Engine And Engine Cooling. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

45 crash reports23 fire reports26 injury reports

What owners actually said

629 reports

56,100 miles · Jan 13, 2003

Power Train

Read full complaint

AUTOMATIC TRANSMISSION FAILURE. EXTENT OF REBUILD/REPAIRS BEING ASSESSED BY BENCHMARK TRANSMISSION, WILMINGTON DE. PROBABLE FAILURE OF SHIFT GOVERNOR DUE TO INTERNAL FAILURE OF PART/PARTS WAS PRELIMINARY DIAGNOSIS OF BRANDYWINE CHRYSLER, WILMINGTON DE AND BENCHMARK TRANSMISSION, WILMINGTON DE. PRELIMINARY ESTIMATE OF REBUILD IS $1400, BUT DEPENDENT ON EXTENT OF INTERNAL DAMAGE. BENCHMARK REPORTED NO ELECTRONIC FAILURE OR CAUSE. MILEAGE IS 56,111. VEHICLE PURCHASED NEW IN JULY 1998 AND STILL OWNED BY ORIGINAL OWNER.

NHTSA ODI #10002626

Mileage unknown · Jan 8, 2003

Seat Belts

CONSUMER STATED THAT WHEN EXITING THE VEHICLE IT WOULD BE HARD FOR THE CONSUMER TO UNLOCK THE DRIVER'S SIDE SEAT BELT AND CONSUMER WILL BE FORCED TO SLIDE OUT. DEALER NOTIFIED. TS *TT

NHTSA ODI #10002332

Mileage unknown · Jan 7, 2003

Fuel System, Gasoline

CONSUMER STATES THAT FUEL IS LEAKING FROM VENT TUBE THAT IS CONNECTED TO THE FUEL TANK. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. TS

NHTSA ODI #10002258

Mileage unknown · Jan 7, 2003

Seat Belts

FRONT SEAT BELTS ARE DIFFERENT FROM DRIVER'S SEAT TO PASSENGER'S SEAT. BOTH HAVE TROUBLE GETTING THEM RELEASED, WHEN EXITING VEHICLE SEAT BELT WOULD NOT UNLOCK AND CONSUMER WAS FORCED TO SLIDE OUT. DEALER NOTIFIED. TS...*AK

NHTSA ODI #10002179

Mileage unknown · Dec 31, 2002

Seat Belts

WHILE DRIVING VEHICLE SEAT BELTS BECAME UNBUCKLED WITHOUT NOTICE. PLEASE PROVIDE ADDITIONAL INFORMATION. TS

NHTSA ODI #10001761

Mileage unknown · Dec 20, 2002

Power Train

WHILE APPLYING THE GEAR THE TRANSMISSION WILL SLIP AND WILL NOT MOVE. PLEASE PROVIDE ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM. TS

NHTSA ODI #10001348

Mileage unknown · Dec 20, 2002

Engine And Engine Cooling

CONSUMER STATES THAT WHILE DRIVING AND WITHOUT WARNING THE HEAD GASKET BLEW CAUSING COOLANT FLUID TO LEAK. DEALER NOTIFIED. TS

NHTSA ODI #10001297

45,000 miles · Dec 17, 2002

Engine And Engine Cooling

THE SERPENTINE BELT SLIPS OFF WHEN YOU DRIVE THROUGH WATER. LOSING THE BELT CAUSES DANGEROUS STEERING CHANGES AND STOPS THE WATER PUMP AND ALTERNATOR. THE MOST RECENT TIME THIS HAPPENED I ALMOST LOST CONTROL OF THE CAR AND HAD A NEAR MISS HEAD ON CRASH PROBLEM HAS HAPPENED 5 TIMES ON MY CAR AND TWO FRIENDS WHO HAVE THE SAME MODE…

Read full complaint

NHTSA ODI #10006535

Mileage unknown · Dec 10, 2002

Power Train

THE TRANSMISSION CAN BE SHIFTED FROM PARK TO DRIVE WITHOUT HAVING FOOT ON BRAKE. ALSO, WHEN SHIFTING INTO DRIVE, INDICATOR NOT REALLY LOCKED IN DRIVE POSITION EVEN IF SHOWN IN DRIVE. THE MECHANIC HAS TO REPLACED THE TRANSMISSION (TWICE) BECAUSE OF DAMAGE DONE WHILE TRYING TO SHIFT PROPERLY. TS

NHTSA ODI #8024075

Mileage unknown · Dec 6, 2002

Visibility

BROUGHT VEHICLE NEW IN AUG 98 AND THE HEATER CORE WOULD CONTINUOUSLY TO BLOW OUT. WOULD BE REPLACED HEATER CORE PART EVERY YEAR. MECHANIC CAN NOT LOCATE CAUSE OF THE DEFECTIVE HEATER CORE PROBLEM. TS

NHTSA ODI #8023863

Official recalls

04V480000 · Air Bags

Oct 6, 2004

ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.

Consequence & remedy

Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.

Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

02V293000 · Air Bags:frontal

Nov 7, 2002

ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.

Consequence & remedy

Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

02V076000 · Seat Belts:rear/other

Mar 8, 2002

ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

00V268000 · Fuel System, Gasoline:fuel Injection System

Sep 13, 2000

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

97V231000 · Child Seat

Dec 15, 1997

VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.

Consequence & remedy

Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.

Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA04013 · Driver Air Bag Clockspring Failure

Opened Jun 4, 2004 · Closed May 25, 2005

Status: closed (inferred from source dates) · Air Bags:frontal

THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.

RQ04001 · Driver Air Bag Clockspring Failure

Opened Jan 28, 2004 · Closed Jun 4, 2004

Status: closed (inferred from source dates) · Air Bags:frontal

COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).

PE02004 · Rear Seat Belt Malfunction

Opened Jan 16, 2002 · Closed Mar 11, 2002

Status: closed (inferred from source dates) · Seat Belts:rear/other

THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.

EA01007 · Air Bag Clockspring

Opened Feb 21, 2001 · Closed Nov 22, 2002

Status: closed (inferred from source dates) · Electrical System

There is no summary currently available

RQ00008 · Dc Minivan Fuel Injector Rail Leak

Opened Mar 9, 2000 · Closed Mar 18, 2002

Status: closed (inferred from source dates) · Vehicle Speed Control:linkages

There is no summary currently available

EA99013 · Post Collision Fuel System

Opened Jun 11, 1999 · Closed Aug 10, 2001

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

No summary supplied.

PE99010 · POST-COLLISION Fuel System Integrity

Opened Feb 3, 1999 · Closed Jun 11, 1999

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

There is no summary currently available