ROUGH IDLE AT STOPPED INTERSECTIONS, LUNGES AND STALLS. STALLS A APPROXIMATELY 15-25 MPH WHILE MAKING LEFT OR RIGHT TURNS MAKING IT VERY DIFFICULT TO TURN WHILE PLACING THE VEHICLE IN NEUTRAL AND STARTING THE ENGINE AGAIN. THE FOG LIGHTS TURN ON BY ITSELF AFTER THE VEHICLE IS PARKED AND THE IGNITION IS TURNED OFF DRAINING THE …
Read full complaint
ROUGH IDLE AT STOPPED INTERSECTIONS, LUNGES AND STALLS. STALLS A APPROXIMATELY 15-25 MPH WHILE MAKING LEFT OR RIGHT TURNS MAKING IT VERY DIFFICULT TO TURN WHILE PLACING THE VEHICLE IN NEUTRAL AND STARTING THE ENGINE AGAIN. THE FOG LIGHTS TURN ON BY ITSELF AFTER THE VEHICLE IS PARKED AND THE IGNITION IS TURNED OFF DRAINING THE BATTERY. HAD TO DISCONNECT THE FUSE IN ORDER TO PREVENT THIS FROM HAPPENING AGAIN. TO THIS DATE NON-FUNCTIONAL FOG LIGHTS. THE VEHICLE HAS SEVERAL ELECTRICAL PROBLEMS FROM INSTRUMENT CLUSTER NOT FUNCTIONING WHILE DRIVING TO RADIO AND CLIMATE CONTROL NOT WORKING UNTIL YOU STOP THE VEHICLE AND TURN IT OFF. THEN START THE VEHICLE AGAIN THEN IT WORKS PROPERLY FOR ANOTHER FEW DAYS. THIS IS A RECURRING PROBLEM. WHEEL BEARING HAS BEEN AN ISSUE TOO AND CURRENTLY NEEDS TO BE REPLACED. *TR
NHTSA ODI #10576869
59,585 miles · Apr 8, 2008
Fuel System, Gasoline
THE FUEL LINE CLIP FELL OFF ALLOWING GASOLINE TO SPILL ONTO LOWER PART OF THE ENGINE. THE CAR WOULD NOT RUN AND WAS TOWED TO A CHRYSLER DEALER AND REPAIRED BY PUTTING ON A NEW "REVISED" FUEL LINE CLIP. THE OLD PART WAS NOT ON THE CAR WHEN THE FAILURE OCCURRED. *TR
NHTSA ODI #10223694
Mileage unknown · Mar 13, 2008
Fuel System, Gasoline
SINCE MY PURCHASE OF THIS 2004 PT CRUISER LESS THAN 5 MONTHS AGO, CAR CONTINUOUSLY LURCHES AT STOP LIGHTS, AND IF I DID NOT HAVE BRAKE COMPLETELY DEPRESSED WOULD RESULT IN AN ACCIDENT. ALSO, WHEN ACCELERATING VERY SLUGGISH AS IF IT IS NOT GETTING ANY GAS FOR A PERIOD OF TIME..... *TR
NHTSA ODI #10221031
22,530 miles · Nov 30, 2006
Fuel System, Gasoline
ON OCTOBER 4, 2006, I HAD NOTICED THAT MY FUEL GAUGE ON THE PT CRUISER WAS STILL READING FULL AND I KNEW AFTER DRIVING IT FOR A WEEK IT SHOULD BE READING EMPTY. I ALSO NOTICED THAT WHEN I ACCELERATED, THE GAUGE READ "FULL" BUT WHEN I PUT ON THE BRAKES IT WOULD READ "EMPTY"; IT EVEN READ 1/2 FULL A COUPLE OF TIMES. ON OCTOBER 5,2…
Read full complaint
ON OCTOBER 4, 2006, I HAD NOTICED THAT MY FUEL GAUGE ON THE PT CRUISER WAS STILL READING FULL AND I KNEW AFTER DRIVING IT FOR A WEEK IT SHOULD BE READING EMPTY. I ALSO NOTICED THAT WHEN I ACCELERATED, THE GAUGE READ "FULL" BUT WHEN I PUT ON THE BRAKES IT WOULD READ "EMPTY"; IT EVEN READ 1/2 FULL A COUPLE OF TIMES. ON OCTOBER 5,2006, I TOOK THE CAR BACK TO DAVE DENNIS CHRYSLER JEEP AND DODGE TO HAVE IT REPAIRED. ACCORDING TO THE WORKORDER, THE DEALER REPLACED THE "FUEL SENDING UNIT". AT THAT TIME, I HAD ALSO ASKED FOR THEIR FREE 16 POINT CHECK WHICH INVOLVES CHECKING FLUID LEVELS AND TIRE AIR PRESSURE, ETC. THIS SERVICE WAS NOT PERFORMED BECAUSE THE NEXT MORNING WE HAD TO STOP FROM OUR ROAD TRIP TO PUT AIR IN ALL 4 TIRES. THE FRONT PASSENGER ONLY HAD 10PSI IN IT. ON OCTOBER 27, 2006 I HAD TO RETURN THE CAR TO THE DEALER AGAIN AFTER I HAD FILLED THE GAS TANK TO CAPACITY. THE FUEL GUAGE WAS ONLY READING 3/4 FULL. ONCE AGAIN THEY REMOVED AND REPLACED THE "FUEL SENDING UNIT". I HAVE ALSO HAD PROBLEMS WITH THE HATCH DOOR ON THE PT. YOU HAVE TO USE MORE THAN NORMAL FORCE TO MAKE SURE IT IS CLOSED SECURELY. IF YOU USE REGULAR FORCE TO CLOSE THE HATCH, THE DOOR IS FLUSHED WITH THE REST OF THE CAR BUT THE SENSOR LIGHT COMES ON STATING THAT THE DOOR IS NOT CLOSED CORRECTLY. I HAVE NOTICED THAT ALONG THE STRESS POINTS ON THE HATCH DOOR THE PAINT HAD CRACKED. THE BODY SHOP SANDED AND REPAINTED THE DOOR BUT SAID THE FORCE USED TO SHUT THE DOOR IS A "FACTORY" ISSUE. *NM
NHTSA ODI #10174812
600 miles · Mar 27, 2006
Fuel System, GasolineLatches/locks/linkagesTires
DT*: THE CONTACT STATED THE TIRES ON THE VEHICLE CONTINUALLY LOST AIR. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION NUMEROUS TIMES. THE DEALER REPLACED ALL 4 TIRES AND A RIM; HOWEVER, THE PROBLEM STILL PERSISTED. ALSO, THE VEHICLE MANIFESTED REMOTE CONTROL PROBLEMS, AS WELL A CRACKED WINDSHIELD A BROKEN GAS TANK. I…
Read full complaint
DT*: THE CONTACT STATED THE TIRES ON THE VEHICLE CONTINUALLY LOST AIR. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION NUMEROUS TIMES. THE DEALER REPLACED ALL 4 TIRES AND A RIM; HOWEVER, THE PROBLEM STILL PERSISTED. ALSO, THE VEHICLE MANIFESTED REMOTE CONTROL PROBLEMS, AS WELL A CRACKED WINDSHIELD A BROKEN GAS TANK. IN ADDITION RACK AND PINION STEERING WAS DEFECTIVE, AND POWER STEERING FLUID WAS LEAKING. *AK
NHTSA ODI #10153791
Mileage unknown · Jan 27, 2005
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
THE CONSUMER PT CRUISER TRIP METER CONSTANTLY RESET ITSELF, WHEN THIS HAPPENS THE DASH LIGHTS FLASH ON AND OFF, GAS GAUGE DROPS TO EMPTY AND THE BELLS START BEEPING. *BF THE MECHANIC SPRAYED STATIC GUARD IN IT THAT TIME TO RESOLVE THE ISSUE, BUT THIS DID NOT WORK. THE CONSUMER WAS TOLD THAT THE PROBLEM WAS WITH THE CLOTH SE…
Read full complaint
THE CONSUMER PT CRUISER TRIP METER CONSTANTLY RESET ITSELF, WHEN THIS HAPPENS THE DASH LIGHTS FLASH ON AND OFF, GAS GAUGE DROPS TO EMPTY AND THE BELLS START BEEPING. *BF THE MECHANIC SPRAYED STATIC GUARD IN IT THAT TIME TO RESOLVE THE ISSUE, BUT THIS DID NOT WORK. THE CONSUMER WAS TOLD THAT THE PROBLEM WAS WITH THE CLOTH SEATS AND TO GET OUT AND GRAB THE METAL BAR. THE GEAR SHIFTER KNOB WOULD COME OFF, THERE WAS A GRINDING NOISE IN THE REAR DUE TO THE BRAKES, IT WAS HARD FOR THE CONSUMER TO GET OUT OF THE VEHICLE AT TIME BECAUSE THE LOCK AND TUMBLERS WERE STICKING, THE ENGINE WOULD KNOCK INTERMITTENTLY DURING ACCELERATION AND WOULD ONLY GET 12.9 MILES TO THE GALLON AND WOULD RUN ROUGH INTERMITTENTLY, AND THE GAUGES WOULD QUIT WORKING AT TIMES. *SC
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
2004 Chrysler Pt Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration