IllustrationSNOW BUILD-UP UNDER FRONT-END CAUSED STEERING LINES TO LEAK LEADING TO FIRE AND DAMAGE TO LOWER ENGINE COMPONENTS. ONLY 6INCHES OF SNOW ON GROUND.LINES POSITIONED TOO CLOSE TO GROUND. *AK
1997 Dodge Caravan
Owner reports · Recalls · Investigations
More warning signs than most Caravan years
Owner complaints for the 1997 Dodge Caravan are substantially higher than the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 113 of 714 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 152 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports36 fire reports39 injury reports
What owners actually said
714 reportsCONSUMER DRIVING AND THE TRANSMISSION STARTED MAKING NOISE AND IT SLIPPED OUT OF GEAR, AND WOULDN'T GO INTO 3RD GEAR. CONTACTED DEALER, AND WAS TOLD VEHICLE WAS NOT UNDER WARRANTY. CONSUMER WILL BE RESPONSIBLE FOR THE COST TO FIX IT. *AK
THE TRANSMISSION JUST FAILED AFTER 48,000 MILES. WE PURCHSED THE CAR USED IN AUGUST OF 1999, AND IT FAILED 6 MONTHS LATTER AFTER WE HAD DRIVEN ONLY 10,000 MILES. WE HAD IT TOWED TO THE DEALER, WHO INSPECTED IT AND SAID THAT ( I THINK)THE DRIVE PIN HAD BROKEN AND TORN OUT PART OF THE CASING OF THE TRANSMISSION. WE COULD NOT A…
Read full complaint
THE TRANSMISSION JUST FAILED AFTER 48,000 MILES. WE PURCHSED THE CAR USED IN AUGUST OF 1999, AND IT FAILED 6 MONTHS LATTER AFTER WE HAD DRIVEN ONLY 10,000 MILES. WE HAD IT TOWED TO THE DEALER, WHO INSPECTED IT AND SAID THAT ( I THINK)THE DRIVE PIN HAD BROKEN AND TORN OUT PART OF THE CASING OF THE TRANSMISSION. WE COULD NOT AFFORD THE EXTENED WARRANTY AT THE TIME OF PURCHASE. THE DEALER STATED THAT CHRYSLER WOULD REPLACE THE TRANSMISION IF WE WOULD PAY FOR THE LABOR. I EXPECTED A TRANSMISSION TO LAST FAR LONGER THAN 48,000 MILES. AM I WRONG IN MY ASSUMPTION?WE WILL HAVE TO USE MOST OF OUR MEAGER SAVINGS TO PAY FOR THE REPAIRS, BUT WE ARE GREATFUL TO STILL HAVE A VEHICLE TO GET AROUND IN. PLEASE LET ME KNOW WHAT YOU THINK. THANK YOU FOR YOU TIME AND EFFORT. *AK
RELAY IS RECALL ITEM ON 96 MODEL NOT 97 SAME PART WONDER WHY? *AK
STARTER CAUGHT ON FIRE, FIRE STARTED IN THE ALTERNATOR/IGNITION SYSTEM, CLAIM 18-0315-533. *SLC
DEALER SERVICE MANAGER STATED THAT THEY (DODGE) HAVE HAD MANY FAILURES OF THE HEAD GASKETS ON THE CARAVAN 4 CYLINDER. EVEN THOUGH THE CAR WAS OUT OF WARRANTY, DODGE AGREED TO FIX THE ENGINE HEAD GASKET. THIS IS THE SECOND HEAD GASKET FAILURE. THANK GOD THAT I NOTICED THE SMALL OIL LEAKS IN THE CARPORT. IF I HADDN'T THE ENGIN…
Read full complaint
DEALER SERVICE MANAGER STATED THAT THEY (DODGE) HAVE HAD MANY FAILURES OF THE HEAD GASKETS ON THE CARAVAN 4 CYLINDER. EVEN THOUGH THE CAR WAS OUT OF WARRANTY, DODGE AGREED TO FIX THE ENGINE HEAD GASKET. THIS IS THE SECOND HEAD GASKET FAILURE. THANK GOD THAT I NOTICED THE SMALL OIL LEAKS IN THE CARPORT. IF I HADDN'T THE ENGINE COULD HAVE LET GO ON THE HIGHWAY. SOMETHING IS VERY, VERY, WRONG WHEN YOU HAVE TO GET A HEAD GASKET REPLACED EVERY 10-30K MILES. *AK
FOR NO APPARENT REASON, WHILE THE VAN WAS PARKED IN THE DRIVEWAY WITH THE IGNITION OFF, IT CAUGHT ON FIRE IN THE ENGINE COMPARTMENT. VAN HAD BEEN PARKED FOR ABOUT 10 MINUTES BEFORE IT CAUGHT ON FIRE. THE FIRE WAS PUT OUT THE THE FIRE DEPARTMENT. VAN WAS TOTALLED. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
WHILE DRIVING AT 35 MPH CAR STARTED TO FEEL AS THOUGH IT WAS IN NEUTRAL. CAR WOULD CONTINUE TO DRIVE, BUT ONLY AT ABOUT 25MPH. THERE COULD HAVE BEEN AN ACCIDENT BECAUSE THERE WERE OTHER CARS PRESENT. *AK
THE WINDSHIELD WIPERS WOULD AUTOMATICALLY COME ON WHILE TRAVELING ON THE ROAD. THEY WOULD COME ON FOR TWO TO FOUR WIPES AND THEN STOP. THIS INTERMITTENT PROBLEM WAS RARE AT FIRST, THEN STARTED TO HAPPEN MORE FREQUENTLY. WE FINALLY TOOK IT IN TO THE DEALERSHIP FOR REPAIR. THEY REPLACED THE WINDSHIELD WIPER SWITCH AT NO COST TO US…
Read full complaint
THE WINDSHIELD WIPERS WOULD AUTOMATICALLY COME ON WHILE TRAVELING ON THE ROAD. THEY WOULD COME ON FOR TWO TO FOUR WIPES AND THEN STOP. THIS INTERMITTENT PROBLEM WAS RARE AT FIRST, THEN STARTED TO HAPPEN MORE FREQUENTLY. WE FINALLY TOOK IT IN TO THE DEALERSHIP FOR REPAIR. THEY REPLACED THE WINDSHIELD WIPER SWITCH AT NO COST TO US. (ONLY BECAUSE WE WERE UNDER THE 36MO./36,000MI. WARANTY.) THE NEXT PROBLEM WAS THE BATTERY WENT DEAD. WE TOOK IT IN FOR REPAIR, AND THE DEALERSHIP REPLACED THE BATTERY AT NO COST TO US. (ONLY BECAUSE IT WAS UNDER THE 36MO./36,000MI. WARANTY) . THE OTHER PROBLEM WAS THAT THE INSIDE REAR VIEW MIRROR BECAME UNGLUED FROM THE FRONT WINDSHIELD. I WENT TO A AUTO REPAIR STORE AND PURCHASED A REAR VIEW MIRROR GLUE KIT. I GLUED THE REAR VIEW MIRROR ON MYSELF. ( I DON'T HAVE CONFIDENCE IN THE DEALERSHIPS GLUE) THANK YOU ........ RICHARD MALDONADO. *AK
CONUSMER HAS AN INTEGRATED CHILD SEAT AND THE BELT TIGHTENED UP AROUND THE CHILD'S NECK WHEN TRYING TO GET HER OUT. CONSUMER WAS GOING TO CUT IT, BUT MANAGED TO SLIDE CHILD'S HEAD UNDERNEATH THE BELT. DEALER HAS NOT BEEN CONTACTED. *AK
Official recalls
702V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V076000 · Seat Belts:rear/other
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
98V185000 · Child Seat
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
97V200000 · Tires:bead
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
97V070000 · Wheels:rim
Apr 28, 1997
THE STEEL ROAD WHEELS WERE DAMAGED BY THE EQUIPMENT USED TO MATCH MOUNT THE WHEEL TO THE TIRE.
Consequence & remedy
Consequence: A SCORE MARK WAS MADE ON THE WHEEL, AFFECTING THE DURABILITY OF THE WHEEL.
Remedy: DEALERS WILL REPLACE ALL ROAD WHEELS (AND FULL SIZE SPARE TIRES) WITH NEW WHEELS.
96V215000 · Service Brakes, Hydraulic:foundation Components:master Cylinder
Oct 29, 1996
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7PE02004 · Rear Seat Belt Malfunction
Opened Jan 16, 2002 · Closed Mar 11, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.