BOUGHT MY DURANGO NEW IN MAY 1998. THE AUTOMATIC TRANSMISSION STARTED SHIFTING IMPROPERLY IN JULY 2000. TOOK IT TO A DODGE DEALER BECAUSE IT WAS STILL UNDER WARRANTY (31,418 MILES). THEY DROPPED THE TRANSMISSION PAN AND PRONOUNCED IT DOA (PAN WAS FULL OF METAL SHAVINGS). SHOULD HAVE SEEN THE WRITING ON THE WALL BUT I LOVED THIS …
Read full complaint
BOUGHT MY DURANGO NEW IN MAY 1998. THE AUTOMATIC TRANSMISSION STARTED SHIFTING IMPROPERLY IN JULY 2000. TOOK IT TO A DODGE DEALER BECAUSE IT WAS STILL UNDER WARRANTY (31,418 MILES). THEY DROPPED THE TRANSMISSION PAN AND PRONOUNCED IT DOA (PAN WAS FULL OF METAL SHAVINGS). SHOULD HAVE SEEN THE WRITING ON THE WALL BUT I LOVED THIS VEHICLE. TOOK IT TO AN INSPECTION STATION FOR SAFETY & EMISSIONS TESTS IN MAY OF 2006. IT FAILED FOR BAD BALL JOINTS. I ASKED THE MANAGER WHY HIS MECHANICS SEEMED TO PAY SPECIAL ATTENTION TO THE FRONT END DURING INSPECTION AND HIS REPLY WAS IT WAS VERY COMMON TO FIND BAD BALL JOINTS ON APPROX. 50% OF ALL 1998-2000 DURANGOS. HAD MY MECHANIC REPLACE UPPER & LOWER BALL JOINTS, BOTH SIDES, AT 74,064 MILES, TO THE TUNE OF $701 PLUS TAX. I THEN STARTED HEARING ABOUT OTHER DURANGO OWNERS WITH SIMILAR BALL JOINT WOES. I WENT ONLINE AND STARTED RESEARCHING. FOUND A SITE WHERE FOLKS LIKE MYSELF WITH THE SAME BALL JOINT PROBLEMS, SOME WITH ACCIDENTS, WERE TRYING TO GET NHTSA TO DO SOMETHING. I GUESS PEOPLE ACTUALLY HAVE TO DIE FIRST BEFORE NHTSA WILL STEP IN AND TELL AN AUTO MANUFACTURER THEY NEED TO FIX THEIR FAULTY PRODUCTS. I ALSO LEARNED THAT THE 1998-2000 DURANGOS WERE BUILT ON THE DODGE DAKOTA PICKUP CHASSIS. A DAKOTA WEIGHS ABOUT 4,600 LBS. WHILE A DURANGO 4X4 WEIGHS IN AT 6,400 LBS. IT'S NO WONDER THE 1998-2000 DURANGO FRONT-ENDS WERE FALLING APART. SERIOUSLY, WHAT KIND OF IDIOT ENGINEERS DOES DODGE HAVE WORKING FOR THEM. SOMETIME LATER I HEARD THAT DODGE RUSHED THE DURANGO INTO PRODUCTION IN 1998 TO COMPETE FOR THE SUV MARKET BUCKS AND DIDN'T HAVE TIME TO ENGINEER A NEW CHASSIS SO THEY JUST MODIFIED THE DAKOTA CHASSIS WITHOUT BEEFING IT UP. WHEN PEOPLE STARTED TO COMPLAIN ABOUT BALL JOINTS AND SUCH, THEY BUILT A WHOLE NEW CHASSIS FOR DURANGOS IN 2001. I STUMBLED ACROSS THIS SITE TODAY WHILE RESEARCHING ANOTHER VEHICLE I'M THINKING ABOUT BUYING.
NHTSA ODI #10886041
Mileage unknown · Aug 29, 2015
Suspension
THE CV JOINT CAME OUT RUIN THE LOWER BALL JOINTS WHICH CAUSED RUBBING ON MY INNER RIM, AFTER A WHILE IT HAS CAUSE THE INNER RIM TO TO BREAK OUT WHILE I WAS DRIVING. WE HAVE REPLACED THE CV JOINT, WHEEL HUB BEARING, UPPER AND LOWER BALL JOINTS AND THE STEERING BALL JOINT. NOW THE LOWER BALL JOINT IS STILL HITTING THE INNER RIM …
Read full complaint
THE CV JOINT CAME OUT RUIN THE LOWER BALL JOINTS WHICH CAUSED RUBBING ON MY INNER RIM, AFTER A WHILE IT HAS CAUSE THE INNER RIM TO TO BREAK OUT WHILE I WAS DRIVING. WE HAVE REPLACED THE CV JOINT, WHEEL HUB BEARING, UPPER AND LOWER BALL JOINTS AND THE STEERING BALL JOINT. NOW THE LOWER BALL JOINT IS STILL HITTING THE INNER RIM AND I CAN'T DRIVE
NHTSA ODI #10760195
68,000 miles · Jan 6, 2014
Suspension
TL* THE CONTACT OWNS A 1998 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, HE NOTICED AN ABNORMAL NOISE FROM THE FRONT END. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS, WHO STATED THAT THE FRONT UPPER AND LOWER BALL JOINTS WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE …
Read full complaint
TL* THE CONTACT OWNS A 1998 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, HE NOTICED AN ABNORMAL NOISE FROM THE FRONT END. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS, WHO STATED THAT THE FRONT UPPER AND LOWER BALL JOINTS WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000 UPDATED 02/11/2014 *BF
NHTSA ODI #10558610
123,000 miles · Dec 12, 2010
Suspension
THE VEHICLE IS MAKING A VERY NOTICEABLE "CLUNKING NOISE" DURING TURNS AND OVER BUMPS. THE VEHICLE OFTEN FALLS OUT OF ALIGNMENT AND DRIVING FEELS UNSTEADY AS ON OF THE FRONT WHEELS IS LOOSE. UPON INSPECTION IT APPEARS THIS IS BEING CAUSED BY PREMATURE WEAR TO THE UPPER BALL JOINTS. THIS HAS ALSO CAUSED EXCESS WEAR ON THE VEHICLE …
Read full complaint
THE VEHICLE IS MAKING A VERY NOTICEABLE "CLUNKING NOISE" DURING TURNS AND OVER BUMPS. THE VEHICLE OFTEN FALLS OUT OF ALIGNMENT AND DRIVING FEELS UNSTEADY AS ON OF THE FRONT WHEELS IS LOOSE. UPON INSPECTION IT APPEARS THIS IS BEING CAUSED BY PREMATURE WEAR TO THE UPPER BALL JOINTS. THIS HAS ALSO CAUSED EXCESS WEAR ON THE VEHICLE SUSPENSION. AS OF YET NO ACCIDENT OR INJURY HAS TAKEN PLACE DUE TO THIS PROBLEM; HOWEVER, IT IS A VERY SERIOUS SAFETY CONCERN AND NEEDS TO BE ADDRESSES PROMPTLY. *TR
NHTSA ODI #10370306
27,500 miles · Jul 17, 2009
Suspension
1998 DODGE DURANGO. 27500 MILES. YES 27500 MILES. UPPER BALL JOINTS BOTH SIDES SHOT $321.00 TO REPAIR. RIGHT SIDE WAS EXTREMELY BAD. *TR
NHTSA ODI #10277115
112,000 miles · Jun 11, 2009
Suspension
