TRANSMISSION STARTED SHIFTING REALLY ROUGH AROUND 116,000. PREVIOUS OWNER REPLACED THE TRANSMISSION. WHEN THEY SOLD IT TO US AT AROUND 150,000, THE TRANSMISSION STARTED SHIFTING HARD AGAIN. NOW AT 169,000 IT SHIFTS BACK AND FORTH BETWEEN 2ND AND 3RD GEARS AND IS VERY ROUGH. WHEN SHIFTING INTO REVERSE, IT CLUNKS. THIS IS AFTER WE…
Read full complaint
TRANSMISSION STARTED SHIFTING REALLY ROUGH AROUND 116,000. PREVIOUS OWNER REPLACED THE TRANSMISSION. WHEN THEY SOLD IT TO US AT AROUND 150,000, THE TRANSMISSION STARTED SHIFTING HARD AGAIN. NOW AT 169,000 IT SHIFTS BACK AND FORTH BETWEEN 2ND AND 3RD GEARS AND IS VERY ROUGH. WHEN SHIFTING INTO REVERSE, IT CLUNKS. THIS IS AFTER WE EVEN TOOK IT IN AND HAD TRANSMISSION FIXED. NO GOOD. *TR
NHTSA ODI #10238688
116,000 miles · Aug 7, 2008
EquipmentPower TrainService Brakes, Hydraulic
TL*THE CONTACT OWNS A 1994 CHRYSLER TOWN AND COUNTRY. THE SLIDING DOOR IS CURRENTLY BEING HELD ONTO THE VEHICLE BY ONE OUT OF THREE HINGES. THE DOOR HAS TO BE PUSHED VERY HARD IN ORDER FOR IT TO CLOSE. IN ADDITION, THE REAR WIPER DOES NOT WORK AND THE MOTOR NEEDS TO BE REPLACED. THE CONTACT HAS DECIDED NOT TO REPAIR THE VEHI…
Read full complaint
TL*THE CONTACT OWNS A 1994 CHRYSLER TOWN AND COUNTRY. THE SLIDING DOOR IS CURRENTLY BEING HELD ONTO THE VEHICLE BY ONE OUT OF THREE HINGES. THE DOOR HAS TO BE PUSHED VERY HARD IN ORDER FOR IT TO CLOSE. IN ADDITION, THE REAR WIPER DOES NOT WORK AND THE MOTOR NEEDS TO BE REPLACED. THE CONTACT HAS DECIDED NOT TO REPAIR THE VEHICLE. WHEN HE PLACES THE VEHICLE INTO DRIVE, IT TAKES A WHILE TO SHIFT. THE VEHICLE MAKES A THUMPING SOUND WHEN IT DOES SHIFT INTO GEAR. THE AIR CONDITIONER HAS NOT WORKED SINCE THE VEHICLE WAS PURCHASED. THE ALL WHEEL DRIVE MAKES A CLUNKING NOISE COMING FROM THE REAR OF THE VEHICLE. ON A HOT DAY, THE GEARS SKIP AS IF THEY ARE NOT GRIPPING PROPERLY IN THE REAR OF THE VEHICLE. THE CURRENT MILEAGE WAS 135,000 AND FAILURE MILEAGE WAS 116,000.
NHTSA ODI #10237368
Mileage unknown · Dec 2, 2002
Power Train
TRANSMISSION NOT SHIFTING OUT OF SECOND GEAR. CHECKED ALL APPROPRIATE FUSES RELAYS AND RESET COMPUTER WITH POWER DISCONNECTED. FLUID CLEAR AND PINK. TRANSMISSION THEN REFUSES TO MOVE FORWARD OR BACK. NO PRIOR OVERHEATING OF THIS VEHICLE. DT
NHTSA ODI #770348
Mileage unknown · Jul 30, 2002
Power Train
DIFFERENTIAL PIN SHOT OUT THROUGH TRANSMISSION HOUSING, CAUSING TRANSMISSION TO BLOW. THERE WAS A LOUD BANG WHILE VEHICLE WAS GOING 55MPH. TRANSMISSION SEIZED UP, AND WAS LEAKING. VEHICLE WOULDN'T SHIFT OUT OF 2ND GEAR. VEHICLE HAD NO BRAKES TO ALERT DRIVERS BECAUSE VEHICLE WOULD EVENTUALLY SLOW DOWN BY JERKING IN GEAR. DEAL…
Read full complaint
DIFFERENTIAL PIN SHOT OUT THROUGH TRANSMISSION HOUSING, CAUSING TRANSMISSION TO BLOW. THERE WAS A LOUD BANG WHILE VEHICLE WAS GOING 55MPH. TRANSMISSION SEIZED UP, AND WAS LEAKING. VEHICLE WOULDN'T SHIFT OUT OF 2ND GEAR. VEHICLE HAD NO BRAKES TO ALERT DRIVERS BECAUSE VEHICLE WOULD EVENTUALLY SLOW DOWN BY JERKING IN GEAR. DEALER WAS NOT NOTIFIED. PLEASE PROVIDE MORE INFORMATION.*AK
NHTSA ODI #8015187
Mileage unknown · Jun 12, 2002
Power Train
WHILE DRIVING TRANSMISSION WENT OUT. WHEN CONTACTING DEALER, DEALER NOTED THAT SEAL PLUGS IN TRANSMISSION NEEDED TO BE REPLACED.*AK
NHTSA ODI #8011585
Mileage unknown · May 28, 2002
Power Train
WHILE DRIVING AT 65 MPH TRANSMISSION WENT OUT OF DRIVE AND INTO NEUTRAL, CAUSING SOME DIFFICULTIES FOR CONSUMER. CONTACTED DEALER, AND THE DEALER WILL REPLACE TRANSMISSION AGAIN FOR THIRD TIME SINCE MAY OF 2000. *AK
NHTSA ODI #8010506
Mileage unknown · Mar 27, 2002
Power Train
WHILE DRIVING THE VEHICLE IT WILL JERK AND CHUG, NOT GOING INTO GEAR AS IT IS SUPPOSE TO. THE TRANSMISSION HAS BEEN REPLACED THREE TIMES. NLM
NHTSA ODI #8006537
Mileage unknown · Jul 13, 2001
Power Train
WHILE TRAVELING 70MPH ON HIGHWAY AUTOMATIC TRANSMISSION WENT FROM HIGH GEAR TO LOW GEAR. VEHICLE WAS UNABLE TO GO FASTER THAN 10MPH. DEALER REPAIRED VEHICLE AT OWNERS EXPENSE OF TWO THOUSAND DOLLARS. PLEASE PROVIDE FURTHER DETAILS.*AK
NHTSA ODI #892734
Mileage unknown · Jun 5, 2001
Power Train
WAS TRAVELING 30MPH WHEN TRANSMISSION EXPLODED. HAD VEHICLE HAD STOPPED DEAD IN MIDDLE OF TRAFFIC. TOWED TO DEALERSHIP, AND INFORMED THAT A PIN HOLDING TRANS AXLE HAD BROKEN. IT WAS A HOLLOWED PIN THAT WAS USED.*AK
NHTSA ODI #889835
Mileage unknown · Mar 20, 2001
Power Train
CONSUMER HAS HAD TRANSMISSION WORK DONE TWICE. CONSUMER INFORMED THAT TRANSMISSION NEEDS TO BE REPLACED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH 2-SPOKE LUXURY WHEELS MANUFACTURED JULY 1992 THROUGH JUNE 1993; OR EQUIPPED WITH 4-SPOKE SPORT WHEELS MANUFACTURED FROM JULY 1992 THROUGH SEPTEMBER 1993. THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence & remedy
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR CRACKS AND ANY WHEELS WITH CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence & remedy
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
WHEELS WITH MISFORMED LUG NUT SEATS WERE INSTALLED ON THESE VEHICLES. THIS CAUSES REDUCED NUT TO WHEEL CONTACT AREA AND LIMITS THE WHEEL SELF-CENTERING CAPABILITY DURING INSTALLATION. THIS RESULTS IN LOSS OF WHEEL LUG NUT TORQUE RETENTION.
Consequence & remedy
Consequence: LOSS OF LUG NUT TORQUE RETENTION MAY LEAD TO WHEEL LUGFAILURE WHICH MAY CAUSE WHEEL SEPARATION AND AN ACCIDENT.
Remedy: INSPECT THE WHEEL ASSEMBLY PLANT CODE; REPLACE WHEELS KNOWN TO HAVE THE PROBLEM AND INSTALL NEW LUG NUTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
RQ00011 · Steering Wheel Separation
Opened May 1, 2000 · Closed Apr 1, 2002
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Additional source detail variants (2)
Steering
There is no summary currently available
Steering
There is no summary currently available
EA98006 · Inadvertent Air Bag Deployments
Opened Feb 27, 1998 · Closed May 24, 1999
Status: closed (inferred from source dates) · Air Bags
COMPLAINTS ALLEGE THAT THE FRONT AIR BAG (S) DEPLOYED INADVERTENTLY--IN MOST CASES WHILE STARTING THE VEHICLE.
PE97046 · Inadvertent Air Bag Deployments
Opened Oct 24, 1997 · Closed Feb 27, 1998
Status: closed (inferred from source dates) · Air Bags
COMPLAINTS ALLEGE THAT THE SUBJECT VEHICLES' AIR BAGS DEPLOYED INADVERTENTLY (IN MOST CASES WHEN STARTING THE VEHICLE).
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
1994 Chrysler Town And Country Problems, Complaints & Recalls | Skip That Year
Illustration