IllustrationMy driver side head rest was fine the night before. When I came out to my car the next morning, the AHR had defected and the padded part had "popped". No damage had occurred on the exterior of my vehicle.
2014 Dodge Avenger
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2014 Dodge Avenger do not stand out strongly from the model-year median of 157.
About this comparison →How this year compares
Owner complaints by model year
Compare all Avenger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
3225–50K
3050–75K
2475–100K
17100–150K
4150K+
145 reports with mileage · 60 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports3 fire reports7 injury reports
Seats complaints
24 reportsI was stopped at a red light, when the airbag in the headrest deployed on the driver side.
The contact's daughter owns a 2014 Dodge Avenger. The contact stated that while her daughter was driving approximately 40 MPH, the occupant restraint controller in the driver's seat activated inadvertently, and the head restraint deployed. The contact stated that her daughter was struck in the back of the head by the head restra…
Read full complaint
The contact's daughter owns a 2014 Dodge Avenger. The contact stated that while her daughter was driving approximately 40 MPH, the occupant restraint controller in the driver's seat activated inadvertently, and the head restraint deployed. The contact stated that her daughter was struck in the back of the head by the head restraint. The contact stated that her daughter had not observed the warning light before or after the failure. The contact's daughter had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 17V640000 (Seats, Air Bags); however, the VIN was not included. The failure mileage was unknown.
The contact owns a 2014 Dodge Avenger. The contact stated while driving at an undisclosed speed and coming to a stop, the driver’s side headrest deployed and pushed her head forward. The contact stated that the impact was like being rear-ended. The contact had a major headache from the impact of the headrest deployment. The cont…
Read full complaint
The contact owns a 2014 Dodge Avenger. The contact stated while driving at an undisclosed speed and coming to a stop, the driver’s side headrest deployed and pushed her head forward. The contact stated that the impact was like being rear-ended. The contact had a major headache from the impact of the headrest deployment. The contact inspected the headrest and became aware that the headrest spring had fractured. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 142,000.
I WAS LEAVING WORK ON FRIDAY, MARCH 19,2021 AROUND 4:05 P.M...STOPPED, MY CAR WAS NOT IN MOTION, I WAS WAITING FOR ON COMING TRAFFIC TO CLEAR, WHEN I HEARD WHAT I BELIEVED TO BE GUN SHOTS OR EITHER A CAR HAD CRASHED INTO THE BACK OF ME AT A HIGH RATE OF SPEED, THERE WERE NO VEHICLES BEHIND ME, I WAS SO SCARED, I WENT TO MY MECHA…
Read full complaint
I WAS LEAVING WORK ON FRIDAY, MARCH 19,2021 AROUND 4:05 P.M...STOPPED, MY CAR WAS NOT IN MOTION, I WAS WAITING FOR ON COMING TRAFFIC TO CLEAR, WHEN I HEARD WHAT I BELIEVED TO BE GUN SHOTS OR EITHER A CAR HAD CRASHED INTO THE BACK OF ME AT A HIGH RATE OF SPEED, THERE WERE NO VEHICLES BEHIND ME, I WAS SO SCARED, I WENT TO MY MECHANIC, AND HE DISCOVERED THE HORRIBLE NOISE WAS MY HEAD REST HAD EXPLODED. IT IS CUT IN HALF AND HAS STARTED RATTLING. MY MECHANIC ADVISED I CALL DODGE DEALER ON MONDAY MORNING 3/22/2021. I CALLED THIS MORNING AT 9:11 A.M. (EASTERN TIME). I DID RECEIVE A CALL BACK, I EXPLAINED IN GREAT DETAIL WHAT HAPPENED, I IN NO CERTAIN TERMS TOLD THE DEALER, I WILL NOT BE PAYING FOR THIS, AND WAS TOLD, THERE ARE NO OPEN RECALLS AT THIS TIME, THAT I WOULD NEED TO BRING MY CAR IN AND LEAVE FOR THE TECHNICIAN TO CHECK FOR PARTS AND IT MIGHT BE COVERED UNDER AN EXTENDED WARRANTY, I ALSO REQUESTED THEY CHECKED THE DRIVERS SIDE HEAD REST, STATED, THEY MIGHT NOT BE ABLE TO DO THAT. I STRESSED I AM SOMEWHAT AFRAID TO DRIVE MY CAR NOW ESPECIALLY NOT KNOWING IF THE DRIVERS SIDE HEAD REST WILL DEPLOY WHEN I AM SITTING OR DRIVING MY CAR. I SCHEDULED AN APPOINTMENT TO TAKE MY CAR IN THE MORNING AT 7:00 A.M. AND ALL OF A SUDDEN, THE PERSON I WAS TALKING TO CHANGED THE RESERVATION TO WEDNESDAY
THE BACK OF BOTH HEAD REST HAVE POPPED OPEN.
I WAS DRIVING AND HEARD A LOUD POP. LOOKED AT MY PASSENGER SEAT AND SAW THE HEAD REST CAME OFF THE PLASTIC HOLDING IN AIRBAG. THE BAG DID NOT DEPLOY AS FAR AS I CAN SEE. I WAS IN MOTION WHEN IT POPPED. I CALLED TO SEE IF DEALERSHIP WOULD FIX BUT THEY WANT ME TO PAY SINCE THERE IS NO RECALL BUT I FEEL WHEN IT COMES TO SAFETY IT S…
Read full complaint
I WAS DRIVING AND HEARD A LOUD POP. LOOKED AT MY PASSENGER SEAT AND SAW THE HEAD REST CAME OFF THE PLASTIC HOLDING IN AIRBAG. THE BAG DID NOT DEPLOY AS FAR AS I CAN SEE. I WAS IN MOTION WHEN IT POPPED. I CALLED TO SEE IF DEALERSHIP WOULD FIX BUT THEY WANT ME TO PAY SINCE THERE IS NO RECALL BUT I FEEL WHEN IT COMES TO SAFETY IT SHOULD BE FIXED WITH NO CHARGE TO CUSTOMER ESPECIALLY WHEN IT WAS A MALFUNCTION ON CAR.
MY SEATBELTS WILL UNLATCH WHENEVER IT FEELS LIKE IT, THE SEATBELTS WON'T GO IN BY THEMSELVES ANYMORE, AMD THIS ALL HAPPENED AFTER WE FIXED THE RECALL. THEN ALL IN A YEAR THE THROTTLE BODY QUIT WORKING, THE ALTERNATOR STOPPED WORKING, IT WILL NOT KEEP A CHARGE, AND SOMETIMES WHEN YOUR DRIVING FOR NO REASON AT ALL THE INSIDE LIGHT…
Read full complaint
MY SEATBELTS WILL UNLATCH WHENEVER IT FEELS LIKE IT, THE SEATBELTS WON'T GO IN BY THEMSELVES ANYMORE, AMD THIS ALL HAPPENED AFTER WE FIXED THE RECALL. THEN ALL IN A YEAR THE THROTTLE BODY QUIT WORKING, THE ALTERNATOR STOPPED WORKING, IT WILL NOT KEEP A CHARGE, AND SOMETIMES WHEN YOUR DRIVING FOR NO REASON AT ALL THE INSIDE LIGHTS WILL DIM AND BRIGHTEN. THIS ALL HAPPENS WHILE IN MOTION EXCEPT THE BATTERY CONSTANTLY DYING EVEN THOUGH THE ALTERNATOR AND BATTERY ARE NEW.
BOTH OF MY HEADRESTS DEPLOYED WITHOUT ANY TYPE OF COLLISION. THE FIRST HAPPENED A FEW MONTHS AGO, MY PASSENGER SIDE DEPLOYED OVERNIGHT WHEN THE CAR WAS PARKED IN THE CARPORT. THE PLASTIC CLIPS WERE BROKEN. THEN ON 7/15/2020, THE DRIVERS SIDE HEADREST DEPLOYED AT SOME POINT DURING THE 8 HOURS MY CAR WAS PARKED AT WORK. THANKF…
Read full complaint
BOTH OF MY HEADRESTS DEPLOYED WITHOUT ANY TYPE OF COLLISION. THE FIRST HAPPENED A FEW MONTHS AGO, MY PASSENGER SIDE DEPLOYED OVERNIGHT WHEN THE CAR WAS PARKED IN THE CARPORT. THE PLASTIC CLIPS WERE BROKEN. THEN ON 7/15/2020, THE DRIVERS SIDE HEADREST DEPLOYED AT SOME POINT DURING THE 8 HOURS MY CAR WAS PARKED AT WORK. THANKFULLY NO ONE WAS IN THE SEAT EITHER TIME BECAUSE THAT WOULD HAVE RESULTED IN INJURY. I HAVE RESEARCHED AND FOUND THAT THERE WAS A RECALL ON THE 2011-2013 AVENGER MODELS, BUT APPARENTLY THEY DECIDED NOT TO CHANGE ANYTHING FOR THE 2014 MODEL, THERE ARE TONS OF COMPLAINTS, SOME WITH INJURY, MOST WITH RIDICULOUS REPAIR BILLS AND ALL THIS IS DUE TO FAULTY CHEAP PLASTIC CLIPS THAT APPARENTLY JUST SNAP DURING NORMAL USE. WE SHOULD NOT BE RESPONSIBLE FOR THIS, CHRYSLER SHOULD BE HELD RESPONSIBLE, THIS IS A SAFETY ISSUE AND SHOULD BE RECALLED AND REPLACED WITH A BETTER, MORE SUBSTANTIAL SYSTEM.
WHILE THE CAR WAS AT A COMPLETE STOP (STATIONARY) WITH NO OTHER CARS AROUND, THE HEADREST ON THE DRIVERS SIDE SNAPPED OPEN JERKING THE DRIVERS HEAD FORWARD.
Official recalls
116V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.