NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
41 reportsClear category filter69,000 miles · Jan 15, 2004
Power TrainService Brakes, Hydraulic
TRANSMISSION ------------ SUDDEN FAILURE OF ALL FORWARD AND REVERSE GEARS. KEY OFF-ON BRINGS BACK FORWARD DRIVE FOR ABOUT 100 YARDS THEN FAILS AGAIN. NO REVERSE GEAR AT ALL. COMPUTER DIAGNOSTIC INDICATES 3 TRANSMISSION ERRORS RELATED TO SHIFTING. SENSORS LOOK OK. SHOP HAD TO REBUILD TRANSMISSION AT A COST OF OVER $2,000. BRAKES…
Read full complaint
TRANSMISSION ------------ SUDDEN FAILURE OF ALL FORWARD AND REVERSE GEARS. KEY OFF-ON BRINGS BACK FORWARD DRIVE FOR ABOUT 100 YARDS THEN FAILS AGAIN. NO REVERSE GEAR AT ALL. COMPUTER DIAGNOSTIC INDICATES 3 TRANSMISSION ERRORS RELATED TO SHIFTING. SENSORS LOOK OK. SHOP HAD TO REBUILD TRANSMISSION AT A COST OF OVER $2,000. BRAKES ------ EXTREMELY EXCESSIVE WEAR OF FRONT BRAKE PADS. MUST BE REPLACED AT LEAST ONCE A YEAR NOW. FIRST TIME IT OCCURRED IT DESTROYED ONE BRAKE ROTOR -- HAD TO REPLACE THAT. NOW, AT THE FIRST SIGN OF BRAKE SQUEAL I MUST CHECK AND REPLACE THE PADS AS THEY ARE CLOSE TO WEARING OUT. GENERALLY GET LESS THAN 15,000 MILES PER SET.
NHTSA ODI #10070783
42,733 miles · Jun 26, 2003
Service Brakes, Hydraulic
WHEN THE CONSUMER APPLIED THE BRAKES, THE FAILED. THE DRIVER USED THE EMERGENCY BRAKE HANDLE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO AN AUTO BODY SHOP. THE MECHANIC STATED THE BRAKE LINE RUSTED THROUGH. *NLM PH *JB
NHTSA ODI #10020280
74,795 miles · Mar 19, 2003
Service Brakes, Hydraulic
I HAVE TO CHANGE MY FRONT BRAKE PADS ABOUT EVERY OTHER MONTH DUE TO THE BRAKES GET TO HOT AND USUALLY THE FRONT DRIVER SIDE BRAKE PAD JUST FALLS OFF WITH NO WARNING AT ALL. I HAVE TAKEN THIS PROBLEM IN TO THE DEALER AND WAS TOLD THAT MY CALIPERS HAD TO BE REPLACED. I WAS VERY HAPPY THAT IT WAS STILL COVERED UNDER THE WARRANTY. T…
Read full complaint
I HAVE TO CHANGE MY FRONT BRAKE PADS ABOUT EVERY OTHER MONTH DUE TO THE BRAKES GET TO HOT AND USUALLY THE FRONT DRIVER SIDE BRAKE PAD JUST FALLS OFF WITH NO WARNING AT ALL. I HAVE TAKEN THIS PROBLEM IN TO THE DEALER AND WAS TOLD THAT MY CALIPERS HAD TO BE REPLACED. I WAS VERY HAPPY THAT IT WAS STILL COVERED UNDER THE WARRANTY. THE DEALER HAD MY VEHICLE FOR ABOUT A WEEK. WHEN I GOT MY VAN BACK IT WAS FINE FOR ABOUT 5 MONTHS, AND THEN THE PROBLEM STARTED HAPPENING AGAIN. NOW I AM STUCK WITH A VEHICLE THAT IS COSTING A FORTUNE TO KEEP UP THE BRAKE PAD MAINTENANCE. I CONSIDER THE BRAKES ON A VEHICLE A LIFELINE AND AM SURPRISED THAT THIS PROBLEM HAS NOT BEEN RECALLED. EVERY PERSON I KNOW THAT OWNS A DODGE CARAVAN HAS THE SAME COMPLAINT. I BOUGHT MY VAN 01/01/00. *NLM
NHTSA ODI #10010739
Mileage unknown · Nov 29, 2002
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
I ONLY HAVE 35,000 MILES ON THIS CAR AND OF COURSE THE WARRANTY IS EXPIRED. AND ALL OF A SUDDEN, THE CAR ACTS LIKE IT HAS 135,000 MILES ON IT. THIS HAS ALREADY COST ME OVER $200 TO REPAIR BRAKES BECAUSE OF ROTORS, NOT BAD BRAKES. NOW I NEED $1000 HEAD GASKET WORK. STARTER ONLY SEEMS TO START WHEN IT WANTS TO. VERY TEMPORAME…
Read full complaint
I ONLY HAVE 35,000 MILES ON THIS CAR AND OF COURSE THE WARRANTY IS EXPIRED. AND ALL OF A SUDDEN, THE CAR ACTS LIKE IT HAS 135,000 MILES ON IT. THIS HAS ALREADY COST ME OVER $200 TO REPAIR BRAKES BECAUSE OF ROTORS, NOT BAD BRAKES. NOW I NEED $1000 HEAD GASKET WORK. STARTER ONLY SEEMS TO START WHEN IT WANTS TO. VERY TEMPORAMENTAL. WHAT IS GOING ON HERE THAT A 35,000 MILE CAR WOULD HAVE SO MUCH WRONG SO SOON. DT
NHTSA ODI #770248
Mileage unknown · Aug 15, 2002
Service Brakes, HydraulicCrash
WHEN ON A EXIT RAMP GOING DOWNHILL, BRAKE PEDAL WENT CLEAR TO FLOOR, NO SLOWING. CAR TOTALED TRYING TO SLOW DOWN BY HITTING GUARD RAIL AND DUMP TRUCK. SAFETY CHECK BY AUTO SHOP SAID FAILED MASTER CYCLINDER. TWO OTHER DRIVERS DROVE CAR THAT DAY WITHOUT NOTICING ANY BRAKE PROBLEMS. NO FORWARNING SUCH AS SQUEAKY OR GRATING SOUND…
Read full complaint
WHEN ON A EXIT RAMP GOING DOWNHILL, BRAKE PEDAL WENT CLEAR TO FLOOR, NO SLOWING. CAR TOTALED TRYING TO SLOW DOWN BY HITTING GUARD RAIL AND DUMP TRUCK. SAFETY CHECK BY AUTO SHOP SAID FAILED MASTER CYCLINDER. TWO OTHER DRIVERS DROVE CAR THAT DAY WITHOUT NOTICING ANY BRAKE PROBLEMS. NO FORWARNING SUCH AS SQUEAKY OR GRATING SOUND ON BRAKING OR SQUISHY BRAKING BEFORE. SINCE THEN HAVE HEARD OF TWO OTHER CARAVAN OWNERS WITH FAILED MASTER CYCLINDER WITHOUT ANY FORWARNING. VERY DANGEROUS. *AK
NHTSA ODI #765726
Mileage unknown · Mar 8, 2002
Engine And Engine CoolingService Brakes, HydraulicSteering
VEHICLE WAS LEAKING OIL. TOOK VEHICLE TO MECHANIC, AND MECHANIC INDICATED EXTERNAL CYLINDER GASKET WAS GONE. DEALER CONTACTED. *AK CONSUMER STATED THAT THE VAN HAD NUMEROUS PROBLEMS, POWER STEERING LOSS, BACK WHEELS ON FIRE, COMPLETE BRAKE FAILURE AND ENGINE WOULD SEIZE AND STOP. *YH
NHTSA ODI #8005221
Mileage unknown · Feb 18, 2002
Power TrainService Brakes, HydraulicVisibility
AS A CONCERNED CITIZEN, WHO HANDLES THE FLEET FOR A STATE AGENCY, I UNHAPPY THAT NOTHING HAS BEEN PUBLISHED FROM THE MANUFACTURED AS RECALLS TO FIX THE PROBLEMS WHICH SEEMS TO HAPPEN AROUND 35,000 MILES OR IF THE VEHICLE HAPPENS TO BE PARKED FOR ANYTIME OVER TWO WEEKS. *AK
NHTSA ODI #758373
Mileage unknown · Nov 13, 2001
Service Brakes, HydraulicFire
WHILE DRIVING 55 MPH, SMELLED SMOKE. THEN, DASHBOARD WENT BLANK. CONSUMER SAW SMOKE COMING FROM EDGE OF HOOD, HE PULLED OVER AND SAW FLAMES FROM UNDERNEATH VEHICLE. VEHICLE AT DEALERSHIP AT THIS TIME. DEALER DETERMINED ABS SYSTEM CAUGHT ON FIRE. DAMAGE UNKNOWN. *AK *YH
NHTSA ODI #899033
Mileage unknown · Oct 9, 2001
Service Brakes, Hydraulic
WHEN BRAKES ARE APPLIED PEDAL GOES TO FLOOR, CAUSING EXTENDED STOPPING DISTANCE. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #897452
Mileage unknown · May 22, 2001
Engine And Engine CoolingService Brakes, HydraulicSteering
ENGINE WARNING LIGHT WAS ON, AND CONSUMER SAW SOMETHING HANGING FROM UNDER THE CAR, IT WAS SERPENTINE BELT. THEN, THERE WAS NO STEERING OR BRAKING.*AK
NHTSA ODI #888891
Official recalls
5Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Dec 15, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.
Consequence & remedy
Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
PE02004 · Rear Seat Belt Malfunction
Opened Jan 16, 2002 · Closed Mar 11, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
Illustration