I OWN A 1998 DODGE DURANGO AND BACK IN MARCH OF THIS YEAR I REPLACED THE UPPER/LOWER BALL JOINTS DUE TO FAILURE. THE VEHICLE HAD AN AWFUL SQUEAKY NOISE AND WHEN TAKEN TO THE MECHANIC I WAS TOLD THAT I WAS LUCKY TO STILL BE ALIVE AS THE BALLJOINTS WERE EXTREMELY WORN OUT DUE TO BE AN UNGREASEABLE TYPE. THE REPAIR COST ME $650.…
Read full complaint
I OWN A 1998 DODGE DURANGO AND BACK IN MARCH OF THIS YEAR I REPLACED THE UPPER/LOWER BALL JOINTS DUE TO FAILURE. THE VEHICLE HAD AN AWFUL SQUEAKY NOISE AND WHEN TAKEN TO THE MECHANIC I WAS TOLD THAT I WAS LUCKY TO STILL BE ALIVE AS THE BALLJOINTS WERE EXTREMELY WORN OUT DUE TO BE AN UNGREASEABLE TYPE. THE REPAIR COST ME $650. IT HAS ONLY BEEN 3MONTHS SINCE THE REPAIR IN WHICH THE BALLJOINTS WERE REPLACED WITH DEALER PARTS AND ONCE AGAIN, THE SQUEAKY SOUND IS BACK, I'VE GONE BACK TO THE MECHANIC ONLY TO BE TOLD THAT ONCE AGAIN, THE BALLJOINTS HAVE FAILED!! ANOTHER $650 TO FIX, THIS IS OUTRAGEOUS!! DODGE MUST BECOME RESPONSIBLE FOR THE FACT THAT THESE BALLJOINTS CONTINUOUSLY FAIL AND THEY MUST COME UP WITH A GREASEABLE TYPE. IN THIS ECONOMY IT IS VERY DIFFICULT TO SPEND $650 EVERY 2-3 MONTHS ON BALLJOINTS!! AT THIS RATE, THERE WILL COME A POINT WHERE THE TIRES WILL FALL OFF THE VEHICLE AND CAUSE A DEATH BEING AS THESE JOINTS DON'T LAST AS LONG AS THEY SHOULD. *TR
NHTSA ODI #10273513
134,000 miles · Feb 26, 2009
Service Brakes, HydraulicSuspension
I BOUGHT THIS CAR USED IN THE LAST WEEK OF NOVEMBER '08. I HAD MY BRAKES DONE BY AN INDIVIDUAL MAYBE TWO WEEKS LATER. A COUPLE OF DAY LATER DRIVING HOME FROM WORK I STARTED HEARING A REAL LOUD IRON GRINDING NOISE. THE NEXT DAY I HAD THE CAR TOWED TO AAMCO, WHO TOLD ME MY CALIPER PINS HAD CAME OUT, AND I WOULD NEED A NEW STEERING…
Read full complaint
I BOUGHT THIS CAR USED IN THE LAST WEEK OF NOVEMBER '08. I HAD MY BRAKES DONE BY AN INDIVIDUAL MAYBE TWO WEEKS LATER. A COUPLE OF DAY LATER DRIVING HOME FROM WORK I STARTED HEARING A REAL LOUD IRON GRINDING NOISE. THE NEXT DAY I HAD THE CAR TOWED TO AAMCO, WHO TOLD ME MY CALIPER PINS HAD CAME OUT, AND I WOULD NEED A NEW STEERING KNUCKLE AND A SET OF CALIPER PINS.THE TRUCK WAS FIXED COSTING ME $525 (NOTING: MECHANIC USED A USED STEERING KNUCKLE.) NOW 2 MONTHS AFTER THOSE REPAIRS I NEED A WHEEL SPINDLE, AND CALIPER BOLTS BECAUSE THE THREADING HAVE STRIPPED AWAY AND SOMETHING TOTALLY UNRELATED A NEUTRAL SAFETY SWITCH. COSTING ME $580. I WAS TOLD THAT BY FIRESTONE WHO TOLD ME I NEEDED NEW TIE RODS AND THEN CORRECTED THEMSELVES BY TELLING ME I NEEDED A NEW STEERING KNUCKLE - WHO WOULDN'T EVEN WORK ON MY CAR BECAUSE OF LIABILITY TOLD ME THAT IT WAS UNSAFE TO DRIVE BECAUSE THE RIGHT FRONT TIRE COULD LITERALLY FALL OFF DUE TO LACK OF SUPPORT AND CAUSE A MAJOR OR SERIOUS ACCIDENT, AND THAT I NEEDED TO TAKE IT BACK TO AAMCO. I DIDN'T WANT TO BECAUSE I FELT AAMCO SHOULD HAVE FIXED THIS THE FIRST TIME. BUT AFTER FIGHTING WITH THEM AND READING THE OTHER COMPLAINTS MAYBE THEY'RE NOT IN THE WRONG. *TR
NHTSA ODI #10260164
Mileage unknown · Feb 7, 2009
Electrical SystemEngine And Engine CoolingSuspension
HEARD METAL TO METAL RUBBING ON 2/2/09 NOW ON 2/6/09 HUB BEARING BROKE RIGHT SIDE.... WHEEL IS TILED IN TO WHEEL WELL. *TR
NHTSA ODI #10257778
123,000 miles · Dec 15, 2008
SteeringSuspensionWheels
WE BOUGHT A 98' DURANGO W/ 123K MILES & AFTER DRIVING IT LESS THAN 500 MILES I BEGAN TO NOTICE A LOUD-REPEATING NOISE "THUD...THUD.." COMING FROM THE FRONT PASSENGER WHEEL WALL. THEN I BEGAN TO NOTICE EXTREME STEERING PROBLEMS SO I STOPPED THE VEHICLE AND INSPECTED IT FURTHER. I JACKED UP THE VEHICLE AND OBSERVED A LOT OF "PLA…
Read full complaint
WE BOUGHT A 98' DURANGO W/ 123K MILES & AFTER DRIVING IT LESS THAN 500 MILES I BEGAN TO NOTICE A LOUD-REPEATING NOISE "THUD...THUD.." COMING FROM THE FRONT PASSENGER WHEEL WALL. THEN I BEGAN TO NOTICE EXTREME STEERING PROBLEMS SO I STOPPED THE VEHICLE AND INSPECTED IT FURTHER. I JACKED UP THE VEHICLE AND OBSERVED A LOT OF "PLAY" IN THE FRONT TIRE. I WAS ACTUALLY ABLE TO "WOBBLE' BACK AND FORTH AND THE LUG NUTS WERE STILL SECURED. I CONTACTED A VERY REPUTABLE MECHANIC (3RD GENERATION RACE CAR DRIVER TOO!) AND HE ADVISED THAT THERE HAVE BEEN MASSIVE PROBLEMS WITH THE BALL JOINTS FAILING ON THE DURANGO'S , BUT THEY ONLY WILL FIX BACK TO 2000' MODEL YEAR. WELL, ANY REASONABLE AUTO COMPANY THAT KNOWS IT HAS A FAULTY PART SHOULD TAKE RESPONSIBILITY FOR THE SAFETY OF ITS PEOPLE....IF NOT, THEN THEY ARE LIABLE FOR CONTINUING TO ALLOW A PRODUCT THAT ENDANGERS THE SAFETY OF THE DRIVER, ITS OCCUPANTS & OTHER MOTORIST'S/CITIZENS-WHO EXPECT THEIR SAFETY TO BE LOOKED UPON, NOT "INVESTIGATED INTERNALLY." I HAVE BEEN IN LAW ENFORCEMENT FOR +13 YEARS, AND AS A RESULT I HAVE WORKED MANY VEHICLE ACCIDENTS (SOME CAUSING DEATH) THAT JUST DIDN'T MAKE SENSE-UNTIL NOW! SOMETHING NEEDS TO BE DONE HERE...AND NOT JUST "ONLY 2000' YEAR MODELS AND UP" THING. DO THE RIGHT THING, BECAUSE ITS THE RIGHT THING TO DO! *TR
NHTSA ODI #10251860
89,789 miles · Sep 9, 2008
SuspensionCrashInjury
DODGE DURANGO 1998 BALL JOINT FAILURE AND FULL SEPARATION WITH NO WARNING, WHICH CAUSED EXTENSIVE DAMAGE IN AN ON-ROAD ACCIDENT TO SEVERAL VEHICLES. DODGE CORPORATION WILL NOT ACKNOWLEDGE THE HUNDREDS OF BALL JOINT FAILURES AND LOST LIVES DUE TO THIS POOR DESIGN AND DEFECTIVE BALL JOINTS. MY VEHICLE HAS 84,000 MILES ON IT AND BA…
Read full complaint
DODGE DURANGO 1998 BALL JOINT FAILURE AND FULL SEPARATION WITH NO WARNING, WHICH CAUSED EXTENSIVE DAMAGE IN AN ON-ROAD ACCIDENT TO SEVERAL VEHICLES. DODGE CORPORATION WILL NOT ACKNOWLEDGE THE HUNDREDS OF BALL JOINT FAILURES AND LOST LIVES DUE TO THIS POOR DESIGN AND DEFECTIVE BALL JOINTS. MY VEHICLE HAS 84,000 MILES ON IT AND BALL JOINTS HAVE BEEN REPLACED 3 TIMES! BALL JOINTS, ACCORDING TO TOP MECHANICS ARE SUPPOSED TO LAST ABOUT 100,000 MILES BEFORE REPLACEMENT AND RARELY SEPARATE. THESE COMPONENTS USED BY DODGE ARE DEADLY, DEFICIENT, AND OUGHT TO HAVE BEEN RECALLED YEARS AGO. HOW MANY MORE LIVES HAVE TO BE LOST BEFORE THE ISSUE IS PROPERLY DEALT WITH?? *TR
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE REAR BRAKE TUBE CAN CONTACT AN UNDERBODY CROSSMEMBER EVENTUALLY WEARING A HOLE IN THE TUBE.
Consequence & remedy
Consequence: IF THE TUBE WERE PERFORATED, THERE WOULD BE A REDUCTION IN BRAKING FROM THE REAR WHEELS, INCREASING STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL A RUBBER ISOLATOR ON ALL VEHICLES THAT DO NOT INDICATE TUBE CONTACT. VEHICLES THAT SHOW CONTACT AND HAVE LESS THAN 45,000 MILES AND NO SIGNS OF RED RUST WILL HAVE THE RUBBER ISOLATOR INSTALLED WITH SILICONE TO PROTECT THE TUBE WHERE THE COATING HAS WORN OFF. VEHICLES THAT EXHIBIT CONTACT, AND HAVE MORE THAN 45,000 MILES OR SHOW SIGNS OF RED RUST, WILL HAVE THE BRAKE TUBE REPLACED WITH THE PRODUCTION TUBE AND ISOLATOR.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FUEL TANK STRAP CAN SEPARATE DUE TO FATIGUE DURING OPERATION. IF THIS OCCURS, THE TANK WILL BE UNSUPPORTED, INCREASING THE RISK OF A FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE DOUBLE TOGGLE LOCK FUEL TANK STRAPS WITH SINGLE TOGGLE LOCK DESIGN. NOTE: AFFECTED VEHICLES BUILT THROUGH MAY 21, 1998, ALSO REQUIRE THE REAR BRAKE TUBE INSPECTION/REPAIR. AS A RESULT, THE FUEL TANK STRAP AND BRAKE TUBE REPAIR WILL BE PERFORMED ON THESE VHEICLES IN A SINGLE SERVICE PROCEDURE UNDER RECALL 99V-341/DAIMLERCHRYSLER #841. AFFECTED VEHICLES BUILT FROM MAY 22, 1998 THROUGH SEPTEMBER 25, 1999, ONLY REQUIRE THE FUEL TANK STRAP REPAIR, WHICH WILL BE PERFORMED UNDER RECALL 99V-342/DAIMLERCHRYSLER #842.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE FASTENER WHICH SECURES THE GENERATOR CABLE TO THE POWER DISTRIBUTION CENTER (PDC) HAS AN INSUFFICIENT CLAMP LOAD, RESULTING IN A LOOSE CONNECTION AND ELECTRICAL ARCING AT THE CONNECTION.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL RETIGHTEN THE GENERATOR CABLE AND BATTERY CABLE FASTENERS TO THE PROPER TORQUE SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
1998 Dodge Durango Problems, Complaints & Recalls | Skip That Year
Illustration