IllustrationFOG LIGHTS STAY ON DRAINING BATTERY. INTERNET RESEARCH INDICATES PROBLEM WITH THE MULTI-FUNCTION SWITCH. ALSO INDICATES THAT HUNDREDS OF PEOPLE HAVE HAD THIS SAME PROBLEM - SOME MULTIPLE TIMES - REPLACING SWITCH AT DEALER FOR APX $200 - AND MANUFACTURER HAS YET TO ISSUE RECALL OR ASSISTANCE. *TR
2001 Chrysler Pt Cruiser
Owner reports · Recalls · Investigations
More warning signs than most Pt Cruiser years
Owner complaints for the 2001 Chrysler Pt Cruiser are substantially higher than the model-year median of 202.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pt Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
370–25K
11625–50K
10150–75K
5675–100K
56100–150K
18150K+
384 reports with mileage · 234 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
36 crash reports17 fire reports24 injury reports
What owners actually said
618 reportsOWNER NOTICED A SLIGHT "PUDDLE" (SIZE OF A SILVER DOLLAR) ON GARAGE FLOOR. OWNER JACKED UP CAR TO INSPECT AND IDENTIFY WHERE LEAK WAS ORIGINATING. NOTED A MISPLACED BUSHING ON THE BRACKET HOLDING THE POWER STEERING HOSE IN PLACE UNDER THE ENGINE. ONE END OF THE BUSHING HAD BROKEN ALLOWING THE HOSE TO CHAFE AGAINST THE BRACKE…
Read full complaint
OWNER NOTICED A SLIGHT "PUDDLE" (SIZE OF A SILVER DOLLAR) ON GARAGE FLOOR. OWNER JACKED UP CAR TO INSPECT AND IDENTIFY WHERE LEAK WAS ORIGINATING. NOTED A MISPLACED BUSHING ON THE BRACKET HOLDING THE POWER STEERING HOSE IN PLACE UNDER THE ENGINE. ONE END OF THE BUSHING HAD BROKEN ALLOWING THE HOSE TO CHAFE AGAINST THE BRACKET AND LEAK FLUID. OWNER IMMEDIATELY TOOK CAR INTO THE DEALER TO HAVE REPAIRED. UPON EXAMINATION, DEALER INFORMED OWNER THAT THE MOTOR MOUNTS (2) HAD BROKEN ALLOWING THE ENGINE TO SIT LOWER ON THE FRAME AND THAT IS WHAT CAUSED THE BUSHING TO FAIL. OWNER PAID OVER $1,000 TO REPLACE MOTOR MOUNTS (2) AND REPLACE BUSHING AND POWER STEERING HOSE. OWNER FEELS THAT MOTOR MOUNT FAILURE WAS PREMATURE AS THE CAR ONLY HAS 38,000 MILES ON IT AND HAS NEVER BEEN DRIVEN HARD AND HAS BEEN GARAGED ITS ENTIRE LIFETIME. OWNER HAS IN HIS POSSESSION THE DEFECTIVE MOTOR MOUNTS. ALTHOUGH THERE WERE NO INJURIES OR DEATHS, THERE CERTAINLY COULD HAVE BEEN IF THE OWNER HAD NOT BEEN SO OBSERVANT AND VIGILANT ABOUT MAINTAINING THE CAR. LOSS OF POWER STEERING FUNCTION OR ENGINE DETACHMENT WOULD BE CATASTROPHIC ON THE ROAD, PARTICULARLY AT FREEWAY SPEEDS. *TR
STRONG EXHAUST ODOR IN CAR WITH AC ON FRESH AIR. AFTER DOING A LITTLE TESTING I FOUND THE MANIFOLD TO EXHAUST SLIP JOINT LEAKING HEAVILY. WE HAVE HAD THIS PROBLEM FOR A LONGE TIME AND ARE JUST GETTING TIRED OF CHOAKING LEVELS OF EXHAUST EVERY TIME WE COME TO A STOP. *TR
THE ORIGINAL CHROME WHEELS ON MY CHRYSLER 2001 PT CRUISER HAVE CONTINUALLY LOST AIR FOR AT LEAST THE PAST TWO YEARS. I HAVE TO ADD AIR EVERY SEVERAL DAYS. BOTH THE MECHANIC AT THE TIRE SHOP AND MY OWN MECHANIC SAID THERE WAS NOTHING WRONG WITH THE TIRES, BUT THE PITTING OF THE WHEELS WAS CAUSING AIR TO LEAK OUT. THIS IS A PROBLE…
Read full complaint
THE ORIGINAL CHROME WHEELS ON MY CHRYSLER 2001 PT CRUISER HAVE CONTINUALLY LOST AIR FOR AT LEAST THE PAST TWO YEARS. I HAVE TO ADD AIR EVERY SEVERAL DAYS. BOTH THE MECHANIC AT THE TIRE SHOP AND MY OWN MECHANIC SAID THERE WAS NOTHING WRONG WITH THE TIRES, BUT THE PITTING OF THE WHEELS WAS CAUSING AIR TO LEAK OUT. THIS IS A PROBLEM THAT SHOULD NOT HAPPEN ON A SIX YEAR OLD CAR WITH 80,000 MILES. I WAS UNABLE TO RETURN TO THE DEALER BECAUSE OWNERSHIP HAS CHANGED SEVERAL TIMES SINCE I BOUGHT THE CAR AND IT IS OUT OF WARRANTY. I BELIEVE THIS IS A MANUFACTURING DEFECT THAT MAY CAUSE A LOSS OF AIR AT HIGH SPEED AND LEAD TO A CRASH. THIS IS A KNOWN PROBLEM THAT HAS BEEN DOCUMENTED ON SEVERAL WEBSITES, BUT HAS NOT BEEN ADDRESSED BY CHRYSLER. *TR
2001 PT CRUISER WITH 44,500 MILES. ABT 3 MONTHS AGO A SMALL CRACK APPEARED IN THE DASHBOARD. IT GREW LARGER AND LARGER, AND IN OCTOBER THE VENT SCREEN PIECE POPPED OUT ON ITS OWN. THE CRACK FINALLY BISECTED THE DASHBOARD, SO I HAD IT REPLACED AT MY OWN EXPENSE. THIS CAR HAS GOTTEN NORMAL USAGE AND THERE APPEARS TO BE NO INCIDENT…
Read full complaint
2001 PT CRUISER WITH 44,500 MILES. ABT 3 MONTHS AGO A SMALL CRACK APPEARED IN THE DASHBOARD. IT GREW LARGER AND LARGER, AND IN OCTOBER THE VENT SCREEN PIECE POPPED OUT ON ITS OWN. THE CRACK FINALLY BISECTED THE DASHBOARD, SO I HAD IT REPLACED AT MY OWN EXPENSE. THIS CAR HAS GOTTEN NORMAL USAGE AND THERE APPEARS TO BE NO INCIDENT OR REASON FOR THIS TO HAVE OCCURRED. *TR
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHILE DRIVING BETWEEN 10-20 MPH, THE CONTACT HEARD A RATTLING NOISE COMING FROM THE REAR OF THE VEHICLE. THE DEALER REPLACED THE REAR LOWER CONTROL ARMS. WHEN THE CONTACT LEFT THE DEALER, SHE HEARD A NOISE COMING FROM THE FRONT END WHEN THE VEHICLE CAME TO A STOP. THE DEALER ST…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHILE DRIVING BETWEEN 10-20 MPH, THE CONTACT HEARD A RATTLING NOISE COMING FROM THE REAR OF THE VEHICLE. THE DEALER REPLACED THE REAR LOWER CONTROL ARMS. WHEN THE CONTACT LEFT THE DEALER, SHE HEARD A NOISE COMING FROM THE FRONT END WHEN THE VEHICLE CAME TO A STOP. THE DEALER STATED THAT THE MOTOR MOUNT NEEDED TO BE REPLACED. THERE WERE NO WARNING INDICATORS. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 116,280. UPDATED 12/13/07 *TR
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE TIRES WERE CONTINUOUSLY FLAT AND THE CONTACT HAD TO ADD AIR IN THEM EVERY OTHER DAY. THE TIRES WERE REPLACED, BUT THE FAILURE CONTINUED. THE DEALER STATED THAT THE CHROME WAS FLAKING INSIDE THE WHEELS AND DAMAGED THE TIRES. THE DEALER STATED THAT THEY COULD SCRAPE THE INSID…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE TIRES WERE CONTINUOUSLY FLAT AND THE CONTACT HAD TO ADD AIR IN THEM EVERY OTHER DAY. THE TIRES WERE REPLACED, BUT THE FAILURE CONTINUED. THE DEALER STATED THAT THE CHROME WAS FLAKING INSIDE THE WHEELS AND DAMAGED THE TIRES. THE DEALER STATED THAT THEY COULD SCRAPE THE INSIDE OF THE WHEEL, BUT WERE UNSURE IF THAT WOULD CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 49,000.
THE CLOCKSPRING IN MY STEERING COLUMN BROKE. I NOTICED A RUBBING NOISE AND THE STEERING WHEEL WOULD STICK WHEN I TURN THE WHEEL TO THE RIGHT. THE RIGHT TURN SIGNAL WHEN ACTIVATED WOULD NOT TURN OFF WHEN THE STEERING WHEEL IS TURNED IN THE OPPOSITE DIRECTION. I TOOK IT TO THE DEALER AND HAD THE CLOCKSPRING REPLACED AT MY EXPENS…
Read full complaint
THE CLOCKSPRING IN MY STEERING COLUMN BROKE. I NOTICED A RUBBING NOISE AND THE STEERING WHEEL WOULD STICK WHEN I TURN THE WHEEL TO THE RIGHT. THE RIGHT TURN SIGNAL WHEN ACTIVATED WOULD NOT TURN OFF WHEN THE STEERING WHEEL IS TURNED IN THE OPPOSITE DIRECTION. I TOOK IT TO THE DEALER AND HAD THE CLOCKSPRING REPLACED AT MY EXPENSE. THE DEALER TOLD ME THAT THE AIRBAG WOULD NOT DEPLOY UNTIL THE CLOCKSPRING IS REPLACED. FOR A ITEM TO FAIL ON A VEHICLE THAT INVOLVES SAFETY EQUIPMENT AND NOT BE REPLACED AT THE MANUFACTURES EXPENSE IS QUITE IRRESPONSIBLE AND CARELESS FOR THE PUBLICS SAFETY. *TR
CRACKED DASHBOARD. THE CRACK HAS NOW SPREAD ACROSS THE ENTIRE DASHBOARD, SEPARATING THE DASH INTO TWO PIECES. THE CRACK EXTENDS FROM THE WINDSHIELD TO THE CENTER CONSOLE. THE CURRENT MILEAGE IS 98,000. *TR
DASHBOARD ON PT CRUISER 2001 BEGAN CRACKING RECENTLY. CRACKING PROGRESSING DAILY AND DASHBOARD IS ABOUT TO CAVE IN. *TR
Official recalls
504V268000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V214000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V215000 · Fuel System, Gasoline:delivery
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V162000 · Seats:front Assembly:recliner
Jun 14, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V366000 · Child Seat
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.