The contact owns a 2007 Chrysler Pacifica. The contact stated that the driver’s side headlight failed to operate as needed. The local dealer was contacted and provided an estimate for the repair. Due to the cost of the repair, the manufacturer was notified of the failure however, offered no assistance since there was no recall o…
Read full complaint
The contact owns a 2007 Chrysler Pacifica. The contact stated that the driver’s side headlight failed to operate as needed. The local dealer was contacted and provided an estimate for the repair. Due to the cost of the repair, the manufacturer was notified of the failure however, offered no assistance since there was no recall on the vehicle. The contact eventually took the vehicle to an independent mechanic who was unable to repair the headlight and referred him to the NHTSA for assistance. The vehicle was not repaired. The failure mileage was approximately 122,000.
NHTSA ODI #11421033
135,000 miles · Jul 2, 2019
Electrical SystemElectronic Stability Control (esc)Exterior Lighting
BOTH STATIONARY AND WHILE DRIVING. HEADLIGHTS WENT OUT. WINDOWS WOULDN'T ROLL UP OR DOWN. WINDSHIELD WIPERS STOPPED WORKING. SPEEDOMETER STOPPED WORKING AS WELL AS OTHER GAUGES. SHIFTER LOCKED UP. FUSE BOX UNDER HOOD BEEPING LOUDLY. VERY VERY DANGEROUS!!
NHTSA ODI #11229044
100,540 miles · Dec 6, 2018
Electrical SystemEngine And Engine CoolingExterior Lighting
TL* THE CONTACT OWNS A 2007 CHRYSLER PACIFICA. WHILE DRIVING AT UNKNOWN SPEEDS, THE RPMS DECREASED AND THE VEHICLE STALLED. ADDITIONALLY, THE PASSENGER SIDE LOW BEAM HEADLIGHT WAS FLICKERING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO KEY CHRYSLER JEEP DODGE (2020 N DETROIT ST, XENIA, OH 45385) WHERE…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHRYSLER PACIFICA. WHILE DRIVING AT UNKNOWN SPEEDS, THE RPMS DECREASED AND THE VEHICLE STALLED. ADDITIONALLY, THE PASSENGER SIDE LOW BEAM HEADLIGHT WAS FLICKERING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO KEY CHRYSLER JEEP DODGE (2020 N DETROIT ST, XENIA, OH 45385) WHERE IT WAS DIAGNOSED THAT THE EXHAUST GAS RE-CIRCULATION VALVE AND THE COMPUTER MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 100,540.
NHTSA ODI #11156664
120,000 miles · Nov 2, 2015
Electrical SystemExterior Lighting
TL* THE CONTACT OWNS A 2007 CHRYSLER PACIFICA. WHILE DRIVING APPROXIMATELY 40 MPH, THE HEADLIGHTS AND INSTRUMENT PANEL FAILED TO ILLUMINATE INTERMITTENTLY. ON A SEPARATE OCCASION, THE CONTACT MENTIONED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE MAN…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHRYSLER PACIFICA. WHILE DRIVING APPROXIMATELY 40 MPH, THE HEADLIGHTS AND INSTRUMENT PANEL FAILED TO ILLUMINATE INTERMITTENTLY. ON A SEPARATE OCCASION, THE CONTACT MENTIONED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.
NHTSA ODI #10787772
52,000 miles · Sep 30, 2014
Exterior LightingService BrakesVehicle Speed Control
ON SEPTEMBER 15TH I WAS TAKING MY SON TO SCHOOL WHEN ALL OF MY IDIOT LIGHTS CAME ON AND STAYED ON. ONCE I GOT BACK HOME AND TURNED THE CAR OFF I NOTICED THAT SOMETHING WAS STILL RUNNING. AFTER OPENING THE HOOD I REALIZED IT WAS MY ABS SYSTEM THAT WANT SHUTTING OFF. I WAS ABLE TO DISCONNECT THE SENSOR BUT HAVE BEEN TOO FEARFUL TO…
Read full complaint
ON SEPTEMBER 15TH I WAS TAKING MY SON TO SCHOOL WHEN ALL OF MY IDIOT LIGHTS CAME ON AND STAYED ON. ONCE I GOT BACK HOME AND TURNED THE CAR OFF I NOTICED THAT SOMETHING WAS STILL RUNNING. AFTER OPENING THE HOOD I REALIZED IT WAS MY ABS SYSTEM THAT WANT SHUTTING OFF. I WAS ABLE TO DISCONNECT THE SENSOR BUT HAVE BEEN TOO FEARFUL TO DRIVE IT SINCE THEN. MY FATHER RAN A CODE CHECKER AND NOTHING WAS SHOWING UP EXCEPT THE FUEL CAP (WHICH WAS REPLACED BUT STILL SHOWING THAT WARNING LIGHT). HE DROVE THE CAR AND NOTICED THAT THE SPEEDOMETER WASN'T WORKING. *TR
NHTSA ODI #10640218
147,000 miles · Sep 5, 2014
Electrical SystemEngineExterior Lighting
WE WERE DRIVING. I ASKED MY HUSBAND TO CLEAN THE WINDSHIELD. AS SOON AS HE PULLED THE WIPER STEM, THE HEADLIGHTS WENT OUT. THE CAR RESTARTED, BUT THE HEADLIGHTS WOULDN'T COME BACK ON. WE PULLED OVER AGAIN AND OPENED THE HOOD. THE CAR WOULD RESTART, BUT NOW THE DASH CLUSTER WAS OUT ALONG WITH THE HEADLIGHTS. WE TURNED THE ENGINE…
Read full complaint
WE WERE DRIVING. I ASKED MY HUSBAND TO CLEAN THE WINDSHIELD. AS SOON AS HE PULLED THE WIPER STEM, THE HEADLIGHTS WENT OUT. THE CAR RESTARTED, BUT THE HEADLIGHTS WOULDN'T COME BACK ON. WE PULLED OVER AGAIN AND OPENED THE HOOD. THE CAR WOULD RESTART, BUT NOW THE DASH CLUSTER WAS OUT ALONG WITH THE HEADLIGHTS. WE TURNED THE ENGINE OFF AND WEIRDLY, THE HEADLIGHTS CAME ON. THEY WERE FLASHING ON AND OFF, OVER AND OVER. WITHIN THE NEXT TEN MINUTES THE CAR WOULD START BUT WOULDN'T SHIFT OUT OF PARK. FROM THERE THE ARMREST CONTROLS STOPPED FUNCTIONING, AND EVENTUALLY THE CAR JUST CHATTERED WHEN THE KEY WAS TURNED. THEN IT WOULDN'T EVEN DO THAT. IT COMPLETELY DIED. FOUR WEEKS AND $1600 LATER, WE HAVE A NEW TIPM L. THE ENTIRE ELECTRICAL SYSTEM WAS FRIED. *TR
NHTSA ODI #10631127
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08006 · Engine Compartment Fire
Opened Feb 21, 2008 · Closed Apr 15, 2009
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:interior/under Dash; Engine And Engine Cooling; Steering:hydraulic Power Assist:power Steering Fluid
THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF CONSUMER COMPLAINTS, FIELD REPORTS, WARRANTY CLAIMS AND OTHER DATA REGARDING ENGINE COMPARTMENT FIRES AND POWER STEERING FLUID LEAKAGE IN MODEL YEAR (MY) 2007 CHRYSLER PACIFICA VEHICLES WITH 4.0L ENGINES.THE AVAILABLE EVIDENCE INDICATES THAT POWER STEERING FLUID LEAKS IN THE SUBJECT VEHICLES AND THE FIRES THAT MAY RESULT FROM THESE LEAKS, OCCURRED EARLY IN THE VEHICLE'S SERVICE LIFE.MOREOVER, CHANGES IN THE ASSEMBLY PROCESS APPEAR TO HAVE REMEDIED THE CONDITION CAUSING THE LEAKS.THE AVAILABLE DATA CONFIRMS A DECLINING TREND FOR BOTH COMPLAINTS AND WARRANTY CLAIMS AS THE SUBJECT VEHICLES REMAIN IN SERVICE. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY THE AGENCY THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. (SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.)
Additional source detail variants (5)
Electrical System
THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF CONSUMER COMPLAINTS, FIELD REPORTS, WARRANTY CLAIMS AND OTHER DATA REGARDING ENGINE COMPARTMENT FIRES AND POWER STEERING FLUID LEAKAGE IN MODEL YEAR (MY) 2007 CHRYSLER PACIFICA VEHICLES WITH 4.0L ENGINES.THE AVAILABLE EVIDENCE INDICATES THAT POWER STEERING FLUID LEAKS IN THE SUBJECT VEHICLES AND THE FIRES THAT MAY RESULT FROM THESE LEAKS, OCCURRED EARLY IN THE VEHICLE'S SERVICE LIFE.MOREOVER, CHANGES IN THE ASSEMBLY PROCESS APPEAR TO HAVE REMEDIED THE CONDITION CAUSING THE LEAKS.THE AVAILABLE DATA CONFIRMS A DECLINING TREND FOR BOTH COMPLAINTS AND WARRANTY CLAIMS AS THE SUBJECT VEHICLES REMAIN IN SERVICE. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY THE AGENCY THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. (SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.)
Electrical System:wiring:front Underhood
THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF CONSUMER COMPLAINTS, FIELD REPORTS, WARRANTY CLAIMS AND OTHER DATA REGARDING ENGINE COMPARTMENT FIRES AND POWER STEERING FLUID LEAKAGE IN MODEL YEAR (MY) 2007 CHRYSLER PACIFICA VEHICLES WITH 4.0L ENGINES.THE AVAILABLE EVIDENCE INDICATES THAT POWER STEERING FLUID LEAKS IN THE SUBJECT VEHICLES AND THE FIRES THAT MAY RESULT FROM THESE LEAKS, OCCURRED EARLY IN THE VEHICLE'S SERVICE LIFE.MOREOVER, CHANGES IN THE ASSEMBLY PROCESS APPEAR TO HAVE REMEDIED THE CONDITION CAUSING THE LEAKS.THE AVAILABLE DATA CONFIRMS A DECLINING TREND FOR BOTH COMPLAINTS AND WARRANTY CLAIMS AS THE SUBJECT VEHICLES REMAIN IN SERVICE. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY THE AGENCY THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. (SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.)
Electrical System:wiring:interior/under Dash
THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF CONSUMER COMPLAINTS, FIELD REPORTS, WARRANTY CLAIMS AND OTHER DATA REGARDING ENGINE COMPARTMENT FIRES AND POWER STEERING FLUID LEAKAGE IN MODEL YEAR (MY) 2007 CHRYSLER PACIFICA VEHICLES WITH 4.0L ENGINES.THE AVAILABLE EVIDENCE INDICATES THAT POWER STEERING FLUID LEAKS IN THE SUBJECT VEHICLES AND THE FIRES THAT MAY RESULT FROM THESE LEAKS, OCCURRED EARLY IN THE VEHICLE'S SERVICE LIFE.MOREOVER, CHANGES IN THE ASSEMBLY PROCESS APPEAR TO HAVE REMEDIED THE CONDITION CAUSING THE LEAKS.THE AVAILABLE DATA CONFIRMS A DECLINING TREND FOR BOTH COMPLAINTS AND WARRANTY CLAIMS AS THE SUBJECT VEHICLES REMAIN IN SERVICE. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY THE AGENCY THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. (SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.)
Engine And Engine Cooling
THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF CONSUMER COMPLAINTS, FIELD REPORTS, WARRANTY CLAIMS AND OTHER DATA REGARDING ENGINE COMPARTMENT FIRES AND POWER STEERING FLUID LEAKAGE IN MODEL YEAR (MY) 2007 CHRYSLER PACIFICA VEHICLES WITH 4.0L ENGINES.THE AVAILABLE EVIDENCE INDICATES THAT POWER STEERING FLUID LEAKS IN THE SUBJECT VEHICLES AND THE FIRES THAT MAY RESULT FROM THESE LEAKS, OCCURRED EARLY IN THE VEHICLE'S SERVICE LIFE.MOREOVER, CHANGES IN THE ASSEMBLY PROCESS APPEAR TO HAVE REMEDIED THE CONDITION CAUSING THE LEAKS.THE AVAILABLE DATA CONFIRMS A DECLINING TREND FOR BOTH COMPLAINTS AND WARRANTY CLAIMS AS THE SUBJECT VEHICLES REMAIN IN SERVICE. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY THE AGENCY THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. (SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.)
Steering:hydraulic Power Assist:power Steering Fluid
THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF CONSUMER COMPLAINTS, FIELD REPORTS, WARRANTY CLAIMS AND OTHER DATA REGARDING ENGINE COMPARTMENT FIRES AND POWER STEERING FLUID LEAKAGE IN MODEL YEAR (MY) 2007 CHRYSLER PACIFICA VEHICLES WITH 4.0L ENGINES.THE AVAILABLE EVIDENCE INDICATES THAT POWER STEERING FLUID LEAKS IN THE SUBJECT VEHICLES AND THE FIRES THAT MAY RESULT FROM THESE LEAKS, OCCURRED EARLY IN THE VEHICLE'S SERVICE LIFE.MOREOVER, CHANGES IN THE ASSEMBLY PROCESS APPEAR TO HAVE REMEDIED THE CONDITION CAUSING THE LEAKS.THE AVAILABLE DATA CONFIRMS A DECLINING TREND FOR BOTH COMPLAINTS AND WARRANTY CLAIMS AS THE SUBJECT VEHICLES REMAIN IN SERVICE. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY THE AGENCY THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. (SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.)
PE07052 · Engine Compartment Fire
Opened Oct 19, 2007 · Closed Feb 21, 2008
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist:power Steering Fluid
COMPLAINANTS ALLEGE THAT A FIRE ERUPTED UNDER THE HOOD, NEAR THE FRONT OF THE VEHICLE.IN CHRYSLER'S RESPONSE TO ODI'S NOVEMBER 2, 2007 INFORMATION REQUEST, CHRYSLER ASSERTS THAT THE ALLEGED DEFECT OCCURS ONLY IN THE 4.0L ENGINES AND THE CONSUMER WILL EXPERIENCE A LOSS OF POWER STEERING FLUID OR A NOISY POWER STEERING PUMP BEFORE SEEING ANY EVIDENCE OF SMOKE OR FIRE.CHRYSLER ALSO STATES THAT A TUBE NUT ON THE HIGH PRESSURE POWER STEERING LINE WAS DISCOVERED TO BE CROSS THREADED DURING THE ASSEMBLY PROCESS AND DID NOT ALLOW PROPER SEALING OF THE O-RING.THE POWER STEERING SYSTEM IN THE 4.0L ENGINE IS ASSEMBLED AT THE CHRYSLER PLANT.THE POWER STEERING SYSTEM FOR THE 3.8L ENGINES ARRIVES AT THE CHRYSLER PLANT PRE-ASSEMBLED.CHRYSLER FOUND THAT IN THE 4.0L ENGINE, IT WAS POSSIBLE TO CROSS-THREAD THE TUBE NUT ON THE HIGH PRESSURE LINE DURING ITS ATTACHMENT TO THE STEERING GEAR, THUS CREATING AN IMPROPER SEAL.CHRYSLER IMPLEMENTED ASSEMBLY PLANT PROCESS CHANGES TO ELIMINATE THE POSSIBILITY OF CROSS-THREADING, AND APPLIED ADDITIONAL QUALITY CONTROL MEASURES TO DETECT POWER STEERING FLUID LEAKS.CHRYSLER STATED THAT WARRANTY AND FIELD DATA SUGGESTS THAT THESE PROCESS CHANGES HAVE MINIMIZED THE POSSIBILITY OF CROSS-THREADING.WITH REGARD TO THE VEHICLES PRODUCED PRIOR TO THE PRODUCTION CHANGE, A REVIEW OF THE WARRANTY CLAIMS INDICATES THAT THE ALLEGED DEFECT HAS NOT DECLINED IN THE 4.0L POPULATION.ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-006, TO FURTHER EVALUATE THE ISSUE.
2007 Chrysler Pacifica Problems, Complaints & Recalls | Skip That Year
Illustration