NHTSA owner reports · September 18, 2026 snapshot.
Visibility complaints
58 reportsClear category filter170,000 miles · Sep 6, 2011
Visibility
TL* THE CONTACT OWNS A 1999 DODGE DURANGO. THE CONTACT STATED THAT THE TWO REAR DRIVER AND PASSENGER WINDOWS WOULD JUST FALL DOWN ON THEIR OWN. THE VEHICLE WAS TAKEN TO A DEALER AND WHO ADVISED HER THAT THE ACTUATORS FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE W…
Read full complaint
TL* THE CONTACT OWNS A 1999 DODGE DURANGO. THE CONTACT STATED THAT THE TWO REAR DRIVER AND PASSENGER WINDOWS WOULD JUST FALL DOWN ON THEIR OWN. THE VEHICLE WAS TAKEN TO A DEALER AND WHO ADVISED HER THAT THE ACTUATORS FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000.
NHTSA ODI #10423862
Mileage unknown · Feb 26, 2008
SeatsVisibility
THE ELECTRONIC DRIVER SEAT STOP WORKING AND THE BACK WINDSHIELD WIPER MOTOR. *TR
NHTSA ODI #10219177
30,840 miles · Sep 7, 2007
Electrical SystemEngine And Engine CoolingExterior Lighting
TL*THE CONTACT OWNS A 1999 DODGE DURANGO. WHILE DRIVING 50 MPH, THE ABS AND BRAKE LIGHTS ILLUMINATED. THE DEALER STATED THAT THE CONTROL MODULE FAILED AND THEY REPLACED IT ON TWO OCCASIONS. APPROXIMATELY SIX MONTHS LATER, THE CHECK ENGINE LIGHT ILLUMINATED AND THE DEALER STATED THAT THE TRANSMISSION OUTPUT SENSOR FAILED. THE…
Read full complaint
TL*THE CONTACT OWNS A 1999 DODGE DURANGO. WHILE DRIVING 50 MPH, THE ABS AND BRAKE LIGHTS ILLUMINATED. THE DEALER STATED THAT THE CONTROL MODULE FAILED AND THEY REPLACED IT ON TWO OCCASIONS. APPROXIMATELY SIX MONTHS LATER, THE CHECK ENGINE LIGHT ILLUMINATED AND THE DEALER STATED THAT THE TRANSMISSION OUTPUT SENSOR FAILED. THEY MADE THE REPLACEMENT. APPROXIMATELY ONE YEAR LATER, THE REVERSE LIGHT AND REAR POWER WINDOWS WERE INOPERATIVE. THE DEALER INSTALLED A NEUTRAL SAFETY SWITCH. THE FAILURE MILEAGE WAS 30,840 AND CURRENT MILEAGE WAS 72,000. THE CONSUMER STATED WHEN SPOKE WITH MECHANIC AT SUPERSTITION THEY INFORMED HER THAT THE PROBLEM WAS THE EMISSION COIL WHICH CONTROLS THE SPARK PLUGS. UPDATED 10/24/07 *TR UPDATED 12/12/07 *TR
NHTSA ODI #10202157
57,000 miles · Aug 22, 2007
Engine And Engine CoolingPower TrainSuspension
I HAVE HAD REPEATED PROBLEMS WITH MY '99 DODGE DURANGO THAT STARTED WITH THE ENGINE LIGHT GOING ON IN SEPTEMBER 27, 2005 AND IS NOW THE NEED FOR A NEW CPM. THE CAR INTERMITTENT STALLS WHILE RIDING DOWN THE ROAD AT 55MPH OR AFTER IDLING AT STOP LIGHT & TURNING LEFT (POWER STEERING GOES OUT AND CAR BLOCKS INTERSECTION/TRAFFIC) - …
Read full complaint
I HAVE HAD REPEATED PROBLEMS WITH MY '99 DODGE DURANGO THAT STARTED WITH THE ENGINE LIGHT GOING ON IN SEPTEMBER 27, 2005 AND IS NOW THE NEED FOR A NEW CPM. THE CAR INTERMITTENT STALLS WHILE RIDING DOWN THE ROAD AT 55MPH OR AFTER IDLING AT STOP LIGHT & TURNING LEFT (POWER STEERING GOES OUT AND CAR BLOCKS INTERSECTION/TRAFFIC) - "NO BUS" APPEARS ON MILEAGE, EVERYTHING SHUTS OFF. SEEMS TO HAPPENS ON DAYS WHEN THE ENVIRONMENTAL TEMPERATURE EXCEEDS 75 DEGREES AND DISAPPEARS ONCE CAR HAS SAT (WHEREVER IT STALLED) FOR 20-30MINUTES. NO DIAGNOSTIC CODE APPEARS WHEN PUT THE CAR IS PUT ON THE COMPUTER AND I WAS ADVISED BY MORE THEN ONE DEALERSHIP THAT THE PROBLEM HAD TO GET WORSE AND PRODUCE A CODE BEFORE DEALERSHIP OR ANYONE ELSE COULD DIAGNOSE THE PROBLEM. NOW THAT THE 8 YR FEDERAL POWERTRAIN WARRANTY HAS EXPIRED FOR ME, IT SEEMS THE PROBLEM IS &ALWAYS WAS THAT THE POWERTRAIN CONTROL MODULE (PCM) IS MALFUNCTIONING &NEEDS TO BE REPLACED. THIS MAJOR COMPONENT IS COVERED THRU 8YRS/80,000 MI BY FEDERAL LAW BUT EVEN THOUGH PROBLEM BEGAN PRIOR TO 8TH YEAR, BECAUSE THIS PROBLEM WAS NOT DIAGNOSED UNTIL AFTER MY 8 YRS HAD BEEN EXCEEDED, IT IS NOW MY $800-$1200 BILL TO PAY (SINCE SEPT '05, HAVE REPLACED MOST COMPONENTS OF COOLANT SYSTEM, INTAKE MANIFOLD PAN GASKET, HEAD GASKET &STILL HAVE PROBLEM WITH ALIGNMENT/BALL JOINTS& REPEATED WINDOW MODULATOR PROBLEMS). *TR
NHTSA ODI #10200413
40,100 miles · Feb 14, 2006
Power TrainSuspensionVisibility
I'VE BEEN COMPLAINING OF ABNORMAL NOISES COMING FROM MY 1999 DODGE DURANGO SINCE MAY OF 2003, TO 2 DIFFERENT DODGE DEALER SERVICE DEPARTMENTS. THE STEERING IS "LOOSE" AND THE TIRES WEAR UNEVENLY NO MATTER HOW MANY TIMES I HAVE THEM ROTATED. AFTER A VERY SCARY ROAD TRIP WHERE I ALMOST VEERED OFF THE HIGHWAY SEVERAL TIMES, I BRO…
Read full complaint
I'VE BEEN COMPLAINING OF ABNORMAL NOISES COMING FROM MY 1999 DODGE DURANGO SINCE MAY OF 2003, TO 2 DIFFERENT DODGE DEALER SERVICE DEPARTMENTS. THE STEERING IS "LOOSE" AND THE TIRES WEAR UNEVENLY NO MATTER HOW MANY TIMES I HAVE THEM ROTATED. AFTER A VERY SCARY ROAD TRIP WHERE I ALMOST VEERED OFF THE HIGHWAY SEVERAL TIMES, I BROUGHT THE DURANGO TO A PRIVATE MECHANIC. THEY IMMEDIATELY DETECTED THE PROBLEM OF FAULTY BALL JOINTS AND A BAD REAR AXLE AND DIFFERENTIAL. WHEN THE MECHANIC CALLED DODGE TO ORDER PARTS, HE WAS TOLD THAT THIS IS A COMMON PROBLEM WITH DURANGO'S AND THE PARTS WERE IN STOCK. REPAIRS CONSISTED OF NEW UPPER AND LOWER BALL JOINTS, NEW FRONT TIRES (WITH ALIGNMENT) REPAIR AND REBUILD REAR AXLE AND DIFFERENTIAL. THIS WAS ALL PAID FOR BY ME PERSONALLY BECAUSE MY EXTENDED WARRANTY EXPIRED IN JUNE 2005. HOWEVER, I BELIEVE IT WOULD HAVE BEEN COVERED UNDER THE WARRANTY IF IN MAY 2003 THE DODGE MECHANICS WOULD HAVE FIGURED OUT WHAT THE PROBLEMS WERE. *NM THERE WAS A WATER LEAK AT THE RIGHT REAR WINDOW. UPDATED 04/10/06. *JB
NHTSA ODI #10150243
Mileage unknown · Aug 13, 2005
Visibility
3 OF 4 POWER WINDOWS FAILED TO WORK WITHIN 2 YEARS OF PURCHASE. NOTHING WAS DONE TO CORRECT THIS, WHEN ADDRESSED TO THE DEALERSHIP I WAS TOLD THE TOTAL PRICE OF PARTS AND LABOR (FULL PRICE). *JB
NHTSA ODI #10132729
Mileage unknown · Apr 20, 2005
SuspensionVisibility
MY 1999 DODGE DURANGO HAS HAD MANY PROBLEMS. THE BALL JOINTS HAVE ALREADY BEEN REPLACED BUT ARE STILL MAKING NOISE WHEN TURNING A CORNER. THE ELECTRICAL PANEL FOR THE WINDOWS HAS BEEN REPAIRED TWICE AND FINALLY REPLACED. THE BACK PASSENGER WINDOW STILL WILL NOT OPERATE. THE FUEL GAUGE IS NOT READING ACCURATELY EITHER.*AK
NHTSA ODI #10118161
Mileage unknown · Mar 8, 2005
SuspensionVisibility
THE UPPER AND LOWER BALL JOINTS IN THE CONSUMER'S 1999 DODGE DURANGO WORE OUT PREMATURELY. *NM THE BALL JOINT PROBLEM CAUSED PROBLEMS WITH; THE STEERING, TIRE WEAR, AND MIS-ALIGNMENT. THE REAR WINDOWS WOULD STICK. *SC *JB
NHTSA ODI #10114905
55,489 miles · Feb 7, 2005
Engine And Engine CoolingSuspensionVisibility
THE CONSUMER HAD TO REPLACE SEVERAL TIRES DUE TO WORN UPPER AND LOWER BALL JOINTS. *AK THE CONSUMER EXPERIENCED THE SAME RECALL PROBLEM AS THE 1998-1999 MODELS. THE RIGHT FRONT AND LEFT WINDOWS WERE INOPERATIVE, THERE WAS NOISES COMING FROM THE SERPENTINE BELT, THE VEHICLE HAD TAKEN TOO LONG TO CRANK AFTER SITTING FOR A WHI…
Read full complaint
THE CONSUMER HAD TO REPLACE SEVERAL TIRES DUE TO WORN UPPER AND LOWER BALL JOINTS. *AK THE CONSUMER EXPERIENCED THE SAME RECALL PROBLEM AS THE 1998-1999 MODELS. THE RIGHT FRONT AND LEFT WINDOWS WERE INOPERATIVE, THERE WAS NOISES COMING FROM THE SERPENTINE BELT, THE VEHICLE HAD TAKEN TOO LONG TO CRANK AFTER SITTING FOR A WHILE AND THE INTAKE MANIFOLD LEAKED OIL. *SC *JB
NHTSA ODI #10107129
45,699 miles · Jan 26, 2005
Engine And Engine CoolingSuspensionVisibility
VEHICLE WAS PURCHASED ON AUGUST 21, 1999. THE BALL JOINTS WERE SAME TYPE AS THOSE ON RECALL FOR YEAR BEGINNING 2000. *BF TWO YEARS AND FOUR MONTHS LATER THE BALL JOINTS FAILED. THE FRONT PASSENGER SIDE POWER WINDOW HAD BROKEN ALONG WITH THE TWO BACK POWER WINDOWS. THERE WAS ALSO A CRACKED SERPENTINE BELT, THE TENSIONER HAD…
Read full complaint
VEHICLE WAS PURCHASED ON AUGUST 21, 1999. THE BALL JOINTS WERE SAME TYPE AS THOSE ON RECALL FOR YEAR BEGINNING 2000. *BF TWO YEARS AND FOUR MONTHS LATER THE BALL JOINTS FAILED. THE FRONT PASSENGER SIDE POWER WINDOW HAD BROKEN ALONG WITH THE TWO BACK POWER WINDOWS. THERE WAS ALSO A CRACKED SERPENTINE BELT, THE TENSIONER HAD FROZEN, THE THROTTLE BODY WAS DIRTY AND THE GASKET WAS LEAKING. *SC *JB
NHTSA ODI #10111343
Official recalls
3May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Apr 11, 2001
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 2, 1999
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FUEL TANK STRAP CAN SEPARATE DUE TO FATIGUE DURING OPERATION. IF THIS OCCURS, THE TANK WILL BE UNSUPPORTED, INCREASING THE RISK OF A FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE DOUBLE TOGGLE LOCK FUEL TANK STRAPS WITH SINGLE TOGGLE LOCK DESIGN. NOTE: AFFECTED VEHICLES BUILT THROUGH MAY 21, 1998, ALSO REQUIRE THE REAR BRAKE TUBE INSPECTION/REPAIR. AS A RESULT, THE FUEL TANK STRAP AND BRAKE TUBE REPAIR WILL BE PERFORMED ON THESE VHEICLES IN A SINGLE SERVICE PROCEDURE UNDER RECALL 99V-341/DAIMLERCHRYSLER #841. AFFECTED VEHICLES BUILT FROM MAY 22, 1998 THROUGH SEPTEMBER 25, 1999, ONLY REQUIRE THE FUEL TANK STRAP REPAIR, WHICH WILL BE PERFORMED UNDER RECALL 99V-342/DAIMLERCHRYSLER #842.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration