IllustrationCAR IS STALLING WHILE DRIVING AND FUEL PUMP AND SYSTEM HAVE HAD TO BE REPLACED TWICE! HEAD LIGHTS AND TURNING SIGNALS ARE HAVE TO BE REPLACED OFTEN AS WELL!
2006 Chrysler Pacifica
Owner reports · Recalls · Investigations
More warning signs than most Pacifica years
Owner complaints for the 2006 Chrysler Pacifica are substantially higher than the model-year median of 189.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pacifica years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
480–25K
6925–50K
10350–75K
12275–100K
195100–150K
79150K+
616 reports with mileage · 110 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 198 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 146 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports7 fire reports16 injury reports
Exterior Lighting complaints
14 reportsLOW BEAM HEADLIGHTS FLICKER WHEN VEHICLE IS RUNNING AND AFTER A FEW MINUTES GO OUT. THIS MAKES IT VERY DIFFICULT TO DRIVE AT NIGHT AS THE HEADLIGHTS WILL GO COMPLETELY OUT. TESTED WITH VEHICLE STATIONARY AND IN MOTION ON A STATE MAINTAINED LETTERED ROADWAY.
AS I WAS DRIVING ALL OF A SUDDEN THE DASHBOARD AND HEADLIGHTS STARTED FLICKERING AND THE WARNING ICONS DINGED ON. THIS HAS CONTINUED TO OCCUR AND THE MECHANIC CAN NOT DETERMINE THE CAUSE OF THE PROBLEM. *TR
VEHICLES LOW BEAM HEADLIGHTS HAVE GONE OUT MULTIPLE TIMES WHILE DRIVING. AFTER REPLACING THEM MULTIPLE TIME THEY HAVE NOW QUIT WORKING COMPLETELY. PREVIOUS MODEL YEARS HAVE HAD THE SAME ISSUE AND HAVE HAD A RECALL. I THINK THAT THIS IS A SERIOUS SAFETY ISSUE AND SHOULD BE ADDRESSED, REGARDLESS OF AGE OR MILEAGE. THIS IS OBVIOUSL…
Read full complaint
VEHICLES LOW BEAM HEADLIGHTS HAVE GONE OUT MULTIPLE TIMES WHILE DRIVING. AFTER REPLACING THEM MULTIPLE TIME THEY HAVE NOW QUIT WORKING COMPLETELY. PREVIOUS MODEL YEARS HAVE HAD THE SAME ISSUE AND HAVE HAD A RECALL. I THINK THAT THIS IS A SERIOUS SAFETY ISSUE AND SHOULD BE ADDRESSED, REGARDLESS OF AGE OR MILEAGE. THIS IS OBVIOUSLY A MANUFACTURING DEFECT. *TR
WAS DRIVING IN THE RAIN AND MY LOW BEAMS SHUT OFF. THE HIGHBEAMS CONTINUED TO WORK AS WELL AS MY MARKER LIGHTS, AND FLOOD LIGHTS. I REPLACED BOTH BULBS AND STILL HAD NO LOW BEAMS. EVERYTHING ELSE WORKS EXCEPT THEM. DID RESEARCH ON THE INTERNET TO LEARN THE 2005 MODELS HAD A SIMILAR ISSUE AND THERE WAS A RECALL BUT THE 2006 M…
Read full complaint
WAS DRIVING IN THE RAIN AND MY LOW BEAMS SHUT OFF. THE HIGHBEAMS CONTINUED TO WORK AS WELL AS MY MARKER LIGHTS, AND FLOOD LIGHTS. I REPLACED BOTH BULBS AND STILL HAD NO LOW BEAMS. EVERYTHING ELSE WORKS EXCEPT THEM. DID RESEARCH ON THE INTERNET TO LEARN THE 2005 MODELS HAD A SIMILAR ISSUE AND THERE WAS A RECALL BUT THE 2006 MODELS ARE NOT COVERED EVEN THOUGH IT IS THE SAME ISSUE. *TT
SPORADICALLY THE ABS & BRAKE WARNING LIGHTS COME ON THE DASHBOARD LIGHTS COME ON AND THE RADIO CUTS OUT. THE MAIN ISSUE IS THAT WHEN ALL OF THIS HAPPENS THE HEADLIGHTS ALSO FLICKER AND GO OUT. WHEN DRIVING AT NIGHT THE HEADLIGHTS ARE VERY DISTRACTING TO MYSELF AS WELL AS OTHER VEHICLES ON THE ROAD. ONCE I WAS DRIVING AT NIGHT …
Read full complaint
