IllustrationTL*THE CONTACT OWNS A 2005 CHRYSLER PACIFICA. WHILE DRIVING 30 MPH, HE DECELERATED AND SPARKS WERE PRESENT ON THE PASSENGER SIDE BRAKES. THE DEALER STATED THAT THE BRAKE PAD FELL OFF. THE BRAKES AND ROTORS WERE REPAIRED ON THE DRIVER AND PASSENGER SIDE. THE CURRENT AND FAILURE MILEAGES WERE 40,000. UPDATED 01/11/08. *LJ
2005 Chrysler Pacifica
Owner reports · Recalls · Investigations
More warning signs than most Pacifica years
Owner complaints for the 2005 Chrysler Pacifica are substantially higher than the model-year median of 189.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pacifica years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1420–25K
10425–50K
12450–75K
16575–100K
369100–150K
141150K+
1,045 reports with mileage · 199 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 413 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 224 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 211 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports13 fire reports17 injury reports
Service Brakes, Hydraulