IllustrationFRONT WHEEL BEARING REPLACE TWO TIMES. *TR
2004 Chrysler Pt Cruiser
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Chrysler Pt Cruiser do not stand out strongly from the model-year median of 202.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pt Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
390–25K
3825–50K
3550–75K
2175–100K
23100–150K
8150K+
164 reports with mileage · 53 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports15 fire reports14 injury reports
Suspension complaints
36 reports2004 PT CRUISER, MULTIPLE WHEEL BEAR FAILURES IN LESS THAN 80K MILES 1ST AT APPROX 40K AND SECOND AT APPROX 80K. BOTH TIMES LEFT SIDE FRONT WHEEL BEARING. *TR
WHEEL BEARING ON 2004 PT CRUISER WITH 28,000 WENT BAD. *TR
FRONT PASSENGER SIDE WHEEL BEARING IS BAD. STARTED ABOUT 31,000 MILES. I TOOK THE CAR TO THE DEALER THINKING IT'S COVERED UNDER THE 7 YEAR, 70,000 MILE POWERTRAIN WARRANTY! AS I READ THE WARRANTY, IT STATES EVERY THING IS COVERED. BUT THE DEALER SAYS IT A WEAR PART! I DON'T UNDERSTAND WHY A WHEEL BEARING GOES BAD THIS EARLY AND …
Read full complaint
FRONT PASSENGER SIDE WHEEL BEARING IS BAD. STARTED ABOUT 31,000 MILES. I TOOK THE CAR TO THE DEALER THINKING IT'S COVERED UNDER THE 7 YEAR, 70,000 MILE POWERTRAIN WARRANTY! AS I READ THE WARRANTY, IT STATES EVERY THING IS COVERED. BUT THE DEALER SAYS IT A WEAR PART! I DON'T UNDERSTAND WHY A WHEEL BEARING GOES BAD THIS EARLY AND WHY THEY DON'T COVER IT AS A POWERTRAIN PART? AND THE PRICE TO REPAIR IT IS OVER 600.00. I JUST CAN'T STAND TO BRING MYSELF TO PAY FOR THIS, AS IF I COULD AFFORD IT . AND AFTER SOME RESEARCH I'M FINDING OUT THAT ALOT OF CONSUMERS ARE GETTING SCREWED BY THE MANUFACTURER BECAUSE OF A DEFECT IN THE DESIGN AND WEIGHT ISSUE OF THE FRAME AND BODY STYLE. *TR
BOTH FRONT WHEEL BEARINGS ON MY WIFE'S 2004 PT CRUSER WITH LESS THAN 40K MILES WENT BAD. *TR
WHILE DRIVING MY 2004 CHRYSLER PT CRUISER, I STARTED HEARING A GRINDING NOISE COMING FROM THE FRONT END OF THE CAR. IN JUST A MATTER OF DAYS I COULD TELL IT WAS GETTING LOUDER. I THOUGHT IT MIGHT BE THE BRAKES BUT I JUST HAD THE FRONT BRAKES REPLACED 6,000 MILES EARLIER. I TOOK IT TO THE MECHANIC WHERE I HAD THE BRAKES DONE AND …
Read full complaint
WHILE DRIVING MY 2004 CHRYSLER PT CRUISER, I STARTED HEARING A GRINDING NOISE COMING FROM THE FRONT END OF THE CAR. IN JUST A MATTER OF DAYS I COULD TELL IT WAS GETTING LOUDER. I THOUGHT IT MIGHT BE THE BRAKES BUT I JUST HAD THE FRONT BRAKES REPLACED 6,000 MILES EARLIER. I TOOK IT TO THE MECHANIC WHERE I HAD THE BRAKES DONE AND AFTER CHECKING THE CAR HE TOLD ME THE PROBLEM WAS THE LEFT FRONT WHEEL BEARINGS. IT COST ME $556.23 TO REPLACE THE FRONT LEFT HUB AND THE BEARINGS ON BOTH FRONT WHEELS. AFTER THE REPAIR, HE SHOWED ME THE OLD HUB AND BEARINGS. THE PART WAS BROKEN AND SEVERAL OF THE BEARINGS WERE MISSING. HE SAID IF I HAD CONTINUED TO DRIVE THE CAR IN THAT CONDITION, IT WAS VERY LIKELY THE FRONT LEFT WHEEL WOULD FALL OFF, POSSIBLY CAUSING SERIOUS INJURY OR DEATH. THIS IS A SERIOUS SAFETY ISSUE AND I BELIEVE CHRYSLER NEEDS TO ISSUE A RECALL FOR THIS PROBLEM. THERE IS ONLY 28,560 MILES ON THIS VEHICLE. THERE IS NO WAY A CAR WITH THIS MANY MILES SHOULD BE HAVING THIS KIND OF PROBLEM. *TR
EXPERIENCED FRONT DRIVER SIDE WHEEL BEARING AND HUB FAILURE - REPLACED AT COST OF $350. INSPECTION DURING THIS REPAIR REVEALED THAT THE FRONT LOWER CONTROL ARM BUSHINGS HAD DETERIORATED AND WERE IN NEED OF REPLACEMENT AS WELL - PUT OFF $600 REPAIR UNTIL LATER DATE. 56,000 MILES 2004 PT CRUISER LIMITED. *CN
PURCHASED 2004 CHRYSLER PT CRUISER, USED WITH 31K MILES IN MAY, 2007. IN ABOUT JULY/AUGUST 2007, NOTICED A GRINDING NOISE WHEN MAKING A RIGHT TURN. IT GRADUALLY GOT WORSE AND BECAME NOTICEABLE WHEN THE CAR WAS GOING STRAIGHT AS WELL. IT FELT LIKE THE FRONT END WAS OUT OF ALIGNMENT. ON EXAMINATION AT DEALER, THEY HAVE INFORME…
Read full complaint
PURCHASED 2004 CHRYSLER PT CRUISER, USED WITH 31K MILES IN MAY, 2007. IN ABOUT JULY/AUGUST 2007, NOTICED A GRINDING NOISE WHEN MAKING A RIGHT TURN. IT GRADUALLY GOT WORSE AND BECAME NOTICEABLE WHEN THE CAR WAS GOING STRAIGHT AS WELL. IT FELT LIKE THE FRONT END WAS OUT OF ALIGNMENT. ON EXAMINATION AT DEALER, THEY HAVE INFORMED ME THAT BOTH FRONT WHEEL BEARINGS ARE BAD AND MUST BE REPLACED. *TR
FRONT WHEEL BEARINGS FAILURE BEFORE 40,000 MILES ON ODOMETER. *TR
TL*THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. WHILE DRIVING 45 MPH, THE CONTACT HEARD AN EXTREMELY LOUD NOISE. HE INSPECTED THE UNDERCARRIAGE AND NOTICED THAT THE INNER WHEEL BEARING FAILED ON THE FRONT DRIVER SIDE WHEEL. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER AND NO REPAIRS WERE MADE. THE CURRENT AND FAILURE …
Read full complaint
TL*THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. WHILE DRIVING 45 MPH, THE CONTACT HEARD AN EXTREMELY LOUD NOISE. HE INSPECTED THE UNDERCARRIAGE AND NOTICED THAT THE INNER WHEEL BEARING FAILED ON THE FRONT DRIVER SIDE WHEEL. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER AND NO REPAIRS WERE MADE. THE CURRENT AND FAILURE MILEAGES WERE 40,318.
Official recalls
104V268000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.