SPORADICALLY THE ABS & BRAKE WARNING LIGHTS COME ON THE DASHBOARD LIGHTS COME ON AND THE RADIO CUTS OUT. THE MAIN ISSUE IS THAT WHEN ALL OF THIS HAPPENS THE HEADLIGHTS ALSO FLICKER AND GO OUT. WHEN DRIVING AT NIGHT THE HEADLIGHTS ARE VERY DISTRACTING TO MYSELF AS WELL AS OTHER VEHICLES ON THE ROAD. ONCE I WAS DRIVING AT NIGHT AND MY HEADLIGHTS COMPLETELY WENT OUT FOR A FEW SECONDS. THE DEALER CAN'T FIGURE OUT WHAT IS CAUSING THE ISSUE AND THERE IS NO SPECIFIC REASON THAT CAUSES IT TO HAPPEN. *TR
THE HEADLIGHTS (LOW BEAM ONLY) JUST STOPPED WORKING. NO WARNING AT ALL. CHECKED BULBS AND THEY ARE FINE. I AM NOT GETTING POWER TO THE LOW BEAM LIGHTS. THE HIGH BEAMS WORK FINE ALONG WITH THE SIGNALS, HORN, FLASHERS, ETC.. I KNOW CHRYSLER HAS A RECALL ON THE 2005 MODELS, AND CAN'T UNDERSTAND WHY THE 2006 ARE NOT INCLUDED!! IT'S…
Read full complaint
THE HEADLIGHTS (LOW BEAM ONLY) JUST STOPPED WORKING. NO WARNING AT ALL. CHECKED BULBS AND THEY ARE FINE. I AM NOT GETTING POWER TO THE LOW BEAM LIGHTS. THE HIGH BEAMS WORK FINE ALONG WITH THE SIGNALS, HORN, FLASHERS, ETC.. I KNOW CHRYSLER HAS A RECALL ON THE 2005 MODELS, AND CAN'T UNDERSTAND WHY THE 2006 ARE NOT INCLUDED!! IT'S THE SAME PROBLEM. *TR
ON MARCH 5, 2012 I WAS REQUIRED TO PAY $95.00 FOR A FULL DIAGNOSTIC TO SATISFY [XXX] ([XXX] CORPORATE OFFICE). THE SERVICE WAS RENDERED BY CAPITAL CHRYSLER 200 WATERFIELD RIDGE PLACE, GARNER NC 27529. THE SERVICE REP [XXX] AND SERVICE MANAGER [XXX] INFORMED ME THAT THE CATALYTIC CONVERTER REPLACEMENT LOOKED USED DUE TO THE …
Read full complaint
ON MARCH 5, 2012 I WAS REQUIRED TO PAY $95.00 FOR A FULL DIAGNOSTIC TO SATISFY [XXX] ([XXX] CORPORATE OFFICE). THE SERVICE WAS RENDERED BY CAPITAL CHRYSLER 200 WATERFIELD RIDGE PLACE, GARNER NC 27529. THE SERVICE REP [XXX] AND SERVICE MANAGER [XXX] INFORMED ME THAT THE CATALYTIC CONVERTER REPLACEMENT LOOKED USED DUE TO THE RUST ON IT AND WAS CAUSING OTHER MECHANICAL FAILURES IN MY VEHICLE BUT WOULD NOT CONFIRM THIS IN WRITING. I DO NOT HAVE AN EXTRA $1000.25 SITTING AROUND TO PAY FOR A PART THAT CHRYSLER IS WELL AWARE OF IT BEING DEFECTIVE OR USED. CHRYSLER SETTLED A LAWSUIT IN 2005-6 WITH THE U. S. ENVIRONMENTAL PROTECTION AGENCY FOR THE DEFECTIVE CATALYTIC CONVERTER. IN CLOSING, AS A RESOLUTION TO THIS MATTER I WOULD LIKE ALL REPAIRS RELATED TO THIS MATTER REPLACED AT NO EXPENSE TO ME BY A CERTIFIED CHRYSLER DEALERSHIP OF MY CHOOSING. AFTER VIEWING THE INFORMATION ON THE FOLLOWING WEBSITES; HTTP://WWW.DAIMLERCHRYSLERVEHICLEPROBLEMS.COM, HTTP://WWW.EPA.GOV/COMPLIANCE/RESOURCES/CASES/CIVIL/CAA/DAIMLERCHRYSLER-FCSHT.HTML, AND HTTP://WWW.LEMONAIDCARS.COM/SECRETWARRANTIES.HTML I AM EVEN MORE EDUCATED AND CONVINCED THAT MY 02 OXYGEN SENSORS AND CATALYTIC CONVERTER WERE DEFECTIVE INITIALLY WHEN I PURCHASED MY VEHICLE AND THAT IT WAS REPLACED WITH A USED AND/OR DEFECTIVE BY [XXX] CHRYSLER DEALERSHIP. LISTED BELOW ARE ADDITIONAL ISSUES I HAVE EXPERIENCED WITH MY CAR SINCE OWNING IT: 1.SECOND REPLACEMENT OF CATALYTIC CONVERTER AND 02 OXYGEN SENSORS 2.HEAD LIGHTS AND TAIL LIGHT GOING OUT FASTER THAN ANY OTHER CAR I HAVE OWNED. 3.HUMMING ENGINE NOISE, LESS ENGINE POWER THAN IT INITIALLY HAD, 4.FREQUENT REPLACEMENT OF THE BATTERY 3 TIMES IN5 YEARS. IS THAT NORMAL? 5.STICKY GAS PEDAL, IT IS VERY HARD TO PUSH DOWN AT TIMES INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
DRIVERS SIDE HEADLAMP WORKED INTERMITTANTLY AND THEN LOST POWER. THERE IS NO POWER LEADING TO THE LOW BEAM HEADLAMP ASSY. 2005 MODELS HAD A RECALL FOR THIS EXACT PROBLEM, BUT CHRYSLER TELLS ME THAT MY 2006 SHOWS NO RECALLS PER MY VIN. THIS IS VERY DANGEROUS THAT MY HEADLIGHTS CAN FAIL WHILE DRIVING AND CAUSE A CRASH. ALSO REPLAC…
Read full complaint
DRIVERS SIDE HEADLAMP WORKED INTERMITTANTLY AND THEN LOST POWER. THERE IS NO POWER LEADING TO THE LOW BEAM HEADLAMP ASSY. 2005 MODELS HAD A RECALL FOR THIS EXACT PROBLEM, BUT CHRYSLER TELLS ME THAT MY 2006 SHOWS NO RECALLS PER MY VIN. THIS IS VERY DANGEROUS THAT MY HEADLIGHTS CAN FAIL WHILE DRIVING AND CAUSE A CRASH. ALSO REPLACING BULBS WILL NOT HELP THIS SITUATION BECAUSE THE PROBLEM IS IN THE INTEGRATED POWER MODULE (FUSE BOX). SO YOU CANNOT EVEN DRIVE YOUR CAR HOME IF THIS PROBLEM HAPPENS TO YOU ON THE ROAD. VERY DANGEROUS AND A HORRIBLE DESIGN BY CHRYSLER. *TR
I HAVE A 2006 CHRYSLER PACIFICA WITH 65000 MILES. EXTERIOR HEADLIGHTS AND INTERIOR DASH LIGHTS BEGIN TO FLICKER WHILE DRIVING. ALSO, ABS & BRAKE LIGHTS ARE FLICKERING ON AND OFF. THIS OCCURS SEVERAL TIMES DAILY..ESPECIALLY IN THE MORNINGS WHEN HEADLIGHTS ARE IN USE. I FEAR HEADLIGHTS WILL GO OUT PERMANENTLY AND WILL CAUSE A CRA…
Read full complaint
I HAVE A 2006 CHRYSLER PACIFICA WITH 65000 MILES. EXTERIOR HEADLIGHTS AND INTERIOR DASH LIGHTS BEGIN TO FLICKER WHILE DRIVING. ALSO, ABS & BRAKE LIGHTS ARE FLICKERING ON AND OFF. THIS OCCURS SEVERAL TIMES DAILY..ESPECIALLY IN THE MORNINGS WHEN HEADLIGHTS ARE IN USE. I FEAR HEADLIGHTS WILL GO OUT PERMANENTLY AND WILL CAUSE A CRASH. HAVE SEEN SEVERAL COMPLAINTS FROM OTHER CONSUMERS.. WHY HAS THERE NOT BEEN A RECALL . REPLACED SEVERAL SENSORS WILL NOT RESULTS. *TR
Official recalls
106V432000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Nov 9, 2006
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE AND THE POWER TRAIN CONTROL MODULE (PCM) SOFTWARE MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN OPERATING CONDITIONS.
Consequence & remedy
Consequence: THIS COULD CAUSE A CRASH TO OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE FUEL PUMP MODULE WILL ALSO BE REPLACED ON VEHICLES BUILT FROM AUGUST 1, 2004 THROUGH SEPTEMBER 30, 2004. THE RECALL BEGAN ON NOVEMBER 21, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA06013 · Engine Stalling
Opened Jun 22, 2006 · Closed Nov 29, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Power Train; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Vehicle Speed Control
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Additional source detail variants (7)
Engine And Engine Cooling
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline:delivery
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline:delivery:fuel Pump
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Power Train
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Vehicle Speed Control
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
EA06010 · Fuel Tank Punctures
Opened Jun 15, 2006 · Closed Oct 11, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage; Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Fuel System, Gasoline:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ06002 · Engine Stalling
Opened Feb 27, 2006 · Closed Jun 22, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline; Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Additional source detail variants (3)
Engine And Engine Cooling
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Fuel System, Gasoline
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.