Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
180–25K
8025–50K
15850–75K
9475–100K
75100–150K
16150K+
441 reports with mileage · 524 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 540 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 90 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports12 fire reports21 injury reports
What owners actually said
965 reports
198,000 miles · Apr 26, 2014
Seats
DATE COMPLAINT FILED: 04/26/2014 COMPONENT(S): SEATS DATE OF INCIDENT: 04/02/2010 NHTSA ID NUMBER: 10565005 VEHICLE IDENTIFICATION NO. (VIN): SUMMARY: THE DRIVERS SIDE POWER SEAT MOVES BACKWARDS ABOUT 2 INCHES WHEN I ACCELERATE AND COMES FORWARD THE SAME AMOUNT WHEN I BRAKE. I PURCHASED THE VEHICLE USED AND THE…
Read full complaint
DATE COMPLAINT FILED: 04/26/2014 COMPONENT(S): SEATS DATE OF INCIDENT: 04/02/2010 NHTSA ID NUMBER: 10565005 VEHICLE IDENTIFICATION NO. (VIN): SUMMARY: THE DRIVERS SIDE POWER SEAT MOVES BACKWARDS ABOUT 2 INCHES WHEN I ACCELERATE AND COMES FORWARD THE SAME AMOUNT WHEN I BRAKE. I PURCHASED THE VEHICLE USED AND THE PREVIOUS OWNER SAID IT HAS ALWAYS BEEN THAT WAY. AFTER RESEARCHING ONLINE I HAVE FOUND HUNDREDS OF CASES OF THE SAME THING. A RECALL IS IN ORDER HERE AS NOT ONLY DOES THIS MALFUNCTION AFFECT THE SAFETY OF DRIVER AND PASSENGERS, IT WILL ONLY GET WORSE AS THE MOVEMENT WILL EVENTUALLY CAUSE THE ENTIRE THING TO FAIL. *TR
NHTSA ODI #10585029
127,000 miles · Feb 19, 2014
Seats
THE DRIVERS SIDE POWER SEAT MOVES BACKWARDS ABOUT 2 INCHES WHEN I ACCELERATE AND COMES FORWARD THE SAME AMOUNT WHEN I BRAKE. I PURCHASED THE VEHICLE USED AND THE PREVIOUS OWNER SAID IT HAS ALWAYS BEEN THAT WAY. AFTER RESEARCHING ONLINE I HAVE FOUND HUNDREDS OF CASES OF THE SAME THING. A RECALL IS IN ORDER HERE AS NOT ONLY DOE…
Read full complaint
THE DRIVERS SIDE POWER SEAT MOVES BACKWARDS ABOUT 2 INCHES WHEN I ACCELERATE AND COMES FORWARD THE SAME AMOUNT WHEN I BRAKE. I PURCHASED THE VEHICLE USED AND THE PREVIOUS OWNER SAID IT HAS ALWAYS BEEN THAT WAY. AFTER RESEARCHING ONLINE I HAVE FOUND HUNDREDS OF CASES OF THE SAME THING. A RECALL IS IN ORDER HERE AS NOT ONLY DOES THIS MALFUNCTION AFFECT THE SAFETY OF DRIVER AND PASSENGERS, IT WILL ONLY GET WORSE AS THE MOVEMENT WILL EVENTUALLY CAUSE THE ENTIRE THING TO FAIL. *TR
NHTSA ODI #10565005
68,000 miles · Jan 6, 2014
Suspension
TL* THE CONTACT OWNS A 1998 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, HE NOTICED AN ABNORMAL NOISE FROM THE FRONT END. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS, WHO STATED THAT THE FRONT UPPER AND LOWER BALL JOINTS WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE …
Read full complaint
TL* THE CONTACT OWNS A 1998 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, HE NOTICED AN ABNORMAL NOISE FROM THE FRONT END. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS, WHO STATED THAT THE FRONT UPPER AND LOWER BALL JOINTS WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000 UPDATED 02/11/2014 *BF
NHTSA ODI #10558610
Mileage unknown · Jan 2, 2014
Power Train
TL* THE CONTACT OWNS A 1998 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE FAILED TO ACCELERATE. THE CONTACT APPLIED THE ACCELERATOR PEDAL TO THE FLOORBOARD BUT THE VEHICLE WOULD NOT RESPOND BEYOND 30 MPH. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE …
Read full complaint
TL* THE CONTACT OWNS A 1998 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE FAILED TO ACCELERATE. THE CONTACT APPLIED THE ACCELERATOR PEDAL TO THE FLOORBOARD BUT THE VEHICLE WOULD NOT RESPOND BEYOND 30 MPH. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10558139
195,000 miles · Nov 9, 2013
Electrical SystemFire
WE ON THE ROAD DRIVING AROUND 7:30 AND I NOTICED MY TRUCK WAS LOSING POWER...I LOOKED IN MY SIDE MIRROR AND SAW SMOKE... I PULLED OVER AND MY TRUCK WAS ON FIRE... THE FIRE DEPT WAS CALLED THEY HAD TO REMOVE THE BOOT AROUND THE 4 WHEEL DRIVE LEVER TO PUT THE FIRE OUT... TRUCK DESTROYED.. *TR
NHTSA ODI #10551626
151,630 miles · May 10, 2013
Seats
DRIVERS SIDE ELECTRIC SEAT MOVES BACK WHEN ACCELERATING AND GOES FORWARD WHEN BRAKING FEELS LIKE YOUR GOING TO GO THROUGH THE WINDSHIELD. *TR
NHTSA ODI #10511457
95,600 miles · Feb 28, 2013
Electronic Stability Control (esc)Service Brakes
NYLE MAXWELL DODGE SUPERCENTER IN AUSTIN TEXAS WAS PAID TO FIX MY SENSOR LIGHT FOR THE ANTILOCK BRAKE SYSTEM WHICH COMES ON CONTINUOUSLY AND STAYS ON 100 PERCENT OF THE TIME. I WAS TOLD THAT THEY NEEDED TO REPLACE A SENSOR WHICH WOULD COST JUST OVER $1100, AND WAS REQUIRED TO SIGN OFF ON A FORM SO THEY COULD BEGIN THE WORK. AF…
Read full complaint
NYLE MAXWELL DODGE SUPERCENTER IN AUSTIN TEXAS WAS PAID TO FIX MY SENSOR LIGHT FOR THE ANTILOCK BRAKE SYSTEM WHICH COMES ON CONTINUOUSLY AND STAYS ON 100 PERCENT OF THE TIME. I WAS TOLD THAT THEY NEEDED TO REPLACE A SENSOR WHICH WOULD COST JUST OVER $1100, AND WAS REQUIRED TO SIGN OFF ON A FORM SO THEY COULD BEGIN THE WORK. AFTER THEY HAD MY DODGE DURANGO A COUPLE OF DAYS, FEBRUARY 27, 2013, I GOT A PHONE CALL FROM SERVICE TO SAY THEY COULD NOT COMPLETELY FIX THE PROBLEM AND THAT THE LIGHT STILL COMES ON "INTERMITTENTLY". THEIR EXPLANATION WAS CONFUSING. SO I BELIEVE THAT I UNDERSTAND FROM THIS, IF THE WARNING LIGHT IS ON THAT THE ABS BRAKE WILL NOT BE WORKING AT ALL. AFTER THIS, I WAS GIVEN AN OPTION OF PAYING ANOTHER $350 FOR A SEPARATE PART, PERHAPS "MODULE" AND THE SERVICE MAN FELT IT WOULD BE THE SOLUTION. I COLLECTED MY CAR WITHOUT NYLE MAXWELL DODGE SUPERCENTER HAVING FIXED THIS $1100 ISSUE. BUT I PAID THEIR BILL. (I NEED TO TAKE IT SOMEWHERE FOR A SECOND UNBIASED OPINION.) AS A CUSTOMER/CONSUMER OF THEIR SERVICE AGREEMENT, I SHOULD HAVE THE RIGHT TO EXPECT THEM TO FIX IT FROM HERE ON OUT TO COMPLETION AT THE EXPENSE OF NYLE MAXWELL DODGE SUPERCENTER; OR REFUND ME. *TR
NHTSA ODI #10500876
87,000 miles · Jun 9, 2012
Seats
DRIVING ALONG WHEN SEAT TRACK "BROKE" SEAT NOW TRAVELS BACK AND FORWARD WHILE DRIVING, BRAKING OR ACCELLERATING...CAUSING MY BODY TO BE PUSHED FORWARD OR BACKWARD. COULD CAUSE AN ACCIDENT WITHIN ITSELF. SOMETHING NEEDS TO BE DONE ABOUT THIS SITUATION. MY DURANGO ONLY HAS AROUND 87,000 ORIGINAL MILES AN EXTREMELY WELL TAKEN CA…
Read full complaint
DRIVING ALONG WHEN SEAT TRACK "BROKE" SEAT NOW TRAVELS BACK AND FORWARD WHILE DRIVING, BRAKING OR ACCELLERATING...CAUSING MY BODY TO BE PUSHED FORWARD OR BACKWARD. COULD CAUSE AN ACCIDENT WITHIN ITSELF. SOMETHING NEEDS TO BE DONE ABOUT THIS SITUATION. MY DURANGO ONLY HAS AROUND 87,000 ORIGINAL MILES AN EXTREMELY WELL TAKEN CARE OF TRUCK BUT WITH THIS PROBLEM, I FILL LIKE I AM DRIVING A BROKE DOWN PEICE OF SH.. AND I LOVE MY TRUCK. SEEMS LIKE I HAVE BEEN LUCKY FOR MINE TO HAVE LASTED AS LONG. *JS
NHTSA ODI #10461114
115,000 miles · May 25, 2012
Seats
WHILE ACCELERATING, HEARD A "SNAP" UNDER THE DRIVERS SEAT. THIS POWER SEAT NOW HAS A ROCKING MOTION WHEN ACCELERATING OR SLOWING DOWN. CHECKED THE INTERNET AND FOUND COUNTLESS NUMBER OF BLOGS AND COMMENTS ON THIS EXACT PROBLEM, WITH SOME SAYING THEIR SEAT IS ACTUALLY SLIDING BACK AND FORTH ON THE SEAT RAILS. THIS IS A KNOWN PROB…
Read full complaint
WHILE ACCELERATING, HEARD A "SNAP" UNDER THE DRIVERS SEAT. THIS POWER SEAT NOW HAS A ROCKING MOTION WHEN ACCELERATING OR SLOWING DOWN. CHECKED THE INTERNET AND FOUND COUNTLESS NUMBER OF BLOGS AND COMMENTS ON THIS EXACT PROBLEM, WITH SOME SAYING THEIR SEAT IS ACTUALLY SLIDING BACK AND FORTH ON THE SEAT RAILS. THIS IS A KNOWN PROBLEM AND I CANNOT BELIEVE THAT THIS IS NOT A SAFETY ISSUE, WARRANTING SOME RECALL OR REMEDY BY CHRYSLER. IF THIS SEAT CAN SLIDE FREE IN A HARD ACCELERATION OR EMERGENCY STOP, THIS COULD CREATE ACCIDENT OR SEVERE INJURY. THIS HAS NOT BEEN ADDRESSED BY THE MANUFACTURER ! *TR
NHTSA ODI #10459706
Mileage unknown · Apr 20, 2011
Tires
TL* THE CONTACT OWNS A 1998 DODGE DURANGO WITH COOPER DISCOVER STT TIRES, TIRE SIZE 31X10/50/R15, DOT NUMBER WAS 60DWE. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH WHEN SHE NOTICED THAT THE REAR OF THE VEHICLE FELT UNSTABLE. ONCE AT HER DESTINATION, SHE DISCOVERED THAT THE TIRE WAS TORN APART. THE TIRE WAS NOT REPLACED. NEITHER…
Read full complaint
TL* THE CONTACT OWNS A 1998 DODGE DURANGO WITH COOPER DISCOVER STT TIRES, TIRE SIZE 31X10/50/R15, DOT NUMBER WAS 60DWE. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH WHEN SHE NOTICED THAT THE REAR OF THE VEHICLE FELT UNSTABLE. ONCE AT HER DESTINATION, SHE DISCOVERED THAT THE TIRE WAS TORN APART. THE TIRE WAS NOT REPLACED. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE REAR BRAKE TUBE CAN CONTACT AN UNDERBODY CROSSMEMBER EVENTUALLY WEARING A HOLE IN THE TUBE.
Consequence & remedy
Consequence: IF THE TUBE WERE PERFORATED, THERE WOULD BE A REDUCTION IN BRAKING FROM THE REAR WHEELS, INCREASING STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL A RUBBER ISOLATOR ON ALL VEHICLES THAT DO NOT INDICATE TUBE CONTACT. VEHICLES THAT SHOW CONTACT AND HAVE LESS THAN 45,000 MILES AND NO SIGNS OF RED RUST WILL HAVE THE RUBBER ISOLATOR INSTALLED WITH SILICONE TO PROTECT THE TUBE WHERE THE COATING HAS WORN OFF. VEHICLES THAT EXHIBIT CONTACT, AND HAVE MORE THAN 45,000 MILES OR SHOW SIGNS OF RED RUST, WILL HAVE THE BRAKE TUBE REPLACED WITH THE PRODUCTION TUBE AND ISOLATOR.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FUEL TANK STRAP CAN SEPARATE DUE TO FATIGUE DURING OPERATION. IF THIS OCCURS, THE TANK WILL BE UNSUPPORTED, INCREASING THE RISK OF A FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE DOUBLE TOGGLE LOCK FUEL TANK STRAPS WITH SINGLE TOGGLE LOCK DESIGN. NOTE: AFFECTED VEHICLES BUILT THROUGH MAY 21, 1998, ALSO REQUIRE THE REAR BRAKE TUBE INSPECTION/REPAIR. AS A RESULT, THE FUEL TANK STRAP AND BRAKE TUBE REPAIR WILL BE PERFORMED ON THESE VHEICLES IN A SINGLE SERVICE PROCEDURE UNDER RECALL 99V-341/DAIMLERCHRYSLER #841. AFFECTED VEHICLES BUILT FROM MAY 22, 1998 THROUGH SEPTEMBER 25, 1999, ONLY REQUIRE THE FUEL TANK STRAP REPAIR, WHICH WILL BE PERFORMED UNDER RECALL 99V-342/DAIMLERCHRYSLER #842.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE FASTENER WHICH SECURES THE GENERATOR CABLE TO THE POWER DISTRIBUTION CENTER (PDC) HAS AN INSUFFICIENT CLAMP LOAD, RESULTING IN A LOOSE CONNECTION AND ELECTRICAL ARCING AT THE CONNECTION.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL RETIGHTEN THE GENERATOR CABLE AND BATTERY CABLE FASTENERS TO THE PROPER TORQUE SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (5)
Suspension
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Arm
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front:control Arm:upper Ball Joint
DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Additional source detail variants (4)
Suspension:front
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Arm
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
Suspension:front:control Arm:upper Ball Joint
IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
1998 Dodge Durango Problems, Complaints & Recalls | Skip That Year
Illustration