NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
13 reportsClear category filter146,000 miles · Mar 4, 2017
Electrical SystemSeatsVehicle Speed Control
LET ME START BY SAYING I JUST BOUGHT THIS 2001 LIMITED EDITION PT CRUISER THREE DAYS AGO FROM A PRIVATE DEALER. I WAS ON THE HIGHWAY, HEADING HOME FROM WORK IN THE MIDDLE OF THE NIGHT, AND WANTED TO TRY THE CRUISE CONTROL. I TURNED IT ON AND SET IT FOR 67MPH TO SEE IF IT WORKED FIRST. THEN I WENT TO RESET IT TO MY ACTUAL DESIRED…
Read full complaint
LET ME START BY SAYING I JUST BOUGHT THIS 2001 LIMITED EDITION PT CRUISER THREE DAYS AGO FROM A PRIVATE DEALER. I WAS ON THE HIGHWAY, HEADING HOME FROM WORK IN THE MIDDLE OF THE NIGHT, AND WANTED TO TRY THE CRUISE CONTROL. I TURNED IT ON AND SET IT FOR 67MPH TO SEE IF IT WORKED FIRST. THEN I WENT TO RESET IT TO MY ACTUAL DESIRED SPEED BY TAPPING MY BRAKES, THEN I TRIED THE SWITCH ON THE ARM OF MY STEERING WHEEL BUT THE CRUISE CONTROL WOULDN'T SHUT OFF. I GOT OFF AT THE NEXT EXIT AND WAS ABLE TO SLOW DOWN TO 40MPH BEFORE MY BRAKES LOCKED UP AND I WAS FORCED TO RUN THE STOP SIGN AT THE END OF THE OFF RAMP. (THANK GOD IT WAS AT 3AM AND MY BABY WASN'T WITH ME!). I WAS ABLE TO PULL OVER DOING 20MPH BEFORE THE BRAKES LOCKED UP AGAIN. I QUICKLY SHUT IT OFF, PUT IT IN PARK, AND WAITED A FEW MINUTES TO TURN IT BACK ON. BUT THE ENGINE JUST KEPT REVING, AS IF I WAS HOLDING MY FOOT ON THE GAS BECAUSE THE CRUISE CONTROL WAS STILL ON! I TRIED RESETTING IT BY TURNING THE KEY BACK AND FORTH A FEW TIMES. I TRIED TO SEE IF IT WOULD THROW ME A CODE BUT ONLY "DONE" APPEARED ON MY DASH. EVERY TIME I STARTED THE CAR, THE LED FOR CRUISE CONTROL WOULD COME ON AND THEN SHUT OFF AFTER A FEW SECONDS. I WAS ABLE TO COAST HOME DOING 40MPH WITH ACCESS TO MY BRAKES AGAIN. NOT VERY WELL, BUT ENOUGH TO MAKE IT HOME, (WHEN I'D LET OFF THE BRAKE THE CAR WOULD TAKE OFF AGAIN). I'VE BEEN DOING RESEARCH SINCE I GOT BACK AND FOUND A FEW OTHER REPORTS OF THIS HAPPENING, EXCEPT THEY WERE ALL ABLE TO STOP. FOR EXAMPLE BY SHIFTING INTO NEUTRAL OR SHUTTING THE CAR OFF. EVERY TIME I START THE [XXX] THING, THE CRUISE CONTROL IS STILL ON! HOW DO I SHUT IT OFF? PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #10958583
130,000 miles · Aug 20, 2014
Electrical SystemService BrakesSteering
MY CAR JUST SHUTS OFF LEAVING ME NO CONTROL TO STOP, TURN, OR GET OUT OF THE WAY OF TRAFFIC BEHIND ME..... @ 55MPH TO NOTHING IS ASKING TO BE HIT FROM BEHIND. OR IF TURNING ACROSS A DIVIDED HIGHWAY, TO BE LEFT STUCK WITH 2 LANES OF SEMI COMING FOR ME AND MY KIDS. NOW IT SOMETIMES WONT EVEN DO ANYTHING WHEN I CRANK OVER THE IGNIT…
Read full complaint
MY CAR JUST SHUTS OFF LEAVING ME NO CONTROL TO STOP, TURN, OR GET OUT OF THE WAY OF TRAFFIC BEHIND ME..... @ 55MPH TO NOTHING IS ASKING TO BE HIT FROM BEHIND. OR IF TURNING ACROSS A DIVIDED HIGHWAY, TO BE LEFT STUCK WITH 2 LANES OF SEMI COMING FOR ME AND MY KIDS. NOW IT SOMETIMES WONT EVEN DO ANYTHING WHEN I CRANK OVER THE IGNITION (LIKE THERE IS NO BATTERY) OR IF IT CRANKS AND STARTS IT WILL SHUT OFF RIGHT AWAY. IT WANTS TO IDLE DOWN AT STOPS AND STALL. I HAVE HAD IT IN THE SHOP MORE THAN I LIKE N SPENT MORE MONEY TO HAVE TO BE TOLD THEY CAN'T FIND ANYTHING. I READ OF SO MANY OTHER OWNERS WITH THE SAME PROBLEMS WHO END UP JUNKING THESE CUZ THEY JUST STOP STARTING....SAD, WE NEED OUR CARS TO RUN. CHRYSLER KNOWS THEY R RIDDLED WITH SERIOUS ISSUES INCLUDING THE LIGHTS AND TRANSMISSIONS.....THESE ARE A BAD COMBINATION ON THE ROAD. SOMEONE NEEDS TO LOOK @ SOME STATS! THANKS. *TR
NHTSA ODI #10626759
111,145 miles · Feb 14, 2014
Service BrakesVehicle Speed Control
TL* THE CONTACT OWNS 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY ACCELERATED WITHOUT WARNING AFTER STARTING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO BE DIAGNOSIS. THE DEALER STATED THAT THE POWER BRAKE BOOSTER HOSE WAS NOT CONNECTED TO THE ENGINE. THE VEHICLE WAS REPAIRED. THE DE…
Read full complaint
TL* THE CONTACT OWNS 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY ACCELERATED WITHOUT WARNING AFTER STARTING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO BE DIAGNOSIS. THE DEALER STATED THAT THE POWER BRAKE BOOSTER HOSE WAS NOT CONNECTED TO THE ENGINE. THE VEHICLE WAS REPAIRED. THE DEALER ALSO STATED THAT THERE WAS NEVER A CLAMP HOLDING THE POWER BRAKE IN PLACE. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 111,145. THE CURRENT MILEAGE WAS 112,416. *TR
NHTSA ODI #10564360
100,000 miles · Dec 5, 2013
Vehicle Speed Control
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE ACCELERATED TO 70 MPH INDEPENDENTLY AND WITHOUT WARNING. THE CONTACT ALSO MENTIONED THAT THE PARKING BRAKE HAD TO BE ENGAGED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFAC…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE ACCELERATED TO 70 MPH INDEPENDENTLY AND WITHOUT WARNING. THE CONTACT ALSO MENTIONED THAT THE PARKING BRAKE HAD TO BE ENGAGED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 100,000. ..UPDATED 12-30-13 *BF
NHTSA ODI #10554927
134,221 miles · Feb 1, 2012
Electrical SystemVehicle Speed Control
CAR STALLS ON TURNS PARTICULARLY TO THE LEFT, UPON KEY INSERTION HARD CRANK OR STARTS AND IDLES ROUGHLY THEN SHUTS OFF WITH OUT WARNING. WHILE IDLING AT STOP LIGHTS THE RPMS MAY OR MAY NOT (REV,) AFTER SO MANY MINS OF DRIVING ACCELERATION BECOMES MORE DIFFICULT AT INTERVALS & STALLING USUALLY WHILE TURNING AT INTERSECTIONS. OR G…
Read full complaint
CAR STALLS ON TURNS PARTICULARLY TO THE LEFT, UPON KEY INSERTION HARD CRANK OR STARTS AND IDLES ROUGHLY THEN SHUTS OFF WITH OUT WARNING. WHILE IDLING AT STOP LIGHTS THE RPMS MAY OR MAY NOT (REV,) AFTER SO MANY MINS OF DRIVING ACCELERATION BECOMES MORE DIFFICULT AT INTERVALS & STALLING USUALLY WHILE TURNING AT INTERSECTIONS. OR GOING OVER BUMPS OR UP HILLS. THIS HAPPENS SOME WHAT SPORADICALLY SO I NEVER CAN TELL WHEN I'M SAFE TO GO. DEFINITELY NOT SOMETHING U WANT TO THINK ABOUT W MIN COVERAGE EITHER WAY. *TR
NHTSA ODI #10446131
68,000 miles · Jul 30, 2008
Electrical SystemEngine And Engine CoolingPower Train
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT PURCHASED THE VEHICLE IN NOVEMBER OF 2007 AND THE WIRING HARNESS WAS REPLACED DUE TO ELECTRICAL FAILURES. IN APRIL OF 2008, WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE ACCELERATED ON ITS OWN. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REPLACED THE BRAKE PADS AN…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT PURCHASED THE VEHICLE IN NOVEMBER OF 2007 AND THE WIRING HARNESS WAS REPLACED DUE TO ELECTRICAL FAILURES. IN APRIL OF 2008, WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE ACCELERATED ON ITS OWN. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REPLACED THE BRAKE PADS AND CALIPERS. RECENTLY, THE ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER'S DIAGNOSTIC INDICATED THAT THE TRANSMISSION SOLENOID SWITCH NEEDED TO BE REPLACED, ALONG WITH THE POWER STEERING PUMP. THE DEALER STATED THAT THE WARRANTY DOES NOT COVER THE PARTS. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS THAT APPLIED TO HER VIN. THE FAILURE MILEAGE WAS 68,000 AND CURRENT MILEAGE WAS 75,551.
NHTSA ODI #10236394
65,000 miles · Mar 3, 2008
Electrical SystemExterior LightingSteeringFire
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE VEHICLE SPEED CONTROL WAS PREVIOUSLY DISCONNECTED. WHILE DRIVING 25 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE STEERING COLUMN. THE DEALER STATED THAT THE FAILURE WAS ELECTRICAL AND RELATED TO THE VEHICLE SPEED CONTROL. THE HIGH AND LOW BEAM SWITCH WAS ALSO BURNED. THE…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE VEHICLE SPEED CONTROL WAS PREVIOUSLY DISCONNECTED. WHILE DRIVING 25 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE STEERING COLUMN. THE DEALER STATED THAT THE FAILURE WAS ELECTRICAL AND RELATED TO THE VEHICLE SPEED CONTROL. THE HIGH AND LOW BEAM SWITCH WAS ALSO BURNED. THE MANUFACTURER STATED THAT THERE WAS NO EXISTING RECALL. THE CONTACT ALLOWED THE VEHICLE TO COOL DOWN AND WAS ABLE TO DRIVE HOME. A MECHANIC WILL REPAIR THE VEHICLE SINCE THE MANUFACTURER STATED THAT THEY WERE UNABLE TO OFFER ANY ASSISTANCE. SHE IS UNABLE TO DRIVE THE VEHICLE DUE TO THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 65,000 AND CURRENT MILEAGE WAS 65,100.
NHTSA ODI #10220571
72,300 miles · Aug 4, 2006
Vehicle Speed Control
DT*: THE CONTACT STATED THE SHIFTER FELT SLUGGISH AND WHILE DEPRESSING THE ACCELERATOR PEDAL AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS PUSHED OFF THE ROAD WHERE A TEMPORARY REPAIR WAS MADE BY THE CONTACT. THE VEHICLE WAS DRIVEN HOME AND THE REPAIRS WERE MADE BY THE CONTACT. THE DEALER HAS NOT BEEN ALERTED. *AK
NHTSA ODI #10164495
50,900 miles · Sep 23, 2003
Vehicle Speed Control
THE GAS PEDAL FELL OFF IT ATTACHMENT *AK THE PEDAL HAD COME OFF IT'S ATTACHMENT ON THE FLOORBOARD AND FELL BEHIND THE BRAKE PEDAL WHICH MADE BOTH THE GAS AND BRAKE PEDALS USELESS. *SCC *JB
NHTSA ODI #10037674
30,077 miles · Jun 6, 2003
Electrical SystemEngine And Engine CoolingEquipment
VEHICLE WAS PARKED FOR APPROX. TWO DAYS, STARTED VEHICHLE AND ALL LIGHTS ON THE INSTRUMENT PANEL STAYED ON; BRAKE LIGHT, ABS LIGHT, ENGINE LIGHT, SECURITY LIGHT, CRUSIE CONTROL, ETC. AS WELL AS WORDS "NO BUG" OVER THE ODEMETER/MILEAGE GAGE. THESE LGHTS WOULD NOT GO OFF AFTER TURNING THE ENGINE ON AND OFF SEVERAL TIMES. THE ENGIN…
Read full complaint
VEHICLE WAS PARKED FOR APPROX. TWO DAYS, STARTED VEHICHLE AND ALL LIGHTS ON THE INSTRUMENT PANEL STAYED ON; BRAKE LIGHT, ABS LIGHT, ENGINE LIGHT, SECURITY LIGHT, CRUSIE CONTROL, ETC. AS WELL AS WORDS "NO BUG" OVER THE ODEMETER/MILEAGE GAGE. THESE LGHTS WOULD NOT GO OFF AFTER TURNING THE ENGINE ON AND OFF SEVERAL TIMES. THE ENGINE LIGHT STAYS ON AND WILL NOT SHUT OFF. SCHEDULED AN APPOINTMENT WITH DEALER TO CONNECT TO COMPUTER. *AK
NHTSA ODI #10021131
Official recalls
5Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jun 14, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration