NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
66 reportsClear category filter55,000 miles · Mar 25, 2008
Suspension
THE FRONT WHEEL BEARINGS ARE SQUEALING AND NEED REPLACED. THE DEALER SAID THAT IT WAS NORMAL... THEY EXPECT TO REPLACE THEM ALL AT ABOUT 50,000 MILES. THEY QUOTED $550 PER AXLE, THE BEARINGS ARE $60 IF NOT FROM THE DEALER!!! SHOULD BE NO REASON FOR WHEEL BEARINGS TO BE "TYPICAL REPLACEMENT" ITEMS! 2001 CHRYSLER PT CRU…
Read full complaint
THE FRONT WHEEL BEARINGS ARE SQUEALING AND NEED REPLACED. THE DEALER SAID THAT IT WAS NORMAL... THEY EXPECT TO REPLACE THEM ALL AT ABOUT 50,000 MILES. THEY QUOTED $550 PER AXLE, THE BEARINGS ARE $60 IF NOT FROM THE DEALER!!! SHOULD BE NO REASON FOR WHEEL BEARINGS TO BE "TYPICAL REPLACEMENT" ITEMS! 2001 CHRYSLER PT CRUISER, 55,000 MILES, GARAGE STORED. *TR
NHTSA ODI #10222241
116,280 miles · Nov 30, 2007
Engine And Engine CoolingSuspension
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHILE DRIVING BETWEEN 10-20 MPH, THE CONTACT HEARD A RATTLING NOISE COMING FROM THE REAR OF THE VEHICLE. THE DEALER REPLACED THE REAR LOWER CONTROL ARMS. WHEN THE CONTACT LEFT THE DEALER, SHE HEARD A NOISE COMING FROM THE FRONT END WHEN THE VEHICLE CAME TO A STOP. THE DEALER ST…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHILE DRIVING BETWEEN 10-20 MPH, THE CONTACT HEARD A RATTLING NOISE COMING FROM THE REAR OF THE VEHICLE. THE DEALER REPLACED THE REAR LOWER CONTROL ARMS. WHEN THE CONTACT LEFT THE DEALER, SHE HEARD A NOISE COMING FROM THE FRONT END WHEN THE VEHICLE CAME TO A STOP. THE DEALER STATED THAT THE MOTOR MOUNT NEEDED TO BE REPLACED. THERE WERE NO WARNING INDICATORS. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 116,280. UPDATED 12/13/07 *TR
NHTSA ODI #10210387
Mileage unknown · Jun 13, 2007
Suspension
FRONT CONTROL ARM BUSHINGS ARE WORN OUT AT LESS THEN 40000 MILES. *AK
NHTSA ODI #10193131
54,000 miles · May 14, 2007
Suspension
THE FRONT HUBS AND BEARINGS ON THE 2001 PT CRUISER NEEDED TO BE REPLACED AT 54000 MILES. I WAS TOLD BY THE DEALER THIS WAS A POTENTIALLY DANGEROUS CONDITION. AFTER SOME RESEARCH ONLINE I DISCOVERED THAT MANY PT OWNERS HAD THE SAME PROBLEM, SOMETIMES REPEATEDLY. THIS MAY BE RELATED TO A DESIGN DEFECT AND SHOULD BE INVESTIGATE…
Read full complaint
THE FRONT HUBS AND BEARINGS ON THE 2001 PT CRUISER NEEDED TO BE REPLACED AT 54000 MILES. I WAS TOLD BY THE DEALER THIS WAS A POTENTIALLY DANGEROUS CONDITION. AFTER SOME RESEARCH ONLINE I DISCOVERED THAT MANY PT OWNERS HAD THE SAME PROBLEM, SOMETIMES REPEATEDLY. THIS MAY BE RELATED TO A DESIGN DEFECT AND SHOULD BE INVESTIGATED.*AK
NHTSA ODI #10190685
37,000 miles · May 9, 2007
Suspension
PREMATURE FAILURE OF FRONT LOWER CONTROL ARM BUSHINGS. THIS VEHICLE HAD 37,000 MILES WITH BOTH RIGHT AND LEFT BUSHINGS FAILED. WITHOUT REPLACEMENT, THIS CAN LEAD TO ADDITIONAL SUSPENSION WEAR AND IN AN EXTREME CASE, LOSS OF CONTROL. BUSHINGS OF THIS TYPE IN TYPICAL VEHICLES LASTS THE LIFE OF THE VEHICLE. ACCORDING TO MY INDE…
Read full complaint
PREMATURE FAILURE OF FRONT LOWER CONTROL ARM BUSHINGS. THIS VEHICLE HAD 37,000 MILES WITH BOTH RIGHT AND LEFT BUSHINGS FAILED. WITHOUT REPLACEMENT, THIS CAN LEAD TO ADDITIONAL SUSPENSION WEAR AND IN AN EXTREME CASE, LOSS OF CONTROL. BUSHINGS OF THIS TYPE IN TYPICAL VEHICLES LASTS THE LIFE OF THE VEHICLE. ACCORDING TO MY INDEPENDENT GARAGE THIS COMPONENT SHOWS AN INORDINATELY HIGH FAILURE RATE, AS EVIDENCED BY THEIR EXPERIENCE IN REPLACING THEM IN MANY PT CRUSIERS. THEY SEE THEM AT A RATE OF ONE EVERY TWO WEEKS, AND THIS WAS AN INDEPENDENT GARAGE, NOT A CHRYSLER DEALERSHIP. THIS PROBLEM WAS CAUGHT AT PENNSYLVANIA ANNUAL STATE INSPECTION.*AK
NHTSA ODI #10190257
41,361 miles · Feb 23, 2007
Suspension
TL* - THE CONTACT STATED THAT HE HAD GOODYEAR EAGLE TIRES, 205/55 R16 EAGLE LS. AT 31,000 MILES THE CAR WAS PULLING TO THE LEFT, AND HE TOOK IT TO A DEALER AND FOUND THAT THE BELTS ON THE TIRE SEPARATED, CAUSING THE TREAD TO SHIFT. THE CONTACT STATED THAT AT 41,000 MILES THE BACK OF THE CAR BEGAN SWAYING SIDEWAYS TO THE LEFT…
Read full complaint
TL* - THE CONTACT STATED THAT HE HAD GOODYEAR EAGLE TIRES, 205/55 R16 EAGLE LS. AT 31,000 MILES THE CAR WAS PULLING TO THE LEFT, AND HE TOOK IT TO A DEALER AND FOUND THAT THE BELTS ON THE TIRE SEPARATED, CAUSING THE TREAD TO SHIFT. THE CONTACT STATED THAT AT 41,000 MILES THE BACK OF THE CAR BEGAN SWAYING SIDEWAYS TO THE LEFT AND RIGHT, AND IT WAS DETERMINED THAT THE BELTS ON THE TIRE SEPARATED AGAIN. THE CONTACT STATED THAT THE TREAD WAS FINE, THE BELT IN THE TIRE WAS FAULTY. *AK THE VEHICLE HAD A SLIGHT OIL LEAK. THE DEALER REPLACED TRANSMISSION SOLENOID PACK. UPDATED 03/19/07. *JB
NHTSA ODI #10183331
Mileage unknown · Jun 30, 2006
Suspension
2001 PT CRUISER WITH UNDER 40,000 MILES. DEALER CHECKED RATTLING NOISE IN REAR AND REPORTS REAR AXLE IS SHOT. REPAIR COSTS ABOUT $2,000.00. CHRYSLER OFFERED TO PROVIDE PARTS. DEALER LABOR IS ABOUT $600.00. *JB
NHTSA ODI #10161139
29,000 miles · Jun 2, 2006
Suspension
DT*: THE CONTACT STATED DURING AN ANNUAL INSPECTION THE DEALERSHIP DETERMINED THE FRONT CONTROL ARM BUSHING WAS CRACKED. THERE WAS NOT A NOTICEABLE PROBLEM WHILE DRIVING THE VEHICLE. AN INDEPENDENT REPAIR SHOP REPLACED THE FRONT CONTROL ARM. UPDATED 6/19/2006 - THE CONSUMER FEELS THAT THE RUBBER OF THE BUSHING POORLY BONDS…
Read full complaint
DT*: THE CONTACT STATED DURING AN ANNUAL INSPECTION THE DEALERSHIP DETERMINED THE FRONT CONTROL ARM BUSHING WAS CRACKED. THERE WAS NOT A NOTICEABLE PROBLEM WHILE DRIVING THE VEHICLE. AN INDEPENDENT REPAIR SHOP REPLACED THE FRONT CONTROL ARM. UPDATED 6/19/2006 - THE CONSUMER FEELS THAT THE RUBBER OF THE BUSHING POORLY BONDS TO THE STEEL OUTER RING CAUSING FAILURE. *NM
NHTSA ODI #10158844
62,000 miles · Feb 16, 2006
Suspension
AT 62,000 MILES, THERE WAS A CLUNKING NOISE IN MY 2001 PT CRUISER. WHEN TAKEN TO THE DEALER WAS TOLD THE LOWER CONTROL ARMS/BUSHINGS WERE BAD. OF COURSE, MY CAR WAS OVER WARRANTY. QUOTE $750.00 + TAX. HAD REPLACED, NOW AT 75,000 MILES 1 YEAR LATER, TOOK MY PT IN FOR ANNUAL INSPECTION.....YEP, LOWER CONTROL ARMS/BUSHINGS BAD …
Read full complaint
AT 62,000 MILES, THERE WAS A CLUNKING NOISE IN MY 2001 PT CRUISER. WHEN TAKEN TO THE DEALER WAS TOLD THE LOWER CONTROL ARMS/BUSHINGS WERE BAD. OF COURSE, MY CAR WAS OVER WARRANTY. QUOTE $750.00 + TAX. HAD REPLACED, NOW AT 75,000 MILES 1 YEAR LATER, TOOK MY PT IN FOR ANNUAL INSPECTION.....YEP, LOWER CONTROL ARMS/BUSHINGS BAD & NEEDING REPLACED AGAIN. QUOTE THIS TIME $582.00 + TAX. SHOULD THIS BE A YEARLY THING? I HAVE NORMAL DRIVING ON PAVED ROADS...AVOID POT HOLES. THIS NEEDS TO BE ADDRESSED! I LOVE MY CRUISER BY A TRADE IN MIGHT BE HAPPENING!*JB
NHTSA ODI #10150474
84,500 miles · Jan 20, 2006
Suspension
DT*: THE CONTACT STATED THE REAR FRONT BUSHING ON THE CONTROL ARM FRACTURED. THE VEHICLE WAS MAKING A HUMMING SOUND WHEN TURNING TO THE RIGHT. THE BUSHING FRACTURE WAS DISCOVERED BY AN INDEPENDENT MECHANIC DURING NORMAL ROUTINE MAINTENANCE. THE LOCAL DEALERSHIP WAS CONTACTED; HOWEVER THEY HAVE BEEN UNSUCCESSFUL IN GETTING TH…
Read full complaint
DT*: THE CONTACT STATED THE REAR FRONT BUSHING ON THE CONTROL ARM FRACTURED. THE VEHICLE WAS MAKING A HUMMING SOUND WHEN TURNING TO THE RIGHT. THE BUSHING FRACTURE WAS DISCOVERED BY AN INDEPENDENT MECHANIC DURING NORMAL ROUTINE MAINTENANCE. THE LOCAL DEALERSHIP WAS CONTACTED; HOWEVER THEY HAVE BEEN UNSUCCESSFUL IN GETTING THE PART FROM THE MANUFACTURER. *NM
NHTSA ODI #10148191
Official recalls
5Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jun 14, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration