IllustrationBALL JOINT GOING TOO EARLY ON DURANGO. CONTACTED DEALER AND MANUFACTURER WIHT NO SUCCESS.
1998 Dodge Durango
Owner reports · Recalls · Investigations
More warning signs than most Durango years
Owner complaints for the 1998 Dodge Durango are substantially higher than the model-year median of 231.
About this comparison →How this year compares
Owner complaints by model year
Compare all Durango years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
180–25K
8025–50K
15850–75K
9475–100K
75100–150K
16150K+
441 reports with mileage · 524 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 540 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 90 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports12 fire reports21 injury reports
What owners actually said
965 reports"#5 INJECTOR CIRCUIT HAD SHORTED TO THE FUEL PUMP INPUT IN THE POWERTRAIN CONTROL MODULE." GAS WAS LEAKING OUT OF THE MUFFLER!
FRONT DRIVER'S SEAT IS HELD DOWN WITH A PLASTIC PIECE.NOW SEATS ROCKS TO THE BACK. ALSO, WITH SUDDEN ACCELERATION FRONT SEAT TILTS. *AK
TRUCK IS NOT EQUIPPED WITH A BRAKE WARNING SENSOR. OWNER HAS NO WAY OF KNOWING WHEN THE BRAKES NEED TO BE SERVICED WHICH COULD LEAD TO A CRASH. *AK *ML
WHILE ON THE HIGHWAY, THE GAS PEDAL DROPPED TO THE FLOOR AND THE CAR ACCELERATED OUT OF CONTROL. APPLYING THE BRAKES DID NOT STOP THE VEHICLE. THE CAR HAD ACCELERATED TO OVER 85 MPH WHEN I PULLED TO THE SHOULDER LANE. I THEN STOOD UP ON THE BRAKE PEDAL, SLOWED THE CAR DOWN TO 35 MPH AND TURNED THE CAR OFF. THE CAR EVENTUALLY…
Read full complaint
WHILE ON THE HIGHWAY, THE GAS PEDAL DROPPED TO THE FLOOR AND THE CAR ACCELERATED OUT OF CONTROL. APPLYING THE BRAKES DID NOT STOP THE VEHICLE. THE CAR HAD ACCELERATED TO OVER 85 MPH WHEN I PULLED TO THE SHOULDER LANE. I THEN STOOD UP ON THE BRAKE PEDAL, SLOWED THE CAR DOWN TO 35 MPH AND TURNED THE CAR OFF. THE CAR EVENTUALLY CAME TO A STOP. AN AAA TOW TRUCK CAME OUT TO HELP. THE TOW TRUCK OPERATOR CONFIRMS THAT WHEN HE TOWED THE TRUCK THAT THE GAS PEDAL WAS STILL ON THE FLOOR. WHEN THE CAR WAS DROPPED OFF AT THE DEALER, THE PEDAL WAS BACK IN A MORE NORMAL POSITION. THE DEALER WAS UNABLE TO FIND ANYTHING WRONG WITH THE VEHICLE.
NOTICED DRIVER'S SEAT ROCKING FORCE AND AFT DURING ACCELERATION AND STOPPING. TOOK VEHICLE TO DEALER FOR REPAIR. DEALER SAID PARTS ON ORDER. PARTS NEVER ARRIVED. DEALER NOW CLAIMS SITUATION NORMAL. FAILURE OF THIS COMPONENT DURING OPERATION WILL RESULT IN LOSS OF VEHICLE CONTROL LEADING TO POSSIBLE INJURY AND/OR DAMAGE.
THIRD ROW OF SEATS, WHEN APPLYING THE LATCH TO GET OUT OF THE VEHICLE, THE THIRD ROW OF SEATS WON'T ALLOW THE DOOR TO OPEN. *AK
I WAS DRIVING IN A RAINSTORM AND HIT A POCKET OF WATER ON THE HIGHWAY. I HYDRO-PLANED INTO A CONCRETE BARRICADE, HITTING THE WALL AT ABOUT A 40-45 DEGREE ANGLE. THE REAR END STARTED TO SPIN COUNTER-CLOCKWISE, SO I STEERED INTO THE SKID. THIS STOPPED THE COUNTER-CLOCKWISE SKID, BUT THREW ME BACK INTO THE BARRICADE - HITTING TH…
Read full complaint
I WAS DRIVING IN A RAINSTORM AND HIT A POCKET OF WATER ON THE HIGHWAY. I HYDRO-PLANED INTO A CONCRETE BARRICADE, HITTING THE WALL AT ABOUT A 40-45 DEGREE ANGLE. THE REAR END STARTED TO SPIN COUNTER-CLOCKWISE, SO I STEERED INTO THE SKID. THIS STOPPED THE COUNTER-CLOCKWISE SKID, BUT THREW ME BACK INTO THE BARRICADE - HITTING THE ENTIRE DRIVER SIDE AND MORE ESPECIALLY THE REAR WHEEL. WHEN I HIT THE WALL, THE REAR DRIVER SIDE LEAF SPRING "WHIPLASHED" IN-BOARD AND CRACKED THE GAS TANK. THE CRACK IS APPROXIMATELY 2-3 INCHES LONG. I DID NOT NOTICE THE CRACK RIGHT AWAY, AND WAS ABLE TO CONTINUE HOME. THE "LOW FUEL WARNING LIGHT" CAME ON AND I STOPPED FOR GAS. IT WAS AT THIS TIME THAT I NOTICED THAT THE FUEL WAS RUNNING OUT ON THE GROUND. I TOOK THE VEHICLE TO THE LOCAL DODGE DEALER FOR REPAIR, AND PERHAPS INVESTIGATION INTO THE FAULTY PLACEMENT OF THE SPRINGS. THEY HAVE IGNORED THE SITUATION AND GAVE ME THE 800 NUMBER FOR CHRYSLER CUSTOMER RELATIONS. WHEN I CALLED THEM, I EXPLAINED THE SITUATION AND RECEIVED BASICALLY A "SO WHAT ??" ATTITUDE. I AM A PROPERTY AND CASUALTY INSURANCE AGENT AND WOULD NOT WANT ANY OF MY INSURANCE CARRIERS TO NEEDLESSLY PAY CLAIMS FOR FAULTY DESIGN. I FEEL THAT THIS NEEDS TO BE INVESTIGATED AS SOON AS POSSIBLE TO PREVENT THE UNNECESSARY LOSS OF LIFE AND NEEDLESS PROPERTY DAMAGE. I WAS LUCKY THAT IT WAS RAINING THE NIGHT THAT THIS HAPPENED WHICH LESSENED THE "SPARKS" POTENTIAL. HAD THERE BEEN SPARKS OF METAL ON CONCRETE, I WOULD PROBABLY HAVE BEEN BURNED IN THE WRECKAGE. I AM REMINDED OF THE FAULTY PLACEMENT OF THE SADDLE TANKS ON THE GMC PICKUP TRUCKS WHICH CAUSED MILLIONS OF DOLLARS IN CLAIMS AND SETTLEMENTS. I BROUGHT THIS UP TO CHRYSLER AND THEIR QUESTION WAS "WHAT DO YOU WANT CHRYSLER TO DO?". YOUR RESPONSE WILL BE GREATLY APPRECIATED. *AK
VEHICLE WAS SHIFTED OUT OF GEAR BY A TWO- YEAR OLD CHILD WHILE PARKED, CAUSING VEHICLE TO ROLL INTO ANOTHER VEHICLE. VEHICLE GEAR SHIFT WAS NOT SUPPOSE TO MOVED UNLESS FOOT WAS PRESSED ON BRAKE PEDAL. DEALER NOTIFIED. *AK
WHEN DRIVING VEHICLE AT A SPEED OF 55 MPH OR ABOVE WITH BACK WINDOWS DOWN THE VHEICLE STARTS TO VIBERATE UNTIL IT IS ALMOST IMPOSSIBLE TO HOLD ON THE ROAD. THIS VIBERATION IS LIKE HAVING A FLAT TIRE WITH THE EXCEPTION OF THE COMPLETE VEHICLE VIBERATING
Official recalls
401V153000 · Air Bags
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V341000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Dec 2, 1999
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE REAR BRAKE TUBE CAN CONTACT AN UNDERBODY CROSSMEMBER EVENTUALLY WEARING A HOLE IN THE TUBE.
Consequence & remedy
Consequence: IF THE TUBE WERE PERFORATED, THERE WOULD BE A REDUCTION IN BRAKING FROM THE REAR WHEELS, INCREASING STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL A RUBBER ISOLATOR ON ALL VEHICLES THAT DO NOT INDICATE TUBE CONTACT. VEHICLES THAT SHOW CONTACT AND HAVE LESS THAN 45,000 MILES AND NO SIGNS OF RED RUST WILL HAVE THE RUBBER ISOLATOR INSTALLED WITH SILICONE TO PROTECT THE TUBE WHERE THE COATING HAS WORN OFF. VEHICLES THAT EXHIBIT CONTACT, AND HAVE MORE THAN 45,000 MILES OR SHOW SIGNS OF RED RUST, WILL HAVE THE BRAKE TUBE REPLACED WITH THE PRODUCTION TUBE AND ISOLATOR.
99V342000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Dec 2, 1999
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FUEL TANK STRAP CAN SEPARATE DUE TO FATIGUE DURING OPERATION. IF THIS OCCURS, THE TANK WILL BE UNSUPPORTED, INCREASING THE RISK OF A FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE DOUBLE TOGGLE LOCK FUEL TANK STRAPS WITH SINGLE TOGGLE LOCK DESIGN. NOTE: AFFECTED VEHICLES BUILT THROUGH MAY 21, 1998, ALSO REQUIRE THE REAR BRAKE TUBE INSPECTION/REPAIR. AS A RESULT, THE FUEL TANK STRAP AND BRAKE TUBE REPAIR WILL BE PERFORMED ON THESE VHEICLES IN A SINGLE SERVICE PROCEDURE UNDER RECALL 99V-341/DAIMLERCHRYSLER #841. AFFECTED VEHICLES BUILT FROM MAY 22, 1998 THROUGH SEPTEMBER 25, 1999, ONLY REQUIRE THE FUEL TANK STRAP REPAIR, WHICH WILL BE PERFORMED UNDER RECALL 99V-342/DAIMLERCHRYSLER #842.
98V019000 · Electrical System:alternator/generator/regulator
Jan 30, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE FASTENER WHICH SECURES THE GENERATOR CABLE TO THE POWER DISTRIBUTION CENTER (PDC) HAS AN INSUFFICIENT CLAMP LOAD, RESULTING IN A LOOSE CONNECTION AND ELECTRICAL ARCING AT THE CONNECTION.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL RETIGHTEN THE GENERATOR CABLE AND BATTERY CABLE FASTENERS TO THE PROPER TORQUE SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.