RECALL #750 FRONT LOWER CONTROL ARM BALL JOINT ALLEGED REPAIRED 02-10-98. THIS IS A NEW (10-08-09) RECALL. DUE TO MY VEHICLE WAS AT THE DEALER, IT WAS ASKED IF THE NUMBERS OF THE BALL JOINTS AND CONTROL ARMS NUMBERS COULD BE CHECKED TO SEE IF ORIGINAL CHRYSLER OR AFTERMARKET QUALITY PARTS WERE USED. THOUGH THIS IS A SERIOUS SAFE…
Read full complaint
RECALL #750 FRONT LOWER CONTROL ARM BALL JOINT ALLEGED REPAIRED 02-10-98. THIS IS A NEW (10-08-09) RECALL. DUE TO MY VEHICLE WAS AT THE DEALER, IT WAS ASKED IF THE NUMBERS OF THE BALL JOINTS AND CONTROL ARMS NUMBERS COULD BE CHECKED TO SEE IF ORIGINAL CHRYSLER OR AFTERMARKET QUALITY PARTS WERE USED. THOUGH THIS IS A SERIOUS SAFETY ISSUE, LOSS OF STEERING, THE SERVICE ADVISOR ADVISED I'D NEED TO CHECK THE ORIGINAL REPAIR ORDER (02-10-98). THE ORIGINAL OWNER IS DECEASED. SO I GUESS I SHOULD CRAWL UNDER THE CAR AND LOOK FOR WHEREVER THESE PARTS ARE, LET ALONE THE NUMBERS, OR PAY SOMEONE ELSE TO CHECK THEM, OR JUST HOPE CHRYSLER HAD AND USED THEIR OWN PARTS. *TR
NHTSA ODI #10294207
62,000 miles · Jan 18, 2006
Steering
DT*: THE CONSUMER STATED BOTH TIE ROD ENDS FRACTURED ON TWO SEPARATE OCCASIONS. THE FIRST TIME, WHILE BACKING OUT OF THE DRIVEWAY, THE FRONT TIRES WENT IN OPPOSITE DIRECTIONS AND THE VEHICLE WOULD NOT MOVE FORWARD OR BACKWARD. THE TIE ROD END WAS REPLACED. THE SAME FAILURE OCCURRED ON THE OTHER SIDE AND THE CONTACT REPAIRED…
Read full complaint
DT*: THE CONSUMER STATED BOTH TIE ROD ENDS FRACTURED ON TWO SEPARATE OCCASIONS. THE FIRST TIME, WHILE BACKING OUT OF THE DRIVEWAY, THE FRONT TIRES WENT IN OPPOSITE DIRECTIONS AND THE VEHICLE WOULD NOT MOVE FORWARD OR BACKWARD. THE TIE ROD END WAS REPLACED. THE SAME FAILURE OCCURRED ON THE OTHER SIDE AND THE CONTACT REPAIRED THE VEHICLE. UPON INSPECTION, IT WAS DETERMINED THE SEALED PIVOT JOINTS WERE NOT LUBRICATED AND RESULTED IN THESE FAILURES. *JB
NHTSA ODI #10147998
78,000 miles · Apr 4, 2004
Steering
TIE ROD FELL OFF. STARTED ENGINE, PROCEEDED TO PULL OUT OF PARKING PLACE AND THE TIE ROD FELL OFF. SINCE CHRYSLER NOW MAKES TIE RODS SO THAT THEY CANNOT BE LUBRICATED, THEY DRY UP AND THE END JUST DROPS OFF. I AM FORTUNATE THAT I WAS NOT DRIVING DOWN THE HIGHWAY 50 MILES AN HOUR WHEN THIS HAPPENED. THERE IS ABSOLUTELY NO FOR…
Read full complaint
TIE ROD FELL OFF. STARTED ENGINE, PROCEEDED TO PULL OUT OF PARKING PLACE AND THE TIE ROD FELL OFF. SINCE CHRYSLER NOW MAKES TIE RODS SO THAT THEY CANNOT BE LUBRICATED, THEY DRY UP AND THE END JUST DROPS OFF. I AM FORTUNATE THAT I WAS NOT DRIVING DOWN THE HIGHWAY 50 MILES AN HOUR WHEN THIS HAPPENED. THERE IS ABSOLUTELY NO FOREWARNING OF A PROBLEM UNTIL IT HAPPENS. MY MECHANIC ALSO NOTICED THAT CHRYSLER HAS INSTALLED A HEAT SHIELD BETWEEN THE TIE RODS AND BRAKES. I HAVE SAVED THE PARTS AND I HAVE NOTIFIED CHRYSLER OF THIS SITUATION. I HAVE 78,000 MILES ON MY CAR. I TRULY FEEL THAT THE TIE ROD FELL OFF DUE TO A MANUFACTURING DEFECT OR FLAWED DESIGN -- I AM NOTIFYING YOU IN THE HOPES THAT THIS WILL BE LOOKED INTO SO THAT NO ONE GETS KILLED WHILE DRIVING DOWN THE HIGHWAY. AS I SAID I WAS VERY FORTUNATE, THE NEXT PERSON OR FAMILY MAY NOT. FEEL FREE TO CONTACT ME AND IF YOU WOULD LIKE ME TO SHIP THE PARTS -- I WILL BE GLAD TO. THANK YOU. *NM
NHTSA ODI #10064535
Mileage unknown · Sep 4, 2003
SteeringSuspension
LEFT LOWER CONTROL ARM FAILED, CAUSING STEERING TO LOCK. *AK
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
1996 Chrysler Sebring Convertible Problems, Complaints & Recalls | Skip That Year
Illustration