SEVERE ENGINE OVERHEATING BECAUSE COOLING FAN FELL OFF OF THE SHAFT OF THE ELECTRIC FAN MOTOR. TERRIBLE DESIGN - LARGE DIAMETER FAN IS BASICALLY HELD IN PLACE BY A SINGLE 1/4-INCH NUT. NEITHER THE FAN NOR THE FAN MOTOR ARE STOCKED AS REPLACEABLE PARTS. ONE MUST PURCHASE THE ENTIRE FAN/MOTOR/SHROUD ASSEMBLY, FOR A LITTLE OVER …
Read full complaint
SEVERE ENGINE OVERHEATING BECAUSE COOLING FAN FELL OFF OF THE SHAFT OF THE ELECTRIC FAN MOTOR. TERRIBLE DESIGN - LARGE DIAMETER FAN IS BASICALLY HELD IN PLACE BY A SINGLE 1/4-INCH NUT. NEITHER THE FAN NOR THE FAN MOTOR ARE STOCKED AS REPLACEABLE PARTS. ONE MUST PURCHASE THE ENTIRE FAN/MOTOR/SHROUD ASSEMBLY, FOR A LITTLE OVER $400, PLUS INSTALLATION! THIS SAME PROBLEM HAPPENED AGAIN - THREE DIFFERENT TIMES! A FEW MONTHS AFTER THE INITIAL REPAIR, THE FAN SEPARATED FROM THE FAN MOTOR ONCE AGAIN, CAUSING OVERHEATING. THE SHOP THAT INSTALLED THE ORIGINAL UNIT STOOD BEHIND HIS WARRANTY, AND REPLACED THE FAN/MOTOR/SHROUD ASSEMBLY FREE OF CHARGE. ANOTHER TIME, WHILE WE WERE ON A TRIP, THE FAN CAME OFF A GAIN, BUT THE LOCAL CHRYSLER DEALER WAS ABLE TO FIND THE NUT THAT HAD DROPPED OFF, AND REPLACED IT. SOMETIME LATER, THE PROBLEM HAPPENED AGAIN, AND I PUT EVERYTHING BACK TOGETHER AND HELD IT IN PLACE WITH EPOXY. IT'S STILL GOING STRONG!
NHTSA ODI #10070138
134,000 miles · Dec 31, 2003
Engine And Engine CoolingPower Train
WHILE DRIVING 15 MPH, THE CONSUMER HEARD A LOUD NOISE COMING FROM UNDERNEATH THE HOOD, THEN THE VEHICLE STALLED AND THE POWER STEERING AND BRAKES LOCKED UP. THE CONSUMER MANAGED TO PULL OVER AND HAD THE VEHICLE TOWED. THERE IS A HOLE IN THE VEHICLE'S TRANSMISSION.*JB *MR
NHTSA ODI #10052226
Mileage unknown · Jun 8, 2001
Engine And Engine Cooling
WHILE DRIVING COULD HEAR NOISE COMING FROM ENGINE, AND VEHICLE COULD NOT BE DRIVEN. THEN, TOWED TO DEALER, WHO FOUND OUT THAT DEFECT WAS BELT PULLEY TENSIONER. THIS HAD BEEN FOURTH TIME THAT BELT PULLEY HAD TO BE REPLACED.*AK *SLC
NHTSA ODI #890051
Mileage unknown · May 27, 2001
Electrical SystemEngine And Engine CoolingPower Train
WHILE BACKING OUT OF PARKING SPACE THE TENSIONER BROKE OFF ENGINE CAUSING A LOSS OF POWER STEERING, ALTERNATOR FUNCTION , COOLING AND SOME ADDITIONAL TRANSMISION DIFFUCULTY WAS NOTED .
NHTSA ODI #745989
Mileage unknown · Aug 11, 1999
Engine And Engine Cooling
WHILE DRIVING AT 10 MPH OUT OF PARKING SPOT HEARD HUGE CRACKING NOISE. VEHICLE WAS UNCONTROLLABLE DUE TO BELT TENSIONER BREAKING IN TWO. DEALER NOT AWARE. PROBLEM STILL EXISTS. PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #844848
Mileage unknown · Feb 19, 1999
Electrical SystemEngine And Engine CoolingEquipment
WIRE TO UNDER HOOD LIGHT SHORTED OUT, BLOWING FUSE. LOST ALL INTERIOR LIGHTS, INCLUDING INSTRUMENT LIGHTS. NEXT ITEM, EGR VALVE WENT BAD, CAUSING VEHICLE TO BACKFIRE, ALSO CHECK ENGINE LIGHT CAME ON. NEXT ITEM, BATTERY SHORTED OUT CAUSING VEHICLE TO STALL. VEHICLE WAS DISABLED ON HIGHWAY, COULD HAVE CAUSED ACCIDENT, HAD TO BE …
Read full complaint
WIRE TO UNDER HOOD LIGHT SHORTED OUT, BLOWING FUSE. LOST ALL INTERIOR LIGHTS, INCLUDING INSTRUMENT LIGHTS. NEXT ITEM, EGR VALVE WENT BAD, CAUSING VEHICLE TO BACKFIRE, ALSO CHECK ENGINE LIGHT CAME ON. NEXT ITEM, BATTERY SHORTED OUT CAUSING VEHICLE TO STALL. VEHICLE WAS DISABLED ON HIGHWAY, COULD HAVE CAUSED ACCIDENT, HAD TO BE TOWED. NEXT, TRANSMISSION SEAL AND GASKET FAILURE, CAUSING TRANSMISSION FLUID TO BE SPRAYED ON VEHICLE AND ROADWAY. NEXT ITEM, REAR SUSPENSION CAUSED REAR TIRE TO COME IN CONTACT WITH REAR WHEELWELL, COULD HAVE BLOWN TIRE IF NOT CAUGHT IN TIME.NEXT SPARE TIRE HOLDER FAILURE CAUSED TIRE TO BE LOWERED WHICH CAUSED TIRE TO COME IN CONTACT WITH ROAD, THUS COULD HAVE CAUSED AN ACCIDENT. *AK
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
1995 Chrysler Town And Country Problems, Complaints & Recalls | Skip That Year
Illustration