCKS AND THE CAR DIES. IT HAS HAPPEN SEVERAL TIMES WHILE I'M ON THE ROAD. REPLACED CAMSHAFT SENSOR BUT IT IS STILL DYING. IF YOU DO A GOOGLE SEARCH YOU WILL FIND THAT A LOT OF PEOPLE ARE HAVING THE SAME ISSUE. IT IS DANGEROUS AND MY LIFE AND THE LIFE OF OTHERS CAN BE AT RISK. *TR
WHILE DRIVING, NO MATTER WHAT SPEED THE VEHICLE STARTS TO SPUTTER, LOSES POWER AND WILL STALL. I WAS LOW ON GAS, AND TOOK MY CAR TO A LOCAL GAS STATION FOR FUEL. AFTER PUTTING $10 IN MY CAR WAS RUNNING EXTREMELY ROUGH. I WAS DOING ABOUT 20 MPH, WHEN IT JUST SHUT OFF. BRAKES GOT REAL HARD. AFTER RE STARTING THE VEHICLE ALL SEEMED…
Read full complaint
WHILE DRIVING, NO MATTER WHAT SPEED THE VEHICLE STARTS TO SPUTTER, LOSES POWER AND WILL STALL. I WAS LOW ON GAS, AND TOOK MY CAR TO A LOCAL GAS STATION FOR FUEL. AFTER PUTTING $10 IN MY CAR WAS RUNNING EXTREMELY ROUGH. I WAS DOING ABOUT 20 MPH, WHEN IT JUST SHUT OFF. BRAKES GOT REAL HARD. AFTER RE STARTING THE VEHICLE ALL SEEMED NORMAL. THEN, I DROVE ABOUT 3 CAR LENGTHS AND IT DID IT AGAIN AT A RED LIGHT. I TRIED PUSHING THE GAS TO SEE IF THAT WOULD DO ANYTHING, IT DIDNT. I DROVE ALL IN , ABOUT 3 MILES, AND THE CAR STALLED 7 TIMES. WHILE IN THE DRIVE THROUGH, IT STALLED 3 ABD AT ONE POINT JERKED SO FAR I THOUGHT I WAS GOING TO HIT THE CAR IN FRONT OF ME. VEHICLE SPEED DOES NOT MATTER , AS IT WILL SLOWLY LOSE POWER AND TURN OFF. I WAS DRIVING LOCALLY ON A CITY STREET. MY BEST GUESS TO THIS PROBLEM WOULD BE SOMETHING RELATED TO THE EVAP SYSTEM, QUITE POSSIBLY THE PURGE VALVE BUT IM NOT 100% SURE BUT THIS SITUATION IS VERY UNSAFE, I HAVE 2 SMALL CHILDREN AND CANNOT DRIVE THIS VEHICLE. DURING MY TRIP THE SPEED WAS BETWEEN 20-45 MPH
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING AND FAILED TO RESTART INTERMITTENTLY. THE VEHICLE WAS TOWED TO A REPAIR FACILITY THAT REPLACED THE CRANK SHAFT SENSOR, CAM SHAFT SENSOR, AND THE IGNITION SWITCH. AFTER THE REPAIRS, THE VEHICLE FAILED TO START. THE INDEPENDENT M…
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING AND FAILED TO RESTART INTERMITTENTLY. THE VEHICLE WAS TOWED TO A REPAIR FACILITY THAT REPLACED THE CRANK SHAFT SENSOR, CAM SHAFT SENSOR, AND THE IGNITION SWITCH. AFTER THE REPAIRS, THE VEHICLE FAILED TO START. THE INDEPENDENT MECHANIC WAS UNABLE TO GET A DIAGNOSTIC TROUBLE CODE READING AND INDICATED THAT THE PCM OR TIPM MAY NEED TO BE REPLACED. THE MECHANIC ALSO INDICATED THAT THE WIRING HARNESS MAY NEED TO BE REPLACED; HOWEVER, THE PART WAS NO LONGER IN PRODUCTION FOR THE YEAR, MAKE, AND MODEL VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
WHILE DRIVING ON AN INTERSTATE HIGHWAY AT 65 MILES PER HOUR THE ENGINE SHUT DOWN AND I PULLED OFF ONTO THE SHOULDER. AFTER SITTING FOR ABOUT 5 MINUTES I TRIED THE IGNITION KEY AND THE ENGINE STARTED AND I CONTINUED ON MY WAY.
A VALVE SEAT IN MY CYLINDER HEAD CAME OFF DURING NORMAL ENGINE OPERATION CAUSING TOTAL ENGINE DESTRUCTION. THE VALVE SEAT (MADE OF STEEL) DISLODGED ITSELF AND DESTROYED THE ALUMINUM HEAD AND THE PISTON IN THAT CYLINDER. THIS IS A FACTORY DEFAULT COMMON IN THESE ENGINES. I WAS DRIVING DOWN A BUSY ROAD WHEN THE VALVE LOCKED UP, LO…
Read full complaint
A VALVE SEAT IN MY CYLINDER HEAD CAME OFF DURING NORMAL ENGINE OPERATION CAUSING TOTAL ENGINE DESTRUCTION. THE VALVE SEAT (MADE OF STEEL) DISLODGED ITSELF AND DESTROYED THE ALUMINUM HEAD AND THE PISTON IN THAT CYLINDER. THIS IS A FACTORY DEFAULT COMMON IN THESE ENGINES. I WAS DRIVING DOWN A BUSY ROAD WHEN THE VALVE LOCKED UP, LOST COMPRESSION, CAUSING MY BRAKES TO GO OUT AND MY ENGINE TO STALL. I HAD TO PULL OFF THE ROAD TO AVOID THE CAR STOPPING IN FRONT OF ME.. THIS IS A DOCUMENTED FAILURE ON 1999-2002 CHRYSLER- JEEP 4.7L ENGINES.
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT REPLACED THE CRANKSHAFT POSITION SENSOR, BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 187,…
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT REPLACED THE CRANKSHAFT POSITION SENSOR, BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 187,000.
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE A…
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 187,000.
WAS DRIVING DOWN WAYNE ROAD WHEN SUDDENLY MY CAR STARTED SLOWING DOWN EVERYTHING SEEM TO BE WORKING EXCEPT THE GAS PADDLE. I HAD MY FEET ON GAS BUT IT WAS NOT RESPONDING I QUICKLY PULLED TO THE RIGHT AS IT WAS HARD TO TURN STEERING WHEEL. IT WAS CARS BEHIND ME AND IT WAS SCARY KNOWING SOMEONE COULD HIT ME . I CALLED MY HUSBAND A…
Read full complaint
WAS DRIVING DOWN WAYNE ROAD WHEN SUDDENLY MY CAR STARTED SLOWING DOWN EVERYTHING SEEM TO BE WORKING EXCEPT THE GAS PADDLE. I HAD MY FEET ON GAS BUT IT WAS NOT RESPONDING I QUICKLY PULLED TO THE RIGHT AS IT WAS HARD TO TURN STEERING WHEEL. IT WAS CARS BEHIND ME AND IT WAS SCARY KNOWING SOMEONE COULD HIT ME . I CALLED MY HUSBAND AND HE CAME THOUGHT HE COULD JUST GIVE ME A JUMP BUT HE SAID ITS NOTHING WRONG WITH BATTERY. IT LOOKS LIKE IM NOT GETTING ANY GAS. IT WONT TURN OVER SO HE PUSHED ME IN THE MALL. UNTIL I GET OFF FROM WORK. I WAS BLESSED THAT IT HAPPEN TO DO THAT ON THE DAY HE WAS OFF BECAUSE I JUST STARTED A NEW JOB AND I DIDN'T NEED TO MISS A DAY AS SOON AS I START WORKING. I ALSO READ MANY SIMILAR COMPLAINTS ON THIS IS. THIS SHOULD BE TAKEN CARE OF AND FAST. I THANK THE LORD FOR WATCHING OVER ME IN TRIAL MOMENTS. *TR
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT WHEN DRIVING, THE KEY WOULD RELEASE FROM THE IGNITION WHILE IN ANY GEAR. THE CONTACT ALSO STATED THAT THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DIAGNOSTIC WAS UNKNOWN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT WHEN DRIVING, THE KEY WOULD RELEASE FROM THE IGNITION WHILE IN ANY GEAR. THE CONTACT ALSO STATED THAT THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DIAGNOSTIC WAS UNKNOWN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
Official recalls
407V555000 · Power Train:automatic Transmission:lever And Linkage:column Shift
Dec 4, 2007
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
06V339000 · Electrical System
Sep 7, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A HIGH RESISTIVE SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE CONSOLE WIRING CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT ADDITIONAL FLUID FROM CONTAMINATING THE CONNECTOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT DAIMLER CHRYSLER AT 1-800-853-1403.
04V596000 · Suspension:front:control Arm:upper Ball Joint
Dec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
Consequence & remedy
Consequence: EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V216000 · Visibility:windshield Wiper/washer
May 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
Consequence & remedy
Consequence: DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA06011 · Vehicle UNDER-SEAT Fire
Opened Jun 19, 2006 · Closed Sep 22, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.
PE06008 · Fire Under The Driver's Seat
Opened Feb 2, 2006 · Closed Jun 19, 2006
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash; Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Additional source detail variants (2)
Electrical System:wiring:interior/under Dash
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
Seats
ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.
EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.