ENGINE CHECK LIGHT ILLUMINATED, INDICATING A MALFUNCTION WITHIN SYSTEM, CAUSE UNKNOWN.DEALER REPLACED THE OXYGEN SENSOR WHICH DID NOT CORRECT THE PROBLEM. I HAD THE OXYGEN SENSOR REPLACED AGAIN ALONG WITH A EXHAUST MANIFOLD- STILL DID NOT CORRECT THE PROBLEM. CHECK ENGINE LIGHT ON AGAIN! DRIVING AT ABOUT 65MPH ON BUSY HIGHWAYS T…
Read full complaint
ENGINE CHECK LIGHT ILLUMINATED, INDICATING A MALFUNCTION WITHIN SYSTEM, CAUSE UNKNOWN.DEALER REPLACED THE OXYGEN SENSOR WHICH DID NOT CORRECT THE PROBLEM. I HAD THE OXYGEN SENSOR REPLACED AGAIN ALONG WITH A EXHAUST MANIFOLD- STILL DID NOT CORRECT THE PROBLEM. CHECK ENGINE LIGHT ON AGAIN! DRIVING AT ABOUT 65MPH ON BUSY HIGHWAYS THE CAR JUST SHUTS DOWN. ANY INFORMATION WOULD BE HELPFUL. *AK
NHTSA ODI #10104859
106,700 miles · Sep 29, 2003
Engine And Engine CoolingFire
WHILE DRIVING AT APPROXIMATELY 45 MPH, NOTICED SMOKE COMING FROM THE REAR OF VEHICLE. PULLED VEHICLE OVER TO SIDE OF ROAD AND CHECKED UNDER THE HOOD. HEAD GASKETS WERE LEAKING OIL FROM THE ENGINE. DROVE VEHICLE TO DEALERSHIP, AND MECHANIC CONFIRMED WHAT PROBLEM WAS. HAD NOT HAD HEAD GASKETS REPAIRED. *AK
NHTSA ODI #10041846
Mileage unknown · Sep 25, 2003
Engine And Engine Cooling
WHILE DRIVING 60 MPH THE VEHICLE SUDDENLY LOST POWER WITHOUT WARNING AND STALLED OUT. THE VEHICLE WAS PUSHED OUT OF TRAFFIC. THE VEHICLE WAS THEN TOWED TO DEALERSHIP. THE DEALER HAS NOT FOUND THE CAUSE OF THE PROBLEM. PLEASE PROVIDE INFORMATION. *NLM
NHTSA ODI #10040584
Mileage unknown · Aug 11, 2003
Engine And Engine Cooling
WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING ENGINE CHECK LIGHT APPEARED ON THE DASHBOARD, AND VEHICLE OVERHEATED. *AK
NHTSA ODI #10033646
Mileage unknown · Nov 27, 2002
Engine And Engine CoolingPower TrainWheels
WHILE THE CONSUMER'S WIFE WAS DRIVING, THE LUG NUTS SHEARED OFF THE RIGHT FRONT WHEEL OF THE VEHICLE. CONSUMER STATED THAT POOR DESIGN SET UP AN IRREGULAR VIBRATION IN THE WHEEL WHICH GRADUALLY WORKED THE LUG NUTS LOOSE AND FAILED. *YH
NHTSA ODI #568503
Mileage unknown · Oct 29, 2002
Engine And Engine Cooling
WHILE TRAVELING ON THE HIGHWAY THE VEHICLE SHUT DOWN WITHOUT PRIOR WARNING. THE DEALERSHIP IS AWARE OF THE PROBLEM. TS
NHTSA ODI #8021872
Mileage unknown · Sep 10, 2002
Engine And Engine CoolingFuel System, GasolineVehicle Speed Control
WHILE DRIVING ENGINE LIGHT CAME ON AND THE VEHICLE SEEMED A BIT SLUGGISH DUE TO LDP PUMP FAILURE. CONSUMER RECEIVED A RECALL NOTICE ON FULL THROTTLE (02V-186) TOOK THE VEHICLE TO THE DEALER AND WAS FIXED BUT THE PROBLEM STILL EXISTS. *YH
NHTSA ODI #567396
Mileage unknown · Aug 28, 2002
Engine And Engine Cooling
ENGINE WOULD STALL WHEN MAKING A TURN AND GOING ONTO AN INCLINE. VEHICLE BEEN TO A DEALER ON TWO OCCASIONS, AND THE PROBLEM IS STILLOCCURRING. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. *AK
NHTSA ODI #8017395
Mileage unknown · Jun 28, 2002
Engine And Engine Cooling
HEAD GASKET FAILURE. *AK
NHTSA ODI #763599
Mileage unknown · Apr 18, 2002
Engine And Engine Cooling
CONSUMER STATES THAT THERE IS AN OIL LEAK ON THE VEHICLE WHEN THE CONSUMER IS DRIVING AND WHEN THE CONSUMER IS AT A COMPLETE STOP. CONTACTED DEALER AND THE DEALER TOLD THE CONSUMER THAT IT IS A POSSIBLE HEAD GASKET LEAK. NLM
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5L V6 ENGINES, THE THROTTLE CONTROL CABLE CAN FRAY CAUSING THE THROTTLE TO BIND OR STICK.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN A LOSS OF THROTTLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE ASSEMBLY. OWNER NOTIFICATION BEGAN AUGUST 5, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE ADJUSTMENT OF THE CABLE CONNECTING THE CONSOLE SHIFTER MECHANISM TO THE IGNITION KEY CAN CAUSE A TRAPPED KEY CONDITION WHICH CAN RESULT IN A LOW FORCE REQUIRED TO DEPRESS THE SHIFT BUTTON. A COMBINATION OF APPLYING A MIS-ADJUSTED RELEASE BUTTON WITH A LOW FORCE ATTEMPT TO SHIFT OUT OF PARK WITH THE KEY IN THE LOCKED POSITION, CAN BREAK THE CONNECTING PIN IN THE SHIFTER.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE "IGNITION-PARK" INTERLOCK SYSTEM WILL BE NONFUNCTIONAL.
Remedy: DEALERS WILL INSPECT FOR PROPER OPERATION OF THE SYSTEM. ANY VEHICLES THAT ARE NOT FUNCTIONAL AFTER THE INSPECTION WILL HAVE THE SHIFT MECHANISM AND CABLE REPLACED WITH A "SELF-ADJUSTING" DESIGN.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Consequence & remedy
Consequence: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER CONTROL ARM WILL BE REPLACED.
THE HEADREST GUIDE BRACKET WAS IMPROPERLY WELDED TO THE SEAT BACK FRAME ON THE PASSENGER SIDE SEAT BACK ASSEMBLIES ONLY.
Consequence & remedy
Consequence: THE HEADREST SUPPORT BRACKET CAN BREAK, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE PASSENGER SEAT BACK ASSEMBLY WITH A NEW ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
EA99028 · Steering Shaft Binding
Opened Sep 10, 1999 · Closed Jul 26, 2001
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE99030 · Steering Shaft Binding
Opened May 3, 1999 · Closed Sep 10, 1999
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA98014 · Automatic Transaxle Ignition Interlock
Opened May 29, 1998 · Closed Sep 14, 1998
Status: closed (inferred from source dates) · Power Train
ALLEGED FAILURE OF THE AUTOMATIC TRANSAXLE IGNITION INTERLOCK SYSTEM THAT EITHER ALLOWS THE IGNITION KEY TO BE REMOVED WHEN THE TRANSMISSION GEAR SELECTOR IS NOT IN THE PARK POSITION AND THE TRANSMISSION GEAR SELECTOR TO BE SHIFTED WHEN THE IGNITION KEY IS REMOVED OR PREVENTS THEIGNITION KEY FROM BEING REMOVED WHEN THE TRANSMISSION GEAR SELECTOR IS IN THE PARK, OR ANY OTHER, POSITION.
EA97025 · Convertible Top Cover Disengagement
Opened Nov 24, 1997 · Closed Nov 17, 1998
Status: closed (inferred from source dates) · Structure
ALLEGED THAT THE CONVERTIBLE TOP COVER MAY DISENGAGE FROM THE SUBJECT VEHICLES WHILE DRIVING.
1997 Chrysler Sebring Problems, Complaints & Recalls | Skip That Year
Illustration