NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
44 reportsClear category filter30,000 miles · Apr 7, 2015
Electrical SystemExterior LightingFire
TL* THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. WHILE DRIVING AT 35 MPH, THE LEFT TURN SIGNAL WAS ACTIVATED AND THE CONTACT NOTICED SMOKE COMING FROM THE LEFT TURN SIGNAL SWITCH NEAR THE INSTRUMENT PANEL. IN ADDITION, THE CONTACT STATED THAT THE FOG LIGHTS REMAINED ILLUMINATED AND THE CONTACT HAD TO LIFT THE STEERING WHEEL UPWA…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. WHILE DRIVING AT 35 MPH, THE LEFT TURN SIGNAL WAS ACTIVATED AND THE CONTACT NOTICED SMOKE COMING FROM THE LEFT TURN SIGNAL SWITCH NEAR THE INSTRUMENT PANEL. IN ADDITION, THE CONTACT STATED THAT THE FOG LIGHTS REMAINED ILLUMINATED AND THE CONTACT HAD TO LIFT THE STEERING WHEEL UPWARDS IN ORDER TO ENGAGE THE HORN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURES RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 30,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10704194
60,000 miles · Oct 2, 2014
Electrical SystemExterior LightingFire
THE MULTIFUNCTION TURN SIGNAL SWITCH STARTED TO SMOKE AND WE COULDN'T TURN OFF THE FOG LIGHTS. WE HAD TO PULL THE FUSE SINCE THERE CONTINUED TO COME SMOKE OUT OF THAT SWITCH -- WE HAD TO OPEN THE WINDOWS TO DRIVE HOME IN ORDER TO GET RID OF THE SMELL/SMOKE. OUR CHRYSLER DEALER SAID THAT THIS PART IS IN HIGH DEMAND. THE PART WAS …
Read full complaint
THE MULTIFUNCTION TURN SIGNAL SWITCH STARTED TO SMOKE AND WE COULDN'T TURN OFF THE FOG LIGHTS. WE HAD TO PULL THE FUSE SINCE THERE CONTINUED TO COME SMOKE OUT OF THAT SWITCH -- WE HAD TO OPEN THE WINDOWS TO DRIVE HOME IN ORDER TO GET RID OF THE SMELL/SMOKE. OUR CHRYSLER DEALER SAID THAT THIS PART IS IN HIGH DEMAND. THE PART WAS $275 AND A SIMILAR HIGH AMOUNT FOR LABOR THE FIRST TIME. FROM THAT TIME ON I ORDERED ONLINE AND REPLACED THE SWITCH TWO MORE TIMES. TODAY, 10/01/2014, THE SWITCH STARTED TO SMOKE AGAIN. THIS WOULD BE THE FOURTH SWITCH. THIS IS A KNOWN PROBLEM AND SHOULD BE A RECALL SINCE IT CAN CAUSE A FIRE AND DRAIN THE BATTERY. *TR
NHTSA ODI #10640693
114,100 miles · Sep 3, 2014
Electrical System
WHEN I TURN THE KEY SWITCH MY RADIO COME ON AND THEN GO OFF. *TR
NHTSA ODI #10630505
145,000 miles · Apr 30, 2014
Electrical SystemEngine
DRIVING ON FREEWAY WHEN ALL THE ENGINE LIGHTS ON THE DASH LIGHT UP, FLICKER, THEN GO DEAD. THEN THE CAR LOSES POWER, INCLUDING STEERING AND BRAKES AND CANNOT BE CONTROLLED. IT WILL START AGAIN LATER AND WILL BE OK FOR A FEW DAYS OR WEEKS WHEN THE PROBLEM RE-OCCURS. NEITHER AN INDEPENDENT MECHANIC NOR CHRYSLER CAN FIND THE PROBL…
Read full complaint
DRIVING ON FREEWAY WHEN ALL THE ENGINE LIGHTS ON THE DASH LIGHT UP, FLICKER, THEN GO DEAD. THEN THE CAR LOSES POWER, INCLUDING STEERING AND BRAKES AND CANNOT BE CONTROLLED. IT WILL START AGAIN LATER AND WILL BE OK FOR A FEW DAYS OR WEEKS WHEN THE PROBLEM RE-OCCURS. NEITHER AN INDEPENDENT MECHANIC NOR CHRYSLER CAN FIND THE PROBLEM. IT HAPPENS WITHOUT WARNING AT ANY SPEED AND CIRCUMSTANCE. I MANAGED TO GET VIDEO DURING ONE SUCH EPISODE ON SURFACE STREETS. THIS IS SIMILAR TO THE PROBLEM GM IS HAVING AND SHOULD LEAD TO A RECALL BEFORE ANYONE IS KILLED. I CAN'T IN GOOD CONSCIENCE SELL THE CAR, AND AM AFRAID TO DRIVE IT BUT HAVE NO CHOICE. THIS HAS HAPPENED TO MANY OTHER PT CRUISER OWNERS AND CHRYSLER HAS TURNED A DEAF EAR TO THE PROBLEM. *JS
NHTSA ODI #10585666
Mileage unknown · Apr 2, 2014
Electrical SystemEngineFuel System, Gasoline
ROUGH IDLE AT STOPPED INTERSECTIONS, LUNGES AND STALLS. STALLS A APPROXIMATELY 15-25 MPH WHILE MAKING LEFT OR RIGHT TURNS MAKING IT VERY DIFFICULT TO TURN WHILE PLACING THE VEHICLE IN NEUTRAL AND STARTING THE ENGINE AGAIN. THE FOG LIGHTS TURN ON BY ITSELF AFTER THE VEHICLE IS PARKED AND THE IGNITION IS TURNED OFF DRAINING THE …
Read full complaint
ROUGH IDLE AT STOPPED INTERSECTIONS, LUNGES AND STALLS. STALLS A APPROXIMATELY 15-25 MPH WHILE MAKING LEFT OR RIGHT TURNS MAKING IT VERY DIFFICULT TO TURN WHILE PLACING THE VEHICLE IN NEUTRAL AND STARTING THE ENGINE AGAIN. THE FOG LIGHTS TURN ON BY ITSELF AFTER THE VEHICLE IS PARKED AND THE IGNITION IS TURNED OFF DRAINING THE BATTERY. HAD TO DISCONNECT THE FUSE IN ORDER TO PREVENT THIS FROM HAPPENING AGAIN. TO THIS DATE NON-FUNCTIONAL FOG LIGHTS. THE VEHICLE HAS SEVERAL ELECTRICAL PROBLEMS FROM INSTRUMENT CLUSTER NOT FUNCTIONING WHILE DRIVING TO RADIO AND CLIMATE CONTROL NOT WORKING UNTIL YOU STOP THE VEHICLE AND TURN IT OFF. THEN START THE VEHICLE AGAIN THEN IT WORKS PROPERLY FOR ANOTHER FEW DAYS. THIS IS A RECURRING PROBLEM. WHEEL BEARING HAS BEEN AN ISSUE TOO AND CURRENTLY NEEDS TO BE REPLACED. *TR
NHTSA ODI #10576869
116,000 miles · Feb 20, 2014
Electrical SystemService BrakesSteeringCrash
THE VEHICLE FAILED TO STOP AFTER APPLYING BRAKES. *TR
NHTSA ODI #10565059
115,000 miles · Sep 20, 2013
Electrical System
I HAD SMOKE AND SMELLED BURNING COMING FROM MY MULTIFUNCTION SWITCH, *TR
NHTSA ODI #10544527
86,000 miles · Nov 9, 2012
Electrical System
TL* THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. THE CONTACT STATED THAT AFTER MAKING A LEFT TURN, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE COASTED DOWNHILL BEFORE IT CAME TO A COMPLETE STOP. THE VEHICLE WAS TOWED TO A MECHANIC WHO RAN A DIAGNOSTIC TEST AND DETERMINED THAT THE AUTOMATIC SHUT OFF FUSE WAS BLOWN. THE MECHA…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHRYSLER PT CRUISER. THE CONTACT STATED THAT AFTER MAKING A LEFT TURN, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE COASTED DOWNHILL BEFORE IT CAME TO A COMPLETE STOP. THE VEHICLE WAS TOWED TO A MECHANIC WHO RAN A DIAGNOSTIC TEST AND DETERMINED THAT THE AUTOMATIC SHUT OFF FUSE WAS BLOWN. THE MECHANIC REPLACED THE FUSE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 86,000.
NHTSA ODI #10483843
124,000 miles · Oct 12, 2012
Electrical SystemEngine
WHILE DRIVING THE ENGINE WILL SPUTTER AND DIE. WHEN PULLING UP TO A STOP LIGHT THE CHECK ENGINE LIGHT WILL COME ON AND THE ENGINE WILL IMMEDIATELY DIE. WHILE DRIVING ON THE FREEWAY AT 65MPH THE ENGINE WILL SUDDENLY DIE. SOMETIMES IT WILL START UP AGAIN RIGHT AWAY, BUT MOST OF THE TIME IT TAKES A FEW MINUTES TO START BACK UP, …
Read full complaint
WHILE DRIVING THE ENGINE WILL SPUTTER AND DIE. WHEN PULLING UP TO A STOP LIGHT THE CHECK ENGINE LIGHT WILL COME ON AND THE ENGINE WILL IMMEDIATELY DIE. WHILE DRIVING ON THE FREEWAY AT 65MPH THE ENGINE WILL SUDDENLY DIE. SOMETIMES IT WILL START UP AGAIN RIGHT AWAY, BUT MOST OF THE TIME IT TAKES A FEW MINUTES TO START BACK UP, WHILE PEOPLE ARE HONKING AND HAVING TO GO AROUND MY CAR. MOST OF THE TIME THE CAR WILL RUN ROUGH AFTER RE-START, BUT WILL RUN NORMALLY AFTER SITTING OVERNIGHT, UNTIL THE NEXT TIME IT DIES. MANY OTHER PT OWNERS ARE EXPERIENCING THE SAME THING. VERY DANGEROUS AND SCARY! FOUR MECHANICS HAVE TRIED TO FIGURE OUT THE PROBLEM. NO LUCK. HAVE REPLACED THE ECM AND JUST ABOUT EVERY SENSOR AND REPLACEABLE ENGINE PART. NO LUCK. THIS IS OCCURRING IN OTHER CHRYSLER VEHICLES, TOO. IT SEEMS LIKE NO ONE HAS FOUND AN ANSWER TO THE PROBLEM. THIS IS A VERY DANGEROUS SITUATION AND CHRYSLER SHOULD FIGURE OUT THE PROBLEM AND PROVIDE A FIX. *TR
NHTSA ODI #10479917
41,365 miles · Sep 17, 2012
Electrical SystemExterior Lighting
FOG LIGHTS WILL NOT TURN OFF. I HAD TO UNPLUG THE LIGHTS IN ORDER FOR THEM NOT TO STAY ON. NOW THEY ARE COMPLETELY OFF. WILL NEVER BUY A CHRYSLER PRODUCT AGAIN. I HAVE 46,000 MILES AND EVERYTHING DESCRIBED IN THESE REPORTS WENT WRONG WITH MY VEHICLE. *TR
NHTSA ODI #10475743
NHTSA investigations
1PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Illustration