APPROXIMATELY 10-12 DAYS AFTER PURCHASING THE VEHICLE, ALL FOUR TIRES BEGAN TO GET FLAT. THIS HAS OCCURRED EVERY TWO WEEKS SINCE THAT TIME. EVERY TIME I FILL THE CAR WITH FUEL, I HAVE TO PUT AIR IN ALL FOUR TIRES. I CONTACTED CHRYSLER ONLINE IN EARLY FEBRUARY 2012 AND RECEIVED A RATHER FLIP RESPONSE... THANKING ME FOR TELLING…
Read full complaint
APPROXIMATELY 10-12 DAYS AFTER PURCHASING THE VEHICLE, ALL FOUR TIRES BEGAN TO GET FLAT. THIS HAS OCCURRED EVERY TWO WEEKS SINCE THAT TIME. EVERY TIME I FILL THE CAR WITH FUEL, I HAVE TO PUT AIR IN ALL FOUR TIRES. I CONTACTED CHRYSLER ONLINE IN EARLY FEBRUARY 2012 AND RECEIVED A RATHER FLIP RESPONSE... THANKING ME FOR TELLING THEM ABOUT THE PROBLEM, BUT OFFERING NO FIX TO THE PROBLEM. THIS IS MY SECOND PT CRUISER.. AND I HAD THE SAME PROBLEM WITH MY FIRST CRUISER. AFTER FURTHER INVESTIGATION, I HAVE DISCOVERED THIS IS A VERY COMMON PROBLEM DUE TO THE ALUMINUM WHEELS CAUSING AIR TO LEAK FROM THE TIRES. I ENJOY MY PT CRUISER, BUT FEEL THERE SHOULD BE A FIX FOR THIS PROBLEM, OTHER THAN BUYING EXPENSIVE NEW WHEELS; ESPECIALLY BECAUSE THEY ARE AWARE OF THE PROBLEM. ANY HELP IN THIS MATTER WILL BE GREATLY APPRECIATED. IT NOT ONLY GIVES ME BAD GAS MILEAGE, BUT ALSO IS A SAFETY HAZARD. *TR
NHTSA ODI #10505165
Mileage unknown · Jul 24, 2012
StructureWheels
WHEELS PEEL AND CORRODE. MAKES TIRES FLAT CONSTANTLY. TIRES WILL NOT KEEP AIR. MAKES TIRES WEAR OUT OFTEN AND THEY HAVE TO BE REPLACE. *TR
NHTSA ODI #10467572
Mileage unknown · Nov 8, 2010
Wheels
2004 CHRYSLER PT CRUISER. STATED ISSUE WHEN I FIRST PICKED UP CAR, CONTINUED LOSING AIR IN ALL FOUR TIRES. LOSS OF PRESSURE IN VEHICLE TIRES. THE ROOT CAUSE OF THE TIRE LEAKAGE WAS BECAUSE THE COATING ON THE ORIGINAL EQUIPMENT WHEEL RIMS WAS DETERIORATING AND NOT PERMITTING AN AIR TIGHT SEAL. I HAVE GONE THROUGH SEVERAL SETS OF…
Read full complaint
2004 CHRYSLER PT CRUISER. STATED ISSUE WHEN I FIRST PICKED UP CAR, CONTINUED LOSING AIR IN ALL FOUR TIRES. LOSS OF PRESSURE IN VEHICLE TIRES. THE ROOT CAUSE OF THE TIRE LEAKAGE WAS BECAUSE THE COATING ON THE ORIGINAL EQUIPMENT WHEEL RIMS WAS DETERIORATING AND NOT PERMITTING AN AIR TIGHT SEAL. I HAVE GONE THROUGH SEVERAL SETS OF TIRES AND RIMS ARE NOW CRACKING. *TR
NHTSA ODI #10364976
40,000 miles · Sep 25, 2010
EquipmentWheels
FRONT WHEEL BEARINGS AND HUBS ARE DEFECTIVE. THIS IS THE SECOND TIME I HAVE HAD THEM REPLACED AT 600.00 DOLLARS AT A TIME. THE FIRST TIME WAS AT AROUND 40,000 MILES. THIS TIME AT 120,000 MILES. THIS IS NOT NORMAL WEAR. *TR
NHTSA ODI #10357487
Mileage unknown · Jul 12, 2010
Wheels
2004 CHRYSLER PT CRUISER. CONSUMER STATES CONCERN REGARDING LOSS OF PRESSURE IN VEHICLE TIRES *TGW THE CONSUMER STATED THE ROOT CAUSE OF THE TIRE LEAKAGE WAS BECAUSE THE COATING ON THE ORIGINAL EQUIPMENT WHEEL RIMS WAS DETERIORATING AND NOT PERMITTING AN AIR TIGHT SEAL. *JB
NHTSA ODI #10342234
43,000 miles · Mar 21, 2009
Wheels
THE FRONT WHEEL BEARING OF OUR CHRYSLER PT CRUISER HAVE HAD REPEATED PROBLEMS AND HAD TO BE REPLACED TWICE IN A PERIOD OF LESS THAN 24 MONTHS. THE CAR IS A 2004 MODEL AND HAS ONLY 43K MILES. THE FIRST TIME AROUND BOTH BEARINGS HAD TO BE REPLACED. THE SECOND TIME THE DRIVER SIDE BEARINGS ARE ROCKING AND WILL NEED TO BE REPLAC…
Read full complaint
THE FRONT WHEEL BEARING OF OUR CHRYSLER PT CRUISER HAVE HAD REPEATED PROBLEMS AND HAD TO BE REPLACED TWICE IN A PERIOD OF LESS THAN 24 MONTHS. THE CAR IS A 2004 MODEL AND HAS ONLY 43K MILES. THE FIRST TIME AROUND BOTH BEARINGS HAD TO BE REPLACED. THE SECOND TIME THE DRIVER SIDE BEARINGS ARE ROCKING AND WILL NEED TO BE REPLACED. *TR
NHTSA ODI #10262643
Mileage unknown · Aug 12, 2008
Wheels
WE OWN A 2004 CHRYSLER PT CRUISER GT WHICH WE BOUGHT NEW. THE PROBLEM STARTED APPROXIMATELY AT 33,000 MILES AND IS STILL ONGOING. WE TOOK THE CAR TO OUR TIRE DEALER TO FIND OUT WHAT WAS CAUSING THE LEAKAGE AND THEY DISCOVERED THAT IT WAS CAUSED BY THE FLAKING OFF OF THE CHROME ALLOY ON THE WHEELS. THE DEALER REPLACED TH…
Read full complaint
WE OWN A 2004 CHRYSLER PT CRUISER GT WHICH WE BOUGHT NEW. THE PROBLEM STARTED APPROXIMATELY AT 33,000 MILES AND IS STILL ONGOING. WE TOOK THE CAR TO OUR TIRE DEALER TO FIND OUT WHAT WAS CAUSING THE LEAKAGE AND THEY DISCOVERED THAT IT WAS CAUSED BY THE FLAKING OFF OF THE CHROME ALLOY ON THE WHEELS. THE DEALER REPLACED THE ONE WHEEL THAT WAS DEFECTIVE WHICH WAS JUST AFTER THE WARRANTY EXPIRED, AND NOW AT 43,000 MILES WE HAVE AT LEAST TWO MORE DOING THE SAME THING. WE CONTACTED THE DEALER AGAIN AND AFTER ABOUT TWO MONTHS THEY FINALLY SAID THEY WOULD NOT REPLACE THE OTHER WHEELS AFTER TALKING WITH THE CHRYSLER REPRESENTATIVE. THIS IS A VERY UNSAFE SITUATION AS A TIRE WILL HEAT UP WHEN IT SLOWLY LOSES AIR AND COULD FAIL AT HIGH SPEED AND POSSIBLY CAUSE A LIFE THREATENING SITUATION. I HAVE LEARNED THIS BY EXPERIENCE AS A TRUCK DRIVER WHEN I HAD A SLOW LEAK IN A WHEEL ON THE STEERING AXLE AND IT EXPLODED ON MY TRUCK AT LEAST FOUR DIFFERENT TIMES UNTIL WE FINALLY FOUND THE TINY LEAK IN THE CHROME WHEEL. THE DEALER'S SERVICE DEPARTMENT WOULD NOT GIVE ME THE NUMBER OR NAME OF WHO HE TALKED TO AS HE SAID IT WAS COMPANY POLICY NOT TO GIVE THESE OUT. HE ALSO DID NOT KNOW WHO THE MANUFACTURER OF THE WHEEL WAS AND HE WOULD HAVE TO FIND OUT FROM THE PARTS DEPT. THIS OF COURSE UPSET ME AND I RAISED MY VOICE TO HIM AND HE SAID THAT IF I KEPT YELLING AT HIM HE WOULD REFUSE TO HELP ME AT ALL. THIS WAS DONE ALL BY PHONE ON 8-11 08
NHTSA ODI #10237789
42,000 miles · Apr 18, 2008
Wheels
STOCK CHRYSLER 17" CHROME ALUMINUM WHEELS ARE DEFECTIVE. THEY ARE RUSTING FROM THE INSIDE OUT CAUSING THE TIRE TO LOSE AIR PRESSURE. WAS TAKE TO THE DEALERSHIP TO GET INSPECTED - AFTER WHICH I WAS TOLD THAT CHRYSLER DOES NOT WARRANTY DEFECTIVE MATERIALS IF THE VEHICLE IS OVER 3 YEARS OLD OR HAS MORE THAN 36,000 MILES. EVEN TH…
Read full complaint
STOCK CHRYSLER 17" CHROME ALUMINUM WHEELS ARE DEFECTIVE. THEY ARE RUSTING FROM THE INSIDE OUT CAUSING THE TIRE TO LOSE AIR PRESSURE. WAS TAKE TO THE DEALERSHIP TO GET INSPECTED - AFTER WHICH I WAS TOLD THAT CHRYSLER DOES NOT WARRANTY DEFECTIVE MATERIALS IF THE VEHICLE IS OVER 3 YEARS OLD OR HAS MORE THAN 36,000 MILES. EVEN THOUGH I HAVE AN EXTENDED WARRANTY FOR 7 YEARS/85,000 MILES. AN THE ROTTING FROM THE INSIDE OF THE RIM IS NOT LIMITED TO A SPECIFIC TO THE VEHICLE OF CHRYSLER'S PRODUCTION. IT EFFECTS ALL MAKES AN MODELS WITH THE CHROMED ALUMINUM RIMS. SEBRING - PT CRUISER - PACFICA - ETC. AN GIVING THE FACT THE RIMS DON'T HOLD AIR I BELIEVE THAT COULD BE A MAJOR SAFETY ISSUE BECAUSE THAT EFFECT THE HANDLING AN BRAKING WHICH COULD CAUSE THE CAR TO LOSE CONTROL. CHRYSLER IS STILL CURRENTLY SELL'S THE SAME PRODUCT ON THERE NEW CARS. EVEN THOUGH THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT THE WHEELS AN THERE DEFECT. BUT DO TO THE FACT THAT BY THE TIME THE CUSTOMER NOTICES THERE RIMS ARE DEFECTIVE THE 3 YEARS/36,000 MILES IS UP. AN THE CUSTOMER WHO BOUGHT THE CAR IS TOLD THEY AREN'T UNDER WARRANTY BUT IF YOU WOULD LIKE TO ORDER A NEW SET THEY WOULD BE HAPPY TO DO SO AT THE EXPENSE OF THE OWNER'S POCKET BOOK. I BELIEVE CHRYSLER PRACTICE'S ARE WRONG ON HOW THEY OPERATE - BY SELLING THE CUSTOMER WHAT IS ULTIMATELY DEFECTIVE MATERIALS. I HAVE TALKED WITH OTHER CHRYSLER VEHICLE OWNER'S WITH THE CHROME ALUMINUM RIMS AN HAVE TOLD ME THEY FOUGHT CHRYSLER AN THAT THEY TOO HAVE TO REPLACE AIR IN THE TIRE EVERY OTHER DAY LIKE MYSELF. P.S. DUE TO THE DEFECTIVE RIMS I AM REQUIRED TO PUT ATLEAST 20+ PSI IN MY TIRES EVERY OTHER DAY. *TR
NHTSA ODI #10224942
68,000 miles · Dec 19, 2006
Wheels
TL* - THE CONTACT HAS A 2004 PT CRUISER, THE CHROME IS LIFTING OFF THE WHEEL. THE DEALERSHIP SAID THERE IS NOTHING THEY CAN DO ABOUT IT AND ADVISED HIM TO CALL NHTSA HOTLINE TO FILE A COMPLAINT. THE CHROME WAS NOTICEABLE WHEN HE PURCHASED THE CAR. THE AUTOMOBILE IS TWO YEARS OLD AND HE IS THE SECOND OWNER.
NHTSA ODI #10176595
600 miles · Mar 27, 2006
Fuel System, GasolineLatches/locks/linkagesTires
DT*: THE CONTACT STATED THE TIRES ON THE VEHICLE CONTINUALLY LOST AIR. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION NUMEROUS TIMES. THE DEALER REPLACED ALL 4 TIRES AND A RIM; HOWEVER, THE PROBLEM STILL PERSISTED. ALSO, THE VEHICLE MANIFESTED REMOTE CONTROL PROBLEMS, AS WELL A CRACKED WINDSHIELD A BROKEN GAS TANK. I…
Read full complaint
DT*: THE CONTACT STATED THE TIRES ON THE VEHICLE CONTINUALLY LOST AIR. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION NUMEROUS TIMES. THE DEALER REPLACED ALL 4 TIRES AND A RIM; HOWEVER, THE PROBLEM STILL PERSISTED. ALSO, THE VEHICLE MANIFESTED REMOTE CONTROL PROBLEMS, AS WELL A CRACKED WINDSHIELD A BROKEN GAS TANK. IN ADDITION RACK AND PINION STEERING WAS DEFECTIVE, AND POWER STEERING FLUID WAS LEAKING. *AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
2004 Chrysler Pt Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration