Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
6 reports
35,500 miles · Nov 22, 2004
Engine And Engine Cooling
BOTH EXHAUST MANIFOLDS CRACKED . ONE MANIFOLD STUD BROKE OFF AT THE HEAD. WIRING HARNESS STARTED TO MELT DUE TO HOT EXHAUST. THIS IS A 454 CHEV. ENGINE. WE HAD TO INSERT METAL PLATE TO DEFLECT THE EXHAUST UNTIL WE COULD GET IT FIXED. IT IS IN THE SHOP NOW FOR REPAIR ON THE RIGHT EXHAUST MANIFOLD AND REPLACEMENT ON THE LEFT EXHA…
Read full complaint
BOTH EXHAUST MANIFOLDS CRACKED . ONE MANIFOLD STUD BROKE OFF AT THE HEAD. WIRING HARNESS STARTED TO MELT DUE TO HOT EXHAUST. THIS IS A 454 CHEV. ENGINE. WE HAD TO INSERT METAL PLATE TO DEFLECT THE EXHAUST UNTIL WE COULD GET IT FIXED. IT IS IN THE SHOP NOW FOR REPAIR ON THE RIGHT EXHAUST MANIFOLD AND REPLACEMENT ON THE LEFT EXHAUST MANIFOLD. WE WILL HAVE THE OLD PARTS WHEN DONE. *JB
NHTSA ODI #10100332
Mileage unknown · Nov 22, 2004
Visibility
BOUGHT UNIT USED ,DEFROSTER DID NOT WORK. AIR CONDITIONER HAS TO BE PUT ON TO GET THE HEAT OUT OF THE VENTS PRIOR TO USING THE VENTS. NONE OF THE DOOR ARE SWITCHING TO DIRECT THE AIR. *JB
NHTSA ODI #10100331
Mileage unknown · Oct 8, 2002
Structure
THE SPRINGS ON THE DRIVER SIDE OF THE MOTORHOME COLLASPED. CONSUMER STATES THAT THE SIZE 16 CHASSIS IS NOT SUFFICIENT ENOUGH TO CARRY A 3500 FOOT MOTORHOME. PLEASE GIVE ANY FURTHER DETAILS. MR
NHTSA ODI #8020420
Mileage unknown · Jun 17, 2002
Exterior LightingPower TrainSeats
THE MOTOR HOME WAS LEANING ON THE FRONT DRIVER'S SIDE AND IT CONTINUED TO WORSEN UNTIL THE SPRING COLLAPSED. THE DEALER STATED THAT THE SPRING COLLAPSED DUE TO BEING OVER WEIGHT AND WANTED TO CUT OFF THE RIGHT SPRING TO BALANCE THE RV. *YH
NHTSA ODI #566089
Mileage unknown · Jun 3, 2002
Structure
SCREWS WERE RUSTING OUT ON LATTER LOCATED ON BACK OF TRAILER. CONSUMER FELT THIS WAS VERY DANGEROUS. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8010945
Mileage unknown · Dec 21, 1998
Service Brakes, Hydraulic
WHEN DRIVING WITH FOOT ON THE ACCELERATOR DRIVER CAN RAISE AND CATCH UNDERNEATH THE BRAKE PEDAL. DEALER AND MANUFACTURER CONTACTED AND ADMITTED TO PROBLEM, BUT WILL NOT REMEDY THE PROBLEM. *AK
CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: DAMON WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR DAMON AT 1-800-860-3812.
VEHICLE DESCRIPTION: CLASS A AND C MOTOR HOMES. THE HARDWARE USED TO SECURE THE LIQUID PROPANE (LP) TANK WAS NOT TIGHTENED PROPERLY.
Consequence & remedy
Consequence: IF THE LP TANK IS NOT SECURED, THE TANK COULD FALL TO THE GROUND WHILE THE MOTOR HOME IS BEING DRIVEN.
Remedy: DEALERS WILL INSPECT THE MOTOR HOMES TO VERIFY THAT THE PROPER HARDWARE IS BEING USED AND THAT ALL NUTS ARE TIGHTENED PROPERLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
SQ99013 · Omitted Exhaust Hanger
Opened May 19, 1999 · No close date supplied
Status: open (inferred from source dates) · Visibility:defroster/defogger/hvac System
THIS INVESTIGATION IS OPENED TO OBTAIN ADDITIONAL INFORMATION CONCERNING THIS PROBLEM.HISTORICALLY, PROBLEMS THAT WOULD ALLOW VEHICLE COMPONENTS TO SEPARATE FROM THE VEHICLE HAVE BEEN ADDRESSED BY CONDUCTING SAFETY RECALLS.
1998 Damon Challenger Problems, Complaints & Recalls | Skip That Year
Illustration