NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
120 reportsClear category filterMileage unknown · Nov 8, 2002
Electrical System
BESIDES THE FAILURES JUST SHOWN, THERE WERE ADDITIONAL ELECTRICAL GAUGE FAILURES ON 02/28/00, 04/14/00, 05/08/99 AND CURRENTLY THERE ARE INTERMITTENT ELECTRICAL GAUGE FAILURES AND OTHER ELECTRICAL SYSTEM FAILURES, INCLUDING FM RADIO, DOOR LOCKS, ELECTRIC WINDOW CONTROLS. CHRYSLER IS NOT RESPONSIVE AND THE DEALER HAS NOT BEEN CO…
Read full complaint
BESIDES THE FAILURES JUST SHOWN, THERE WERE ADDITIONAL ELECTRICAL GAUGE FAILURES ON 02/28/00, 04/14/00, 05/08/99 AND CURRENTLY THERE ARE INTERMITTENT ELECTRICAL GAUGE FAILURES AND OTHER ELECTRICAL SYSTEM FAILURES, INCLUDING FM RADIO, DOOR LOCKS, ELECTRIC WINDOW CONTROLS. CHRYSLER IS NOT RESPONSIVE AND THE DEALER HAS NOT BEEN COOPERATIVE. THIS VEHICLE HAS BEEN A "LEMON" SINCE IT WAS NEW BUT CHRYSLER HAS REFUSED TO REPAIR ANYTHING NOT COVERED UNDER WARRANTY OR A NATIONAL RECALL. DT
NHTSA ODI #769450
Mileage unknown · Oct 8, 2002
Electrical System
HORN STOPPED WORKING WITHOUT WARNING. *MR
NHTSA ODI #8020440
Mileage unknown · Sep 16, 2002
Electrical SystemStructureFire
CONSUMER BROUGHT VEHICLE IN FOR REPAIRS TO THE DASHBOARD LIGHTS. THE PROBLEM HAD FIXED WITH NO FURTHER DIFFICULTIES. TWO AND A HALF WEEKS LATER ON AUG 25 THE VEHICLE BURNED UP FROM A FIRE WHICH ORIGINATED FROM THE DASHBOARD AREA. THIS WAS AN ELECTRICAL FIRE THAT CAME ABOUT WITH OUT ANY WARNING. CONSUMER IS REQUESTING MONETAR…
Read full complaint
CONSUMER BROUGHT VEHICLE IN FOR REPAIRS TO THE DASHBOARD LIGHTS. THE PROBLEM HAD FIXED WITH NO FURTHER DIFFICULTIES. TWO AND A HALF WEEKS LATER ON AUG 25 THE VEHICLE BURNED UP FROM A FIRE WHICH ORIGINATED FROM THE DASHBOARD AREA. THIS WAS AN ELECTRICAL FIRE THAT CAME ABOUT WITH OUT ANY WARNING. CONSUMER IS REQUESTING MONETARY REIMBURSEMENT FOR EXPENSES. THE VISOR HOOKS WERE REPLACED PRIOR TO INCIDENT. *JG
NHTSA ODI #8018671
Mileage unknown · Sep 12, 2002
Air BagsElectrical SystemVehicle Speed Control
BELT TENSION" AND "POWER STRING" FAILED, CAUSING HORN/ AIRBAG, AND CRUISE CONTROL TO FAIL.
NHTSA ODI #8018551
Mileage unknown · Jun 4, 2002
Air BagsElectrical SystemVehicle Speed Control
AIRBAG LIGHT STAYS ON OR BLINKS INTERMITTENTLY, HORN AND CRUISE CONTROL DOESN'T WORK - ***DANGEROUS*** - WILL HAVE DEALER REPLACE DEFECTIVE CLOCKSPRING HARNESS - RECALL???
NHTSA ODI #762618
Mileage unknown · May 12, 2002
Electrical System
WINDSHIELD WIPERS ARE ACTIVATED BY USING THE TURN SIGNALS OR CHANGING THE LIGHT BEAMS FROM LOW TO HIGH OR VICE VERSA AT LEAST ONCE EACH TIME THE CAR IS DRIVEN. DROVE 64 MILES TODAY AND IT HAPPENED THREE TIMES. VERY FRUSTRATING. THE SCRATCHES IN THE WINDSHIELD ARE BEGINNING TO MAKE NIGHT DRIVING MORE DIFFICULT AND UNSAFE. *TS …
Read full complaint
WINDSHIELD WIPERS ARE ACTIVATED BY USING THE TURN SIGNALS OR CHANGING THE LIGHT BEAMS FROM LOW TO HIGH OR VICE VERSA AT LEAST ONCE EACH TIME THE CAR IS DRIVEN. DROVE 64 MILES TODAY AND IT HAPPENED THREE TIMES. VERY FRUSTRATING. THE SCRATCHES IN THE WINDSHIELD ARE BEGINNING TO MAKE NIGHT DRIVING MORE DIFFICULT AND UNSAFE. *TS *JB ****DIMSII IVOQ ENTRY POSTED AFTER 12-12-02 CUT OVER TO ARTEMIS****
NHTSA ODI #10008818
Mileage unknown · Apr 8, 2002
Air BagsElectrical SystemVehicle Speed Control
MY CRUISE CONTROL IS INTERMITTENT, MY AIRBAG LIGHT COMES ON INTERMITTENLY, MIGHT WINDSHIELD WIPERS COME ON INTERMITTENTLY. HORN SPORADICALLY DOES NOT WORK.*AK
NHTSA ODI #760426
Mileage unknown · Mar 16, 2002
Air BagsElectrical SystemVehicle Speed Control
FAILURE OF PART CAUSED CRUISE CONTROL, HORN AND AIRBAG TO BE NON-OPERATIONAL. THIS IS A SAFETY HAZARD THAT OCCURED AT 65 MPH ON THE FREEWAY. IF AN ACCIDENT HAD OCCURED, I WOULD HAVE BEEN UNABLE TO OPERATE THE HORN TO ALERT ANOTHER VEHICLE AND THE AIRBAG WOULD NOT HAVE DEPLOYED. IN ADDITION, THE CRUISE CONTROL FAILED WHILE IN …
Read full complaint
FAILURE OF PART CAUSED CRUISE CONTROL, HORN AND AIRBAG TO BE NON-OPERATIONAL. THIS IS A SAFETY HAZARD THAT OCCURED AT 65 MPH ON THE FREEWAY. IF AN ACCIDENT HAD OCCURED, I WOULD HAVE BEEN UNABLE TO OPERATE THE HORN TO ALERT ANOTHER VEHICLE AND THE AIRBAG WOULD NOT HAVE DEPLOYED. IN ADDITION, THE CRUISE CONTROL FAILED WHILE IN USE ON THE FREEWAY WHICH ALSO COULD HAVE RESULTED IN AN ACCIDENT.*AK
NHTSA ODI #759444
Mileage unknown · Mar 14, 2002
Electrical SystemService Brakes, HydraulicVehicle Speed Control
WE EXPERIENCED PROBLEMS WITH ABS LIGHT ON, HORN AND CRUISE CONTROL NOT WORKING, CHRYSLER CHANGED THE CLOCK SPRING, NOW EVERYTHING IS OK. *AK
NHTSA ODI #759347
Mileage unknown · Mar 13, 2002
Air BagsElectrical SystemVehicle Speed Control
CLOCKSPRING FAILURE CAUSING DRIVER'S AIRBAG/ CRUISE CONTROL, AND HORN TO STOP FUNCTIONING.*AK
NHTSA ODI #759321
NHTSA investigations
14EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00032 · Air Bag Clockspring
Opened Aug 8, 2000 · Closed Feb 21, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97002 · Fuel Tank Leaks
Opened Jan 31, 1997 · Closed Feb 10, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS ENGINEERING ANALYSIS WAS OPENED ON JANUARY 31, 1997 BASED ON INFORMATION GATHERED DURING PRELIMINARY EVALUATION (PE), PE96-051. THE PE WAS OPENED ON AUGUST 19, 1996, TO INVESTIGATE ALLEGATIONS OF FUEL LEAKAGE FROM THE AREA WHERE THE FUEL PUMP/SENDING UNIT JOINS THE FUEL TANK.FOR BREVIDY, THIS AREA WILL BE REFERRED TO AS THE PUMP/TANK INTERFACE.THESE ALLEGATIONS WERE FIRST RECEIVED BY ODI ON AUGUST 2, 1996 WHILE INVESTIGATING ALLEGATIONS OF CHRYSLER MINIVAN THROTTLE SHAFT HAND-UP, AND UNCONTROLLED ENGINE SPEED, IN PE96-036.WHILE DISCUSSING THAT ISSUE WITH A FLEET, IT WAS ALLEGED THAT AT LEAST 10(OUT OF 40) 1996 EARLY PRODUCTION CHRYSLER MINIVANS LEAKED FUEL FROM THE PUMP/TANK INTERFACE.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA INDICATE FUEL TANK LEAKAGE INCIDENTS IN THE SUBJECT VEHICLES PREDOMINATLY AFFECTED EARLY PRODUCTION VEHICLES.THE DATA INVOLVING CONFIRMED INCIDENTS OF TANK/PUMP INTERFACE LEAKS SUGGEST THAT THOSE FAILURES HAVE BEEN DECLINING SINCE JULY 1996.ODI HAS RECEIVED NO REPORTS OF THE SUBJECT CONDITION INVOLVING ORIGINAL EQUIPMENT PUMPS AND TANKS SINCE SEPTEMBER, 1997.CURRENTLY THIS ISSSUE DOES NOT REQRESENT A CONTINUING FIELD CONCERN.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES FOR FUEL LEAKS OF ANY TYPE.A SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURED DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
EA96025 · Sliding Door Latch Failure
Opened Oct 15, 1996 · Closed Jul 30, 1998
Status: closed (inferred from source dates) · Structure
ANALYSIS OF KNOWN INCIDENTS INDICATES A DECLINING TREND OVER THE LAST FIVE CALENDAR QUARTERS.EXTENSIVE TESTING OF INCIDENT VEHICLES HAS FAILED TO REPRODUCE OCCURRENCES OF FULL LATCH DISENGAGEMENT.NO FAILURE MODE WHICH COULD CAUSE A PROPERLY LATCHED DOOR TO LOSE FULL LATCH ENGAGEMENT WHILE DRIVING HAS BEEN VERIFIED AS A CAUSAL FACTOR IN ANY OF THE KNOWN INCIDENT VEHICLES DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.HOWEVER, ODI WILL CONTINUE TO MONITOR COMPLAINT INPUT FOR THE NEXY YEAR AND WILL REQUEST UPDATED REPORTS FROM CHRYSLER DURING THAT PROCESS.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96051 · Fuel Leaks From The Gas Tank
Opened Aug 19, 1996 · Closed Jan 31, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ANALYSIS TO DATE INDICATES THAT SOME OF THE SUBJECT VEHICLESCONTINUE TO EXPERIENCE FUEL LEAKS FROM THE FUEL TANK AT THE SENDING UNIT INTERFACE.MOST OFTEN THE LEAK INVOLVES THE O-RING SEAL.
PE96038 · Sliding Door Latch Failure
Opened May 16, 1996 · Closed Oct 15, 1996
Status: closed (inferred from source dates) · Structure
CHRYSLER MAINTAINS THAT THE COMMON FACTOR CONTRIBUTING TO KNOWN SLIDING DOOR OPENING INCIDENTS IS PRIOR INCORRECT DEALER LATCH ADJUSTMENT.CHRYSLER ATTRIBUTES THIS PROBLEM TO AN INACCURATE SERVICE MANUAL PROCEDURE - SLIDING DOOR LATCH/LOCK CONTROL, REMOVAL AND INSTALLATION.CHRYSLER FURNISHED INFORMATION SHOWING THAT SIX OF ITS COMPLAINTS, AND TWO OF ODI'S, INVOLVED VEHICLES THAT HAD UNDERGONE PRIOR REPAIRS TO THE AFFECTED SLIDING DOOR.CHRYSLER HAS ADDRESSED THE PROBLEM BY ISSUING TWO TECHNICAL SERVICE BULLETINS.TSB 26-06-96, SERVICE MANUAL REVISIONS, WAS ISSUED IN JUNE 1996 AND INCLUDES A SERVICE REVISION (#81-370-6105A) CORRECTING SERVICE MANUAL SLIDING DOOR REPAIR PROCEDURES.TSB 23-39-96, SLIDING DOOR(S) DIFFICULT TO OPEN FROM THE OUTSIDE AND/OR INSIDE, WAS ISSUED JUNE 28, 1996.CHRYSLER IDENTIFIED THREE DESIGN CHANGES INVOLVING THE SUBJECT COMPONENTS: (1)SLIDING DOOR LATCH PAWL SPRING FORCE INCREASED FROM 5.4 NEWTONS TO 8.0 NEWTONS IN SEPTEMBER 1995 TO ENHANCE PAWL ROTATION RETURN TO NEUTRAL POSITION; (2)ADJUSTABLE SLIDING DOOR HINGE IMPLEMENTED IN NOVEMBER 1995 TO REDUCE VARIATION IN SLIDING DOOR FIT; AND(3)SLIDING DOOR STRIKER ATTACHMENT HOLES REVISED IN JANUARY 1996 TO ELIMINATE UP/DOWN ADJUSTMENT OF STRIKER TO IMPROVE INSTALLATION PROCESS AND REDUCE VARIABILITY OF ALIGNMENT BETWEEN LATCH AND STRIKER.AT PRESENT, ODI IS NOT AWARE OF ANY INCIDENTS INVOLVING VEHICLES BUILT IN OR AFTER JANUARY 1996.ODI HAS CONTINUED TO RECEIVE COMPLAINTS OF SLIDING DOORS OPENING WHILE THE VEHICLES ARE IN MOTION, INCLUDING VEHICLES WITH NO PRIOR SERVICE HISTORY TO THE AFFECTED SLIDING DOOR ASSEMBLY.OWNERS ALLEGE THAT THE DOORS OPEN ANYWHERE FROM A FEW INCHES TO FULLY OPEN, AT SPEEDS RANGING FROM 15 TO 60 MPH.ODI HAS ALSO RECEIVED NUMBEROUS COMPLAINTS ALLEGING DIFFICULTY IN LATCHING THE SUBJECT SLIDING DOORS AND/OR DIFFICULTY IN OPENING ONE OR BOTH SLIDING DOORS.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE95053 · Fuel Leakeage From Rollover Valve
Opened Oct 25, 1995 · Closed Dec 22, 1995
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control
There is no summary currently available
Illustration