NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
61 reportsClear category filter98,500 miles · Nov 26, 2016
Steering
POWER STEERING FLUID IS LEAKING FROM THE HIGH PRESSURE HOSE WHERE IT IS ROUTED UNDER THE ENGINE CASING. THE HIGH PRESSURE HOSE APPEARS TO HAVE BEEN WARN THROUGH BY RUBBING AGAINST ONE OF THE CLAMPS WHICH SECURE THE HOSE TO THE BOTTOM OF THE ENGINE CASING. POWER STEERING PUMP WAS MAKING WHINING NOISES. POWER STEERING FLUID…
Read full complaint
POWER STEERING FLUID IS LEAKING FROM THE HIGH PRESSURE HOSE WHERE IT IS ROUTED UNDER THE ENGINE CASING. THE HIGH PRESSURE HOSE APPEARS TO HAVE BEEN WARN THROUGH BY RUBBING AGAINST ONE OF THE CLAMPS WHICH SECURE THE HOSE TO THE BOTTOM OF THE ENGINE CASING. POWER STEERING PUMP WAS MAKING WHINING NOISES. POWER STEERING FLUID RESERVOIR WAS CHECKED. DIPSTICK WAS DRY.
NHTSA ODI #10928067
101,295 miles · Oct 24, 2016
Steering
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT OBSERVED A HEAVY LEAK FROM THE UNDERCARRIAGE OF THE VEHICLE. THE CONTACT DETERMINED THAT THE FLUID WAS POWER STEERING FLUID. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: …
Read full complaint
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT OBSERVED A HEAVY LEAK FROM THE UNDERCARRIAGE OF THE VEHICLE. THE CONTACT DETERMINED THAT THE FLUID WAS POWER STEERING FLUID. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V268000 (STEERING). THE APPROXIMATE FAILURE MILEAGE WAS 101,295.
NHTSA ODI #10918642
162,400 miles · Mar 24, 2016
Steering
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHILE MAKING A TURN AT 5 MPH, AN ABNORMAL NOISE WAS HEARD AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER WITHOUT WARNING. THE FAILURE RECURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE POWER STEERING HOSE FAILED AND NEEDED TO…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHILE MAKING A TURN AT 5 MPH, AN ABNORMAL NOISE WAS HEARD AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER WITHOUT WARNING. THE FAILURE RECURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE POWER STEERING HOSE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V268000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 162,400.
NHTSA ODI #10851384
155,621 miles · Sep 9, 2015
SteeringStructure
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LIGHT FLICKERED AND SUDDENLY REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE UNDERBODY PREMATURELY RUSTED AND COULD FRACTURE AT ANY MOMENT. THE VEHICLE WAS ALSO TAKEN TO AN INDEPENDENT REPAI…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LIGHT FLICKERED AND SUDDENLY REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE UNDERBODY PREMATURELY RUSTED AND COULD FRACTURE AT ANY MOMENT. THE VEHICLE WAS ALSO TAKEN TO AN INDEPENDENT REPAIR WHO DIAGNOSED THAT THE CASING FOR THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE CONTACT STATED THAT POWER STEERING FLUID HAD TO BE CONSTANTLY ADDED TO THE VEHICLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V268000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 155,621.
NHTSA ODI #10762585
46,403 miles · Jul 27, 2015
Steering
FRONT SUB FRAME (CROSS MEMBER) BROKE APART AT WELD.
NHTSA ODI #10743592
140,000 miles · Oct 23, 2014
Air BagsSteering
CENTER OF STEERING WHEEL (WHERE AIRBAG IS LOCATED) BECAME SO HOT THAT IT COULD NOT BE TOUCHED WITH YOUR BARE HAND. PULLED OVER AND GOT OUT OF THE VEHICLE AND TURNED VEHICLE OFF. WAITED UNTIL IT COOLED DOWN TO NORMAL TEMPERATURE THEN GOT BACK IN AND RESTARTED VEHICLE AND MOVED SEAT ALL THE WAY BACK FROM THE STEERING WHEEL JUST …
Read full complaint
CENTER OF STEERING WHEEL (WHERE AIRBAG IS LOCATED) BECAME SO HOT THAT IT COULD NOT BE TOUCHED WITH YOUR BARE HAND. PULLED OVER AND GOT OUT OF THE VEHICLE AND TURNED VEHICLE OFF. WAITED UNTIL IT COOLED DOWN TO NORMAL TEMPERATURE THEN GOT BACK IN AND RESTARTED VEHICLE AND MOVED SEAT ALL THE WAY BACK FROM THE STEERING WHEEL JUST IN CASE. THE HEATING PHENOMENON DID NOT RECUR IN THE SHORT DRIVE HOME (5-10 MINUTES). HAS NOT HAPPENED AGAIN. SCHEDULING A VISIT TO LOCAL DEALER TO DETERMINE IF THIS IS A KNOWN PROBLEM. NOTHING FOUND ON CHRYSLER RECALL INFORMATION AND EMAIL TO CHRYSLER GOT NO RESPONSE. THIS IS A 2001 CHRYSLER PT CRUISER WITH PACKAGE 28G THAT INCLUDED SUPPLEMENTAL SIDE AIRBAGS. *TR
NHTSA ODI #10649477
130,000 miles · Aug 20, 2014
Electrical SystemService BrakesSteering
MY CAR JUST SHUTS OFF LEAVING ME NO CONTROL TO STOP, TURN, OR GET OUT OF THE WAY OF TRAFFIC BEHIND ME..... @ 55MPH TO NOTHING IS ASKING TO BE HIT FROM BEHIND. OR IF TURNING ACROSS A DIVIDED HIGHWAY, TO BE LEFT STUCK WITH 2 LANES OF SEMI COMING FOR ME AND MY KIDS. NOW IT SOMETIMES WONT EVEN DO ANYTHING WHEN I CRANK OVER THE IGNIT…
Read full complaint
MY CAR JUST SHUTS OFF LEAVING ME NO CONTROL TO STOP, TURN, OR GET OUT OF THE WAY OF TRAFFIC BEHIND ME..... @ 55MPH TO NOTHING IS ASKING TO BE HIT FROM BEHIND. OR IF TURNING ACROSS A DIVIDED HIGHWAY, TO BE LEFT STUCK WITH 2 LANES OF SEMI COMING FOR ME AND MY KIDS. NOW IT SOMETIMES WONT EVEN DO ANYTHING WHEN I CRANK OVER THE IGNITION (LIKE THERE IS NO BATTERY) OR IF IT CRANKS AND STARTS IT WILL SHUT OFF RIGHT AWAY. IT WANTS TO IDLE DOWN AT STOPS AND STALL. I HAVE HAD IT IN THE SHOP MORE THAN I LIKE N SPENT MORE MONEY TO HAVE TO BE TOLD THEY CAN'T FIND ANYTHING. I READ OF SO MANY OTHER OWNERS WITH THE SAME PROBLEMS WHO END UP JUNKING THESE CUZ THEY JUST STOP STARTING....SAD, WE NEED OUR CARS TO RUN. CHRYSLER KNOWS THEY R RIDDLED WITH SERIOUS ISSUES INCLUDING THE LIGHTS AND TRANSMISSIONS.....THESE ARE A BAD COMBINATION ON THE ROAD. SOMEONE NEEDS TO LOOK @ SOME STATS! THANKS. *TR
NHTSA ODI #10626759
130,000 miles · Aug 6, 2014
Steering
MADE A RIGHT HAND TURN AND HEARD A METAL CLUNK NOISE, PROCEEDED ANOTHER BLOCK - FROM A STOP MADE A LEFT HAND TURN ONTO A HIGHWAY - AT THAT TIME A VERY LOUD METAL NOISE, NO BRAKES, NO STEERING, NO CONTROL OF VEH AT ALL. SOMEHOW MANAGED TO GET TO SIDE OF ROAD WITHOUT ROLLING VEH, WHEELS TURNED OPPOSITE DIRECTIONS, HAD VEH TOWED T…
Read full complaint
MADE A RIGHT HAND TURN AND HEARD A METAL CLUNK NOISE, PROCEEDED ANOTHER BLOCK - FROM A STOP MADE A LEFT HAND TURN ONTO A HIGHWAY - AT THAT TIME A VERY LOUD METAL NOISE, NO BRAKES, NO STEERING, NO CONTROL OF VEH AT ALL. SOMEHOW MANAGED TO GET TO SIDE OF ROAD WITHOUT ROLLING VEH, WHEELS TURNED OPPOSITE DIRECTIONS, HAD VEH TOWED TO SHOP. ENGINE CRADLE WAS RUSTED OUT ON RIGHT SIDE AND GAVE WAY, WHICH DISCONNECTED STEERING CONTROL ARM AND AXEL FROM THE WHEELS, MECHANIC - STATED DRIPPING FROM AIR CONDITIONER HAD RUSTED THE PARTS ON THAT SIDE ONLY - REST OF UNDER VEH WAS IN GOOD SHAPE - STATED HAD SEEN THIS IN PT'S OFTEN - A KNOWN CHRYSLER ISSUE WITH THE PT CRUISERS AND THE NEONS ALSO - WHICH HAVE THE SAME PLATFORM. IF HAD BEEN GOING AT HIGHWAY SPEEDS - WOULD HAVE BEEN A VERY BAD, POSSIBLY FATAL ACCIDENT. OWN TWO OF THESE VEHS - TOOK THE SECOND VEH TO HAVE INSPECTED (ONLY HAS 50,000 MILES) - HAS THE EXACT SAME ISSUE. RESEARCHED THE PT CRUISER FORUMS AND FOUND MANY COMPLAINTS ON THE SAME ISSUE. CHRYSLER IS NON RESPONSIVE - THIS SHOULD BE RECALLED AS IS A DEADLY PROBLEM. VEHICLE IS UNREPAIRABLE. *TR
NHTSA ODI #10619367
193,892 miles · Jun 6, 2014
Steering
I PURCHASED A USED PT CRUISER THAT DROVE FINE UNTIL THE COMPONENTS NEAR THE POWER STEERING HOUSE TOUCHED AND CREATED A MAJOR LEAK AND CAUSED MY CAR TO SMOKE VERY BADLY CLOSE TO CAUSING A FIRE WHILE DRIVING. *TR
NHTSA ODI #10596578
90,000 miles · May 28, 2014
Steering
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE TRAVELING 20 MPH AND ATTEMPTING TO MAKE A LEFT TURN, THE POWER STEERING FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 90,000.
NHTSA ODI #10594547
Official recalls
5Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jun 14, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration