2020 Chrysler Pacifica

I experienced a sudden loss of power and steering while driving my vehicle. The screen advised me to pull over because the engine would shut off soon, but I already had lost steering and power. I turned the car off and was able to restart it and drive it 1 mile home, and the check engine light was on. I had it towed to the dealer. After 2 weeks of testing, the dealer reported, “When your vehicle was initially checked in, the following trouble codes were present: 5 BPCM FAULT CODES P1A21-00, P1D43-00, P1C01-00, P1A2A-00, and P1A29-00. We have completed Recall Y40.” The repair tech said they expected the engine to lose power again at some point and I would need to have it towed in again to be repaired then. The repairs made so far are only software updates, no hardware has been repaired because the dealer said the errors didn’t recur after they reset the system. I have elevated the issue with the dealer and am awaiting a response. I am concerned based on the error codes and technician information that my vehicle is still at risk of catching fire at any time or experiencing another catastrophic loss of power if the faulty hardware is not replaced.

I am writing to formally express my dissatisfaction with the handling of repairs on my Chrysler Pacifica and the significant financial and personal impact this situation has caused my family. The issue began when the engine suddenly stopped, leaving us stranded. The vehicle was first taken to an insurance-recommended shop that could not diagnose the issue, then transferred to Wischsnewsky Dodge in Baytown, TX. There, we were told the problem was the starter and fuse box. Based on their professional assessment, we approved costly repairs, which required financing. However, just one day after picking up the vehicle, it failed to start again. This not only showed a lack of proper diagnosis, but also placed my wife and children in an unsafe situation. We were also forced to cancel a prepaid family trip due to lack of transportation. The dealership retrieved the vehicle and promised a loaner, but none has been provided after more than two weeks. We have since incurred additional expenses for rentals and rideshare services. We are now being told the issue may be a head gasket failure—something that could have been identified earlier with a basic test and is reportedly a known issue with this model. The estimated cost to replace the engine per the dealership is $16,000. At this point, we have taken on debt for ineffective repairs and continue to face mounting costs without a clear resolution. I am requesting immediate assistance from Chrysler to address this situation and provide a fair outcome.

I have a 2020 Chrysler Pacifica. There was a recall last year and I brought it in to the dealership. At that time, I wasn't even sure what the recall was for. This year, about a month ago, I was driving (I take XXX to work everyday) and the display had a notice that said "Stop safely, the engine will turn off". I pulled over and turned the car off and turned it back on. The check engine light came back on but it drove fine. The check engine light eventually went off but the same thing happened again a few days later. I brought it into my mechanic who couldn't read the diagnostics. I brought it back into the dealership and they said I just needed a software upgrade so they did that. Unfortunately, the engine died again on the road. I shut the car off and turned it back on. I brought it back to the dealership and said the issue wasn't fixed. They haven't taken the issue seriously so I started searching and found this issue. It sounds like Chrysler is aware of the issue but I'm nervous even a new transmission won't fix the issue. In the meantime, I've had to rent a car as the dealership doesn't do loaners. This is a pretty big safety issue as now my car has shut down on the middle of the highway multiple times! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The hybrid propulsion system on my 2020 Chrysler Pacifica Plug-In Hybrid has repeatedly failed, resulting in sudden and complete loss of power while driving at highway speeds. The vehicle enters full limp mode, displays a red turtle warning light, and the motor cuts out entirely, creating a serious collision risk. The failure occurs without warning and has happened on multiple occasions. The root cause has been traced through escalating component failures: first the Power Inverter Module (PIM) was found to have an internal failure disabling regenerative braking and causing the motor to cut out; subsequently the battery charging module was found to be failing, causing the high-voltage battery to drain to 0% and stall the vehicle. Both components were replaced by an authorized Stellantis dealership under warranty. Despite replacement of the PIM, the charging module, and ultimately the transmission, the defect has not been resolved. The vehicle has been confirmed defective by the authorized dealer on each visit and has been subject to a STAR (engineering escalation) case with Stellantis. Warning symptoms include the red turtle warning light, check engine light, and sudden power loss. The vehicle has been out of service for cumulative warranty repairs exceeding 130 days, including a continuous period exceeding 90 days. The vehicle remains unrepaired and in dealer custody as of the date of this filing. The dealer has confirmed the defect on each visit and has conducted multiple rounds of diagnostic testing and component replacement, none of which have restored safe and reliable operation. The component failures are available for inspection upon request.

While driving in suburban traffic vehicle engine began running rough and lost most power with about 58000 mi on the vehicle. Received check engine light and vehicle entered 'limp mode' with Turtle Icon displayed on screen. Brought to dealer and it was diagnosed with a P0304 Cylinder #4 Misfire and leaking head gasket causing coolant contamination to engine oil. Dealer repaired the head gasket under warranty. About 2 months after the head gasket was repair at 60,098 miles while drive on the Interstate the engine began running rough. Check Engine Light came on and then Oil Pressure Light came on. We were able to exit the highway, had the vehicle towed to the same dealer where the head gasket was repaired under warranty. This time the engine was diagnosed with a failed #4 Cylinder connecting rod. Chrysler and Dealer refused to repair or replace the engine even though both leak and failure occurred on same cylinder.

The contact owns a 2020 Chrysler Pacifica. While the contact's wife was driving at an undisclosed speed, the engine seized in the middle of the road. The contact stated that there was no power to the vehicle. The contact stated that the failure occurred close to the residence, and there was not a lot of traffic. The driver was able to exit the vehicle and get to a safe area. The contact's brother-in-law was contacted for assistance; however, the driver became impatient waiting for assistance. The driver attempted to restart the vehicle, and the vehicle started. The help arrived, disconnected and reconnected the battery cables, and the vehicle was driven to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer; however, the dealer was made aware of the failure. The contact was informed that a recall was issued, but for Hybrid vehicles. In addition, the contact referenced an open investigation for the failure. The contact stated that the failure had occurred twice within two weeks. Additionally, the warning light that the “Auto START/STOP Unavailable” had remained illuminated since August 2025. The manufacturer was not made aware of the failure. The failure mileage was approximately 52,000. The VIN was unavailable.