IllustrationI HAVE HAD HUGE BREAK ISSUES. I HAD TO REPLACE THREE TIMES THE BRAKES AND ROTOR IN MY CAR. IT ONLY HAS 50,000 MILES ON IT. THE FIRST INSTANCE WAS AT 28,000. THEN 40,000....AND NOW AGAIN. I'VE BEEN READING ABOUT PT CRUISER BRAKE PROBLEMS, AND HOW PREVALENT THEY ARE. I AM SURPRISED THAT NO RECALL HAS BEEN DONE. *LN
2006 Chrysler Pt Cruiser
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Chrysler Pt Cruiser do not stand out strongly from the model-year median of 202.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pt Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
570–25K
8325–50K
6250–75K
5075–100K
42100–150K
12150K+
306 reports with mileage · 43 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 138 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
35 crash reports5 fire reports21 injury reports
Service Brakes, Air complaints
2 reportsWHILE DRIVING DOWN THE FREEWAY THE DOOR LOCKS STARTED CLICKING LIKE THEY DO WHEN HITTING THE WIRELESS REMOTE. AT THE SAME TIME THE FLASHERS WOULD GO ON. THIS CONTINUED INTERMITTENTLY ALL THE WAY TO WORK ON CITY STREETS AS WELL. I HAVE NOT CONTACTED THE DEALER AT THIS TIME. MY PASSENGER AIRBAG LIGHT WENT ON, SOMETIMES WHEN…
Read full complaint
WHILE DRIVING DOWN THE FREEWAY THE DOOR LOCKS STARTED CLICKING LIKE THEY DO WHEN HITTING THE WIRELESS REMOTE. AT THE SAME TIME THE FLASHERS WOULD GO ON. THIS CONTINUED INTERMITTENTLY ALL THE WAY TO WORK ON CITY STREETS AS WELL. I HAVE NOT CONTACTED THE DEALER AT THIS TIME. MY PASSENGER AIRBAG LIGHT WENT ON, SOMETIMES WHEN I WAS DRIVING. I TOOK THE CAR IN TO MY MECHANIC IN JANUARY FOR A COMPLETE BRAKE JOB. THE ROTORS NEEDED REPLACING. I HAD LESS THAN 10000 WHEN THE CAR WOULD SHIMMY VIOLENTLY WHEN THE BRAKES WERE APPLIED. I TOOK IT BACK TO MY MECHANIC, AND HE INFORMED ME THAT THE ROTORS WERE NOT OF A MATERIAL MADE TO WITH STAND MUCH HEAT. HE ADVISED A BEEFIER ROTOR. THERE WAS NOW A HEAVY DUTY ROTOR AVAILABLE ON THE AFTER-MARKET. I DID NOT TAKE THIS PROBLEM TO THE DEALER BECAUSE THEY MOST LIKELY WILL TELL ME I WAS TOO HARD ON THE BRAKES. IF THAT WERE THE CASE THE HONDA, WHICH HAD 107000 MILES ON IT WOULD HAVE BEEN IN FOR BRAKES SEVERAL TIMES BY NOW, IT WAS ON THE FIRST SET AND FINALLY NEEDED PADS. . ANOTHER CAR DID NOT SEE ME COMING AND PULLED OUT IN FRONT OF ME. WHEN I WENT TO HIT THE HORN IT WOULD NOT HONK. I HAD TO REPOSITION MY HAND SEVERAL TIMES TO FIND THE RIGHT SPOT AND THEN PUSH VERY HARD. I PLANNED TO GET RID OF THIS CAR AND NEVER PURCHASE ANOTHER AMERICAN CAR AGAIN. I HAVE ALWAYS HAD NOTHING BUT TROUBLE WITH THEM. * AK
Official recalls
107V149000 · Visibility:glass, Side/rear
Apr 4, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR QUARTER GLASS ATTACHING FASTENERS MAY PULL THROUGH THEIR MOUNTS AND ALLOW THE GLASS TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: IF THE GLASS SEPARATES WHILE DRIVING, IT COULD STRIKE ANOTHER VEHICLE OR INJURE A PEDESTRIAN.
Remedy: DEALERS WILL REPLACE THE REAR QUARTER GLASS. THE RECALL BEGAN ON APRIL 30, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07004 · Rear Quarter Panel Glass Separation
Opened Feb 16, 2007 · Closed Apr 5, 2007
Status: closed (inferred from source dates) · Visibility:glass, Side/rear
DAIMLERCHRYSLER CORPORATION (DCC) WILL RECALL MODEL YEAR 2005 AND 2006 PT CRUISER VEHICLES PRODUCED FROM 5/17/05 THROUGH 9/1/05 TO CORRECT A POTENTIAL DEFECT IN THE REAR QUARTER PANEL GLASS THAT MAY SEPARATE FROM THE VEHICLE.DCC WILL INSPECT THE REAR QUARTER PANEL GLASS AND REPLACE IF NECESSARY.DCC WILL BEGIN NOTIFYING OWNERS IN MAY 2007. VEHICLES PRODUCED PRIOR TO AND AFTER THE ABOVE BUILD DATES ARE NOT AFFECTED.A CHANGE MADE BY THE ASSEMBLY PLANT IN MAY 2005 THAT MODIFIED THE GLASS ATTACHMENT LED TO THE POTENTIAL FOR GLASS SEPARATION.IN SEPTEMBER 2005, SUBSEQUENT CHANGES TO THE PROCESS WERE MADE TO CORRECT THIS.THIS ENGINEERING ANALYSIS IS CLOSED.SEE RECALL 07V149 FOR ADDITIONAL DETAILS.
PE06046 · Rear Quarter Panel Glass Separation
Opened Oct 20, 2006 · Closed Feb 16, 2007
Status: closed (inferred from source dates) · Visibility:glass, Side/rear
ODI HAS RECEIVED REPORTS THAT THE EITHER THE LEFT OR THE RIGHT REAR QUARTER PANEL GLASS FALLS OFF THE VEHICLE.SOME REPORTS INDICATE THAT THE GLASS FELL OFF THE VEHICLE WHILE IN MOTION AND STRUCK A FOLLOWING VEHICLE.IN SOME CASES DAMAGE TO THE FOLLOWING VEHICLE WAS REPORTED.THE COMPLAINT AND WARRANTY DATA ARE CONCENTRATED WITHIN A PARTICULAR BUILD DATE RANGE FROM MAY TO JUN OF 2005 FOR MY 2005 VEHICLES AND JULY TO SEP OF 2005 FOR MY 2006 VEHICLES.THIS PRELIMINARY EVALUATION (PE) IS UPGRADED TO EA07-004.