2007 Chrysler Pacifica

Engine Sub Frame-AKA Engine Cradle is rotting out. Vehicle was inspected on July 6, 2023 at Jim Rielh's Chrysler -Jeep Dealership located at 32899 Van Dyke, Warren Michigan 48093. The report came back as " FOUND FRONT ENGINE CRADLE / FRAME ROTTED / RUSTED OUT." This vehicle has been well maintained and has been Safety Inspected by the same dealership in 2021 & 2022 and never advised there was a problem with the Engine Cradle. Now in 2021, three engine mounts were replaced to correct clunking noises when accelerating, but again there was never an advisement of a potential Engine Cradle Rot. The vehicle had 127, 640 miles on it when it was inspected by the dealer. The results were reported to Chrysler Customer Care via email and by phone but no response as of today.

I am requesting that NHTSA issue a recall for the known defect and serious safety hazard for the 2007 Chrysler Pacifica. These vehicles need to be recalled effective immediately and removed from our highways. The engine cradle rot poses a a risk for accidents and the manufacturer is privy to these problems and had legal action taken against them for a similar notification of different years. The 2007 models should be recalled as well. Please issue the recall and do the right thing. Who knows, you may save someone’s life who is unaware of the dangerous equipment they are driving. Not to mention the manufacturer needs to either to buy back the vehicles, pay for the costly repairs and or compensate the owners who are unable to drive their vehicle or are forced to purchase another vehicle because Chrysler and those in authority have failed and refused to act with integrity and take action to make the recall. There are countless consumers who complain of the same problems of cradle rot, but nothing has been done. Please note the following:l, which lists the court case and consumer complaints: https://www.casemine.com/judgement/us/59145d2dadd7b049341f482e https://www.carproblemzoo.com/chrysler/pacifica/frame-rust-problems.php Please provide a follow up with what action you are going to take since Chrysler refuses to issue a recall and a representative stated, the recall would need to come from NHTSA and will not do the right thing. Thank you.

The contact owned a 2007 Chrysler Pacifica. The contact stated that the vehicle had been parked in the driveway for a week when it caught fire. The contact's husband looked outside the window of their residence and noticed that the vehicle had caught fire from the engine. The fire also caused damage to the garage door and siding. The fire department arrived on the scene and extinguished the fire. The fire department determined that the fire started in the engine compartment. Police and fire department reports were filed. The vehicle was towed to a tow yard and was not yet deemed totaled by the insurance company. The manufacturer was not made aware of the failure. Prior to the failure, the vehicle experienced a loss of power steering assist. The failure mileage was approximately 187,000.

The car has a lot of dangerous problems. For one I had my truck diagnosed and code came back as gas cap. Then it was electric problems after the replacement of the gas cap. Check engine light was still on. So I went for another diagnostic now is coming up power train. Went to 3 to 6 transmission shops and all told me different reasons solenoid, pcm, Tcm, or maybe it’s just shot all together is what the last shop told me. That’s a $3,000 repair and that’s ridiculous after I had all those pieces replaced. My car stills doesn’t shift gears as I’m driving I can’t really go over 40 or 50 mph because of high rpm’s. The car doesn’t shift gears and I’m hearing a loud whining noise as I drive. I was on the high way and could get off fast enough because of high rpm’s and the car not shifting and also automatically switches from drive to auto-stick on it’s on. Pls Help Me

My Chrysler Pacifica 2007 4.0L Shifter Check Engine Light Was On. I Took It To Get Diagnosed It Came Back Ass Gas Cap My Inboard Computer Even Read Gas-cap. So I Replaced It And The Check Engine Light Was Gone. I Say A Week Later My I Was Parked An Tried To Put The Car In Drive I Wouldn't Shift Shifter Broken Only To Find Out It Was A Piece Inside The Shifter. So I Replaced That And After Replacement Of That Now I’m Having Transmission And Electric Problems. The Car Shifts Rough And As I’m Driving The Car Doesn’t Shifts Gears Now Also Will Shift Into Auto-stick On It’s On. I’ll Put My Car Into Drive An As I’m Proceeding To Drive Say At 20mph My Rpm’s A Stay At x2000 I’ll Continue To Speed Up To 30,40 mph And My Rpm’s Will Be The Same As If My Transmission Isn’t Shifting Gears Also Hear A Whining Noise As I Drive. Replaced Transmission Inner And Outer sensors Still Having The Same Problem. Now He’s Saying My Transmission Is Shot All Together. I Put In Total $800. In repairs after the purchase of this car and its my only car RN. It’s basically idling up and not switching gears I’ve been to 3 to 5 transmission shops and auto body shops.

After fueling, especially if the take is full. The engine will die several times in the first 5 or more miles driven. Of course, this also means no power steering. You may be turning at an intersection, on a freeway or just traveling on a surface street. Still, you are without power and no power steering putting the car and occupants in danger. Usually, putting the car in neutral and starting gets you going again, at least until the next event. We have had as many a 5 such events on a 4.5 mile drive home form the gas station. This has now progressed. The last fill up, the nozzle cut of several times and restart over and over to finally fill the take. We knew it could take more fuel, Ultimately it took on 15 Gallons. This time, even after the second day and about 20 miles on the car it will still die at random, especially at idle, say at a stop light. Also with this phenomenon, when the gas gouge gets to just below a half of a tank reading, it may suddenly drop to (E) empty. This is not a good feeling, even though we know it is a bogus reading. The gauge may or may not read correctly at about a half tank the next time the car is started, after an overnight rest. We suspect this may relate to the saddle bag fuel tank system. Currently the check engine light is on, solid, not flashing. However, this problem after a fill up has occurred when there was no check engine light active. Our mechanic is aware of the problems and we are scheduling a visit again and will make sure he is aware of all of these issues. Safety issue, yeah, like suddenly rear-ended or t boned with loss of power and almost impossible steering without power steering. Thankfully, the emergency flashers work fine.

The engine cradle has rotted and engine started to fall out. It took months to find a replacement, now I am told the bolts needed are discontinued and no one at Chrysler or Mopar can tell me what size bolts & nuts are needed to put it together. The control arm came but not bolts or nuts. The engine carriage came, but no nuts & bolts. So, over $1k in parts, looks like it will need to go to the crushers for a loss of $2500 (with cost of purchase). FYI one guy one ebay is selling 1 bolt for $105.00 plus shipping.

The contact owns a 2007 Chrysler Pacifica. The contact stated that the driver’s side headlight failed to operate as needed. The local dealer was contacted and provided an estimate for the repair. Due to the cost of the repair, the manufacturer was notified of the failure however, offered no assistance since there was no recall on the vehicle. The contact eventually took the vehicle to an independent mechanic who was unable to repair the headlight and referred him to the NHTSA for assistance. The vehicle was not repaired. The failure mileage was approximately 122,000.