IllustrationWINDSHIELD WIPERS SELF ACTIVATE WHILE DRIVING. DEALERSHIP HAS BEEN NOTIFIED ABOUT THE PROBLEM. PROBLEM WILL BE REPAIRED AT OWNER'S EXPENSE. *AK
1997 Dodge Caravan
Owner reports · Recalls · Investigations
More warning signs than most Caravan years
Owner complaints for the 1997 Dodge Caravan are substantially higher than the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 113 of 714 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 152 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports36 fire reports39 injury reports
Visibility complaints
55 reportsWINDSHIELD WIPERS OCCASSIONALLY COME ON BY THEMSELVES (EVEN WHEN THE WIPER SWITCH IS IN THE OFF POSITION) AND RUN UNTIL THE DRIVER JIGGLES THE SWITCH A LITTLE TO STOP THEM. *AK
THE POWER STEERING FAILED DURING EMERGENCY CAUSING THE VEHICLE TO CRASH. YH
THE WINDSHIELD WIPERS WOULD AUTOMATICALLY COME ON WHILE TRAVELING ON THE ROAD. THEY WOULD COME ON FOR TWO TO FOUR WIPES AND THEN STOP. THIS INTERMITTENT PROBLEM WAS RARE AT FIRST, THEN STARTED TO HAPPEN MORE FREQUENTLY. WE FINALLY TOOK IT IN TO THE DEALERSHIP FOR REPAIR. THEY REPLACED THE WINDSHIELD WIPER SWITCH AT NO COST TO US…
Read full complaint
THE WINDSHIELD WIPERS WOULD AUTOMATICALLY COME ON WHILE TRAVELING ON THE ROAD. THEY WOULD COME ON FOR TWO TO FOUR WIPES AND THEN STOP. THIS INTERMITTENT PROBLEM WAS RARE AT FIRST, THEN STARTED TO HAPPEN MORE FREQUENTLY. WE FINALLY TOOK IT IN TO THE DEALERSHIP FOR REPAIR. THEY REPLACED THE WINDSHIELD WIPER SWITCH AT NO COST TO US. (ONLY BECAUSE WE WERE UNDER THE 36MO./36,000MI. WARANTY.) THE NEXT PROBLEM WAS THE BATTERY WENT DEAD. WE TOOK IT IN FOR REPAIR, AND THE DEALERSHIP REPLACED THE BATTERY AT NO COST TO US. (ONLY BECAUSE IT WAS UNDER THE 36MO./36,000MI. WARANTY) . THE OTHER PROBLEM WAS THAT THE INSIDE REAR VIEW MIRROR BECAME UNGLUED FROM THE FRONT WINDSHIELD. I WENT TO A AUTO REPAIR STORE AND PURCHASED A REAR VIEW MIRROR GLUE KIT. I GLUED THE REAR VIEW MIRROR ON MYSELF. ( I DON'T HAVE CONFIDENCE IN THE DEALERSHIPS GLUE) THANK YOU ........ RICHARD MALDONADO. *AK
ROTORS PITTED AND RUSTED PREMATURELY DUE TO INFERIOR MATERIALS USED TO CONSTRUCT THEM. NLM
CAMSHAFT BROKE IN HALF AT 59,000 MILES, NECESSITATING ENGINE REPLACEMENT. SERVICE MGR. & TECHNICIAN BOTH INISTSTED THIS WAS VERY UNUSUAL IN ANY ENGINE, ESPECIALLY ONE WITH THIS LOW MILEAGE. DODGE REFUSED TO HELP WITH REPAIRS AS CAR WAS "OUT OF WARRANTY". THE WIPERS TURN ON BY THEMSELVES EVERY NOW AND THEN, SOMETIMES WHEN JUST…
Read full complaint
CAMSHAFT BROKE IN HALF AT 59,000 MILES, NECESSITATING ENGINE REPLACEMENT. SERVICE MGR. & TECHNICIAN BOTH INISTSTED THIS WAS VERY UNUSUAL IN ANY ENGINE, ESPECIALLY ONE WITH THIS LOW MILEAGE. DODGE REFUSED TO HELP WITH REPAIRS AS CAR WAS "OUT OF WARRANTY". THE WIPERS TURN ON BY THEMSELVES EVERY NOW AND THEN, SOMETIMES WHEN JUST OPENING THE DOORS. THE WHOLE BRAKE SYSTEM HAD TO BE REPLACED AT 43,000 MILES AS IT HAD NEVER BEEN PROPERLY LOOKED AT, EVEN THOUGH SERVICE RECORDS SHOWED INSPECTION AT THREE OCCASIONS BEFORE BREAKING DOWN. ORIGINAL DEALER WAS DUTCHESS DODGE, 614 SOUTH ROAD, POUGHKEEPSIE, NY 12601 (914) 462-7700. THEY NEVER RESPONDED TO CORRESPONDENCE REGARDING THE BRAKES & WIPERS. THE ENGINE WAS REPAIRED AT HYDE PARK MOTORS. I'VE CONTACTED DODGE (DAIMLER/CHRYSLER) AND THE DISTRICT MGR. (PHIL FORNABAIO) BUT THEY REFUSE TO HELP WITH THE ENGINE AND WOULDN'T EVEN MEET WITH ME.
WINDSHIELD WIPERS WORK INTERMITTENTLY CAUSING POOR VISIBILITY. *YC
WHENEVER MAKING LEFT TURN THE WINDSHIELD WIPERS WOULD GO OFF, NOW THEY GO OFF AT ANYTIME. *AK
I WAS PARKED AT BURGER KING, TURNED THE IGNITION AND PUT MY CARAVAN IN REVERSE TO GET OUT OF MY PARKING SPACE. TO MY SURPRISE, THE CAR GAVE A SEVER JOLT, AND WOULD NOT GO INTO REVERSE....I TRIED AGAIN AND THE SAME JOLT OCCURRED, THIS TIME SOUNDING LIKE STUFF INSIDE WAS BEING SMASHED UP (LIKE A TRASH COMPACTOR SOUNDS). I TRIED …
Read full complaint
I WAS PARKED AT BURGER KING, TURNED THE IGNITION AND PUT MY CARAVAN IN REVERSE TO GET OUT OF MY PARKING SPACE. TO MY SURPRISE, THE CAR GAVE A SEVER JOLT, AND WOULD NOT GO INTO REVERSE....I TRIED AGAIN AND THE SAME JOLT OCCURRED, THIS TIME SOUNDING LIKE STUFF INSIDE WAS BEING SMASHED UP (LIKE A TRASH COMPACTOR SOUNDS). I TRIED TO GET IT INTO DRIVE (EVEN THOUGH I WAS ALMOST AS FAR UP AS I COULD GO) AND IT WOULDN'T BUDGE EITHER...THE SOUNDS GETTING WORSE. AFRAID I WAS CRUSHING THINGS INSIDE, I TURNED THE CAR OFF. MY TWO CHILDREN AND I WALKED THE MILE OR SO HOME AND I CALLED A TOW TRUCK. THE MECHANIC SAID IT APPEARED TO BE A TRANSMISSION PROBLEM. ONCE HE LOOKED IT OVER AND TOOK THE TRANSMISSION OUT, IT WAS A SEVERE PROBLEM, "BIZZARRE" IS THE EXACT WORD OF THE MECHANC WHO ASKED ME IF I HAD ANY WARNING SIGNS. I HAD NONE. HE SAID HE COULDN'T BELIEVE THE EXTENT OF STUFF BROKEN APART INSIDE THE TRANSMISION LIKE BROKEN GLASS...AND SAID HE COULD NOT EVEN COME UP WITH AN EXPLANATION OF HOW IT MIGHT HAVE OCCURED SINCE IT WAS SO UNLIKELY FOR A CAR THIS NEW (97) WITH ONLY 43000 MILES AND THEN FOR THE "REAR PLANETARY (SP) GEAR CARRIER TO HAVE BEEN MUTILATED LIKE IT WAS WITHOUT THE FRONT HAPPENING. I HAVE PHOTOS TO SHOW THE HORRIFIC DAMAGE. AND I AM REPORTING THIS BECAUSE, GOD FORBID, I HAD NOT BEEN PARKED BUT STOPPED FOR A LIGHT OR SOMETHING OR ON A DARK ROAD OR WHEREVER, I CRINGE AT THE THOUGHT OF THE ACCIDENT THAT COULD HAVE OCCURRED WITH THIS HAPPENING WITH ABSOLUTELY NO WARNING AND I FEEL CHRYSLER SHOULD ANSWER TO THIS!!!!!!!! I DID CALL THEIR CUSTOMER SVC CENTER TO REPORT THIS AND TO DEMAND RESTITUTION AS IT COST ME $2134; THEY DID NOT WANT TO KNOW NOTHING SINCE I HAD NOT BROUGHT IT TO A "CHRYLSER/DODGE DEALER" TO BE FIXED....THE CATCH 22 IS THAT I DID NOT DO SO BECAUSE I WAS PASSED MY WARRANTLY AND MY EXPERIENCES WITH DEALERS' SERVICE CENTER PRICES FOR MAJOR WORK HAS BEEN BEYOND MY POCKETBOOK!!! PLEASE INVESTIGATE THIS MATTER
VEHICLE EXPERIENCES HESITATION, BUCKING AND MISFIRES CONTINUALLY, SEVERAL REPAIR ATTEMPTS TO SEVERAL COMPONENTS HOWEVER CONTINUES TO EXPERIENCE SYMPTONS. MJS
Official recalls
702V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V076000 · Seat Belts:rear/other
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
98V185000 · Child Seat
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
97V200000 · Tires:bead
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
97V070000 · Wheels:rim
Apr 28, 1997
THE STEEL ROAD WHEELS WERE DAMAGED BY THE EQUIPMENT USED TO MATCH MOUNT THE WHEEL TO THE TIRE.
Consequence & remedy
Consequence: A SCORE MARK WAS MADE ON THE WHEEL, AFFECTING THE DURABILITY OF THE WHEEL.
Remedy: DEALERS WILL REPLACE ALL ROAD WHEELS (AND FULL SIZE SPARE TIRES) WITH NEW WHEELS.
96V215000 · Service Brakes, Hydraulic:foundation Components:master Cylinder
Oct 29, 1996
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7PE02004 · Rear Seat Belt Malfunction
Opened Jan 16, 2002 · Closed Mar 11, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.