NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
965 reports56,000 miles · Jul 23, 2003
Power Train
UPPER AND LOWER BALLJOINTS AND FRONT TIE ROD ENDS HAD TO BE REPLACED AT MY EXPENSE DUE TO BEING TOTALLY WORN OUT AND FRONT TIRES WHERE WORN BALD ON THE INSIDE DUE TO THIS PROBLEM. GEAR SHIFT INDICATOR IS ALSO NOT ALIGNED PROPERLY SINCE PURCHASE, SITS IN BETWEEN NEUTRAL AND DRIVE WHILE IN DRIVE POSITION, TRANSMISSION WILL HANG I…
Read full complaint
UPPER AND LOWER BALLJOINTS AND FRONT TIE ROD ENDS HAD TO BE REPLACED AT MY EXPENSE DUE TO BEING TOTALLY WORN OUT AND FRONT TIRES WHERE WORN BALD ON THE INSIDE DUE TO THIS PROBLEM. GEAR SHIFT INDICATOR IS ALSO NOT ALIGNED PROPERLY SINCE PURCHASE, SITS IN BETWEEN NEUTRAL AND DRIVE WHILE IN DRIVE POSITION, TRANSMISSION WILL HANG IN FIRST GEAR OR SLIP WHEN ACCELARATING CAUSING HIGH RPMS, HAVE MAINLY EXPERIENCED THIS PROBLEM WHEN VEHICLE IS LOW ON GAS, AS STRANGE AS THAT MAY BE. HAVE ALSO EXPERIENCED PROBLEMS WITH THE VEHICLE LEAKING A CLEAR LIQUID ON THE PASSENGER SIDE FLOORBOARD WHICH APPEARS TO BE COMING FROM THE AIR CONDITIONER CONDENSATION.
NHTSA ODI #10028928
121,000 miles · Jul 22, 2003
SuspensionFire
FRONT WHEEL BEARING FAILURE ON A 1998 DODGE DURANGO. THE FAILURE CAUSED THE FRONT WHEEL TO COLLAPSE INTO THE SPINDLE WHICH CAUSED EXCESSIVE HEAT AND SPARKS TO RUPTURE FRONT BRAKE LINE AND CAUSE A FIRE.
NHTSA ODI #10028915
90,000 miles · Jul 22, 2003
Suspension
I OWN A 1998 DODGE DURANGO WITH APPROX. 91,000 MILES. LAST YEAR I HAD TO REPLACE THE FRONT LOWER BALL JOINT ON THE DRIVER'S SIDE. I BEGAN TO NOTICE THAT THE VEHICLE WOULD SHAKE UNCONTROLLABLY WHEN IT REACHED HIGHWAY SPEEDS (55 MPH). THIS MONTH I PURCHASED AND INSTALLED 4 NEW TIRES, BUT THE SERVICE STATION COULD NOT DO AN ALIG…
Read full complaint
I OWN A 1998 DODGE DURANGO WITH APPROX. 91,000 MILES. LAST YEAR I HAD TO REPLACE THE FRONT LOWER BALL JOINT ON THE DRIVER'S SIDE. I BEGAN TO NOTICE THAT THE VEHICLE WOULD SHAKE UNCONTROLLABLY WHEN IT REACHED HIGHWAY SPEEDS (55 MPH). THIS MONTH I PURCHASED AND INSTALLED 4 NEW TIRES, BUT THE SERVICE STATION COULD NOT DO AN ALIGNMENT ON MY VEHICLE BECAUSE THE FRONT UPPER BALL JOINT ON THE DRIVER'S SIDE HAD GONE BAD.*AK
NHTSA ODI #10028911
47,574 miles · Jul 22, 2003
Suspension
UPPER AND LOWER BALL JOINTS WORN OUT. BOTH FRONT LOWER BALL JOINTS REPLACED AT 52264 K MILES, 5/17/01 AND AGAIN AT 89387 K MILES ON 02/07/03. ALSO REPLACED THE UPPER BALL JOINTS AT 89387 K MILES ON 02/07/03.*AK
NHTSA ODI #10028882
60,000 miles · Jul 22, 2003
Suspension
I WANTED TO REPORT THAT I TOO HAD TO REPLACE THE UPPER BALL JOINTS FOR MY 1998 DURANGO. THE DODGE DEALERSHIP IDENTIFIED THIS PROBLEM AFTER I BROUGHT MY VEHICLE IN FOR 60,000 MILE SERVICE. I NOTICED A SOFT SUSPENSION AND UNUSUAL TIRE WEAR RESULTING FROM PREMATURE WEAR OF THE BALL JOINTS.*AK
NHTSA ODI #10028878
Mileage unknown · Jul 22, 2003
Suspension
MY 1998 DODGE DURANGO HAS BEEN DIAGNOSED WITH MAJOR FRONT END PROBLEMS. IT NEEDS UPPER & LOWER BALL JOINT REPLACEMENT AS WELL AS TIE ROD ENDS.
NHTSA ODI #10028875
107,700 miles · Jul 22, 2003
Engine And Engine Cooling
RETURNING HOME FROM A BUSINESS TRIP, THE DURANGO STARTED MAKING A LOUD NOISE, THEN QUIT WITHIN SECONDS OF THE ORIGINAL NOISE, WITH A LOUD CLUNK. THE "CHECK ENGINE GUAGES" LIGHT DID NOT COME ON PRIOR TO THE LOUD NOISE. I LIVE IN THE MOUNTAINS, AND FORTUNATELY THE ENGINE QUIT NEXT TO A VEHICLE TURNOUT. IF THE ENGINE FAILURE HAD…
Read full complaint
RETURNING HOME FROM A BUSINESS TRIP, THE DURANGO STARTED MAKING A LOUD NOISE, THEN QUIT WITHIN SECONDS OF THE ORIGINAL NOISE, WITH A LOUD CLUNK. THE "CHECK ENGINE GUAGES" LIGHT DID NOT COME ON PRIOR TO THE LOUD NOISE. I LIVE IN THE MOUNTAINS, AND FORTUNATELY THE ENGINE QUIT NEXT TO A VEHICLE TURNOUT. IF THE ENGINE FAILURE HAD OCCURED A FEW SECONDS EARLIER, OR A FEW SECONDS LATER, MY LIFE WOULD HAVE BEEN IN SERIOUS DANGER, AND I WOULD HAVE ENDANGERED THE LIVES OF THE PEOPLE AT RISK OF HITTING MY STALLED VEHICLE. MY MECHANIC FOUND A USED ENGINE AND INSTALLED IT. NEW INSTALLED ENGINE RAN QUITE WELL FOR ABOUT 300 MILES. THIS TIME, THE FAILURE WAS FORWARNED BY A "CHECK ENGINE GUAGES" LIGHT AND BELL. CHECKING THE GUAGES, I FOUND NOTHING OUT OF THE ORDINARY - OIL PRESSURE AND TEMP WERE OK. THIS HAPPENED WITH THE SECOND BELL AS WELL. THE THIRD BELL, AND I TURNED THE ENGINE OFF DUE TO THE OIL PRESSURE GUAGE FALLING TO ZERO. TOWING THE DURANGO TO A LOCAL MECHANIC, HE ADVISED THAT WE SHOULD CHANGE THE OIL PUMP, BUT ADVISED ME THAT METAL SHAVINGS WERE FOUND IN THE OIL PUMP SCREEN, AND THAT FURTHER DAMAGE WAS PROBBABLE. MY MECHANIC TOLD ME THAT I SHOULD HAVE THE PUMP CHANGED, AND DRIVE IT TO HIS SHOP FOR INSPECTION - A DISTANCE OF APPROXIMATELY 35 MILES. THE DURANGO MADE IT 15 MILES BEFORE QUITTING. THE CATASTROPHIC FAILURE OF THIS ENGINE CREATES A DEFINITE SAFETY HAZARD. THE MANUFACTURER SHOULD BE ALLOWED TO DO A RECALL ON THIS ENGINE. IF THE MANUFACTURER DOES NOT THINK A RECALL NECESSARY, THE NHTSA SHOULD FORCE A RECALL. THIS ENGINE WILL CREATE SERIOUS HARM TO SOMEONE. IT IS JUST A MATTER OF TIME....
NHTSA ODI #10028866
35,000 miles · Jul 22, 2003
Suspension
I OWN A 1998 DODGE DURANGO, I AM ON MY SECOND SET OF UPPER AND LOWER BALL JOINTS AND NOW HAVE TO REPLACE THE FRONT WHEEL BEARING HUBS ALSO. MY DEALER SAYS THIS IS NORMAL, I HAVE NEVER HAD TO REPLACE THESE ITEMS ON ANY OTHER CAR THAT I'VE OWNED!*AK
NHTSA ODI #10028843
80,000 miles · Jul 22, 2003
Suspension
I HAVE BEEN READING THE COMPLAINTS ON THE FRONT SUSPENSION OF THE DODGE DURANGO AFTER HEARING THAT THE VEHICLE WAS BEING INVESTIGATED FOR PROBLEMS WITH THE FRONT SUSPENSION AND HAVE SPENT A LOT OF MONEY FIXING THE SAME PROBLEMS THAT ARE BEING DESCRIBED. MY ABS LIGHT CAME ON INTERMITTENTLY, WOULD STAY ON FOR AWHILE, THEN GO OUT.…
Read full complaint
I HAVE BEEN READING THE COMPLAINTS ON THE FRONT SUSPENSION OF THE DODGE DURANGO AFTER HEARING THAT THE VEHICLE WAS BEING INVESTIGATED FOR PROBLEMS WITH THE FRONT SUSPENSION AND HAVE SPENT A LOT OF MONEY FIXING THE SAME PROBLEMS THAT ARE BEING DESCRIBED. MY ABS LIGHT CAME ON INTERMITTENTLY, WOULD STAY ON FOR AWHILE, THEN GO OUT. WHEN THE CAR WAS PUT ON THE COMPUTER, THEY COULDN'T FIND ANYTHING. THEN MY SPEEDOMETER STARTED JUMPING FROM 0 TO 60 MPH INTERMITTENTLY. THROUGH TRIAL AND ERROR, A SENSOR WAS REPLACED AND SEEMS TO HAVE FIXED THE PROBLEM. I HAVE ALSO SPENT ALMOST $1000 REPLACING BRAKES, ETC. BECAUSE MY BRAKES WENT TO THE FLOOR WHILE DRIVING, LUCKILY ONLY IN A PARKING LOT, AND THE CALIPERS, BRAKES, ROTORS, ETC. HAD TO BE REPLACED. I JUST REPLACED MY TIRES BECAUSE OF SEVERE CUPPING. THESE TIRES WERE NOT THAT OLD AND THIS CONDITION WOULD CAUSE MY VEHICLE TO HYDROPLANE IN WET WEATHER AND SHUDDER GOING 50 MPH AND OVER. I ALSO EXPERIENCE THAT SAME SHUDDER WHEN THE BACK WINDOWS ARE OPEN AND THE FRONT WINDOWS CLOSED. THE WHOLE VEHICLE VIBRATES TERRIBLY, UNLESS YOU CRACK THE FRONT WINDOWS ALSO.
NHTSA ODI #10028821
Mileage unknown · Jul 22, 2003
Power TrainSuspension
SUSPENSION, DRIVE TRAIN, AND FRONT BALL JOINTS BAD - 1989, DODGE, DURANGO. *AK
NHTSA ODI #10028814
Official recalls
4May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 2, 1999
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE REAR BRAKE TUBE CAN CONTACT AN UNDERBODY CROSSMEMBER EVENTUALLY WEARING A HOLE IN THE TUBE.
Consequence & remedy
Consequence: IF THE TUBE WERE PERFORATED, THERE WOULD BE A REDUCTION IN BRAKING FROM THE REAR WHEELS, INCREASING STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL A RUBBER ISOLATOR ON ALL VEHICLES THAT DO NOT INDICATE TUBE CONTACT. VEHICLES THAT SHOW CONTACT AND HAVE LESS THAN 45,000 MILES AND NO SIGNS OF RED RUST WILL HAVE THE RUBBER ISOLATOR INSTALLED WITH SILICONE TO PROTECT THE TUBE WHERE THE COATING HAS WORN OFF. VEHICLES THAT EXHIBIT CONTACT, AND HAVE MORE THAN 45,000 MILES OR SHOW SIGNS OF RED RUST, WILL HAVE THE BRAKE TUBE REPLACED WITH THE PRODUCTION TUBE AND ISOLATOR.
Dec 2, 1999
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FUEL TANK STRAP CAN SEPARATE DUE TO FATIGUE DURING OPERATION. IF THIS OCCURS, THE TANK WILL BE UNSUPPORTED, INCREASING THE RISK OF A FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE DOUBLE TOGGLE LOCK FUEL TANK STRAPS WITH SINGLE TOGGLE LOCK DESIGN. NOTE: AFFECTED VEHICLES BUILT THROUGH MAY 21, 1998, ALSO REQUIRE THE REAR BRAKE TUBE INSPECTION/REPAIR. AS A RESULT, THE FUEL TANK STRAP AND BRAKE TUBE REPAIR WILL BE PERFORMED ON THESE VHEICLES IN A SINGLE SERVICE PROCEDURE UNDER RECALL 99V-341/DAIMLERCHRYSLER #841. AFFECTED VEHICLES BUILT FROM MAY 22, 1998 THROUGH SEPTEMBER 25, 1999, ONLY REQUIRE THE FUEL TANK STRAP REPAIR, WHICH WILL BE PERFORMED UNDER RECALL 99V-342/DAIMLERCHRYSLER #842.
Jan 30, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE FASTENER WHICH SECURES THE GENERATOR CABLE TO THE POWER DISTRIBUTION CENTER (PDC) HAS AN INSUFFICIENT CLAMP LOAD, RESULTING IN A LOOSE CONNECTION AND ELECTRICAL ARCING AT THE CONNECTION.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL RETIGHTEN THE GENERATOR CABLE AND BATTERY CABLE FASTENERS TO THE PROPER TORQUE SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03023 · Upper Ball Joint Separation
Opened Nov 19, 2003 · Closed Feb 11, 2005
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03032 · Front Susp. Upper Ball Joint Failure
Opened Jul 16, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration