2022 Chrysler Pacifica

The contact owns a 2022 Chrysler Pacifica. The contact had received notification of NHTSA Campaign Number: 26V362000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the message "Battery Over Heated" was displayed, and the check engine warning light was illuminated. The failure mileage was 61,000.

Upon attempting to charge the vehicle with factory supplied Level 1 charger, a dashboard message appeared stating "Service Charging System" and the vehicle would not charge. Took the vehicle to a service station and scanned the vehicle. Listed error code is p0d27-00. The code could not be cleared and the vehicle was unable to be charged. Vehicle had to be taken to a Chrysler dealer for the code to be cleared in order to charging capability to be restored. This was considered a "software" issue and not covered under the vehicles warranty - despite it directly affecting the fuel/hybrid propulsion system. This defect and inability to clear the code means the vehicle cannot be charged, reducing its range and fuel economy, and increasing emissions. This is a critical issue and should not incur customer expense to have the code cleared.

We got a notice that said to pull over because the vehicle will shut down. We did and the vehicle shut down and went into red turtle mode only a few seconds after the indicator light appeared. This was unsafe in our situation and would be very unsafe at highway speeds or in busy traffic. The dealer has not been able to reproduce the issue (although has confirmed the error code) but will also not confirm that the car is safe for us to drive. The car is still at the dealer. They will not fix the car unless the error code is replicated. We do not feel comfortable driving the car until it is fixed or they are willing to confirm it is safe to drive. It has been more than 2 months with no progress.

This vehicle has experienced three separate powertrain failures stemming from the same transmission defect (DTC P0A43 — Drive Motor Position Sensor, eFlite transmission). Incident 1 — April 19, 2026: Complete sudden loss of motive power on the highway with family aboard. Vehicle towed to Castle Rock Chrysler CDJR. Failed Repair — May 8, 2026: Chrysler corporate mandated a software flash rather than a hardware repair. Vehicle failed identically within 10 miles of pickup in live highway traffic. Towed back same day. Incident 3 — June 6, 2026: A replacement transmission was installed. Within one week of pickup, a progressive transmission whine developed followed by visible smoke from the engine compartment while driving. Vehicle was immediately pulled over and towed to avoid a third highway failure. Chrysler's own STAR engineering team (TSB 21-014-26) has documented this as a known defect requiring transmission rebuild or replacement. Chrysler blocked a full transmission replacement for over 5 weeks citing backorder, then located one within hours when a repurchase review was requested. This defect causes sudden loss of motive power at highway speeds with no warning, creating an immediate safety hazard. I am requesting NHTSA investigate this defect pattern on 2022 Chrysler Pacifica Hybrid vehicles and evaluate whether a safety recall is warranted.

1. Most emergency lights come on while the vehicle's brake engages automatically. The brake then pumps up and down on its own if any pressure is applied. Shortly after, the vehicle goes into "limp mode". The vehicle is currently at a Chrysler Dealership service department and available for inspection. 2. This has occurred 8 times since the vehicle was purchased in October 2024. All but one time, it has happened while driving. Once it happened while on a major highway. I had to quickly veer into a turn lane so our vehicle was not rearended by another car. Another time, I was driving my children to school and it happened about 10 seconds before crossing the worst intersection in our city. That could have resulted in a major crash based on the history of that intersection. A third time, I was traveling at about 40 miles an hour when warnings came on and the brake started to engage. Luckily, I had just gotten off a major highway and I was able to get to the side of the road. 3. The problem has been confirmed by a dealer, since it happened while I was in their service parking lot. However, they have been unable to recreate, find the source of, or fix the issue after 7 times of servicing it. 4. I am unsure whether the manufacturer has sent anyone outside of the dealer's service department to inspect the vehicle. We have been in contact with the manufacturer directly since December 26, 2025 in relation to this issue. Our extended warranty company may have had an inspector out on the first visit to the dealership for the issue, but no one since that I am aware of. 5. Emergency messages have included: Service Electronic Stability Control, Service Charging System, Service Hybrid Electronic Vehicle System, Auto Emergency Braking Unavailable Service Required. Multiple emergency lights come on including: Check Engine, Electronic Throttle Control, Electronic Stability Control Active, Service Forward Collision Warning. The first incident was January 22, 2025.

My 2022 Chrysler Pacifica Hybrid has developed a dangerous rear brake system malfunction. During a dealer inspection on 4/27/26, the certified technician confirmed that the rear brake pads are only contacting approximately 50% of the rotor surface, leaving the remaining half completely unused and heavily corroded. This is not normal corrosion or wear. It is a mechanical failure in which the pads are not engaging the rotor correctly. The technician also stated that the pads were sticking in the caliper slides, which prevented full engagement. This is a functional defect in the brake hardware, not environmental corrosion. Corrosion does not selectively prevent half of a brake pad from engaging the rotor unless the caliper mechanism is not operating properly. This defect results in: Reduced rear braking force Increased stopping distance Excessive load on the front brakes Potential loss of stability during emergency braking Possible degradation of the parking brake The vehicle was serviced on 9/23/25 (tire rotation + NYS inspection) and 12/10/24 (four new tires + NYS inspection). No rear brake issues were identified at either visit. If this were normal corrosion, it would have been visible during those inspections. The sudden onset of severe partial engagement by 4/27/26 indicates a latent mechanical defect, not gradual wear. Chrysler/Stellantis has refused to classify this as a defect and instead labels it “corrosion,” despite the technician’s findings of pad binding in the slides and improper brake engagement. The manufacturer’s internal system blocks any warranty or engineering review because it incorrectly categorizes the failure as routine maintenance. This is a premature and unsafe brake system failure at only 33,000 miles. The braking system is not operating as designed, and the defect could lead to reduced braking performance or loss of control. I am requesting NHTSA’s review of this issue as a potential safety defect affecting the rear brake system

Driving down a highway at 70 mph and a notification popped up saying to pull over and turn off the vehicle because the engine would shut down soon. I lost the ability to accelerate and impeded traffic. Had to pull over on the side of the road with minimal shoulder. This has happened dozens of times; all at high rates of speed and often in heavy traffic.

My 2022 Pacifica Hybrid has experienced a total loss of motor propulsion THREE times in the last 8 days at highway (or near-highway) speeds. The car issued a warning to "Stop Safely Vehicle will Shut Off Soon" and had a turtle light appear along with a check engine light and I experienced no power going to the wheels on the highway. This included TWO incidents after a recall repair that was completed to supposedly fix this issue.

My 2022 Chrysler Pacifica PHEV has experienced three separate complete losses of motive power at highway speed, each preceded only by a brief dashboard warning to pull over safely. First occurrence: April 18, 2026. Second: May 7, 2026 — vehicle towed to Spitzer Motor City (Cleveland, OH), an authorized Stellantis dealer. Dealer replaced the Power Inverter Module hardware under warranty (R.O. 42463CY). Third occurrence: May 17, 2026 — just five days after the repair. Notably, the battery was at 40% on the third occurrence, meaning the engine had not cycled on, distinguishing this failure from the prior two. The root cause is the internal transmission wiring harness connector short identified in NHTSA Recall 03A (23V-010). Per NHTSA's own ODI investigation (RQ24-004), the software recall remedy does not prevent loss of motive power. TSB 21-008-23 / Warranty Extension XE1 identifies full transmission replacement as the correct fix. The dealer did not perform a transmission replacement. The safety risk is severe — complete, sudden loss of drive power at interstate speeds with minimal warning creates immediate rear-end collision risk. The defect has been confirmed by the authorized dealer. The transmission assembly is available for inspection. No police or insurance involvement. This VIN currently shows zero open recalls, suggesting the incomplete repair was logged as satisfying Recall 03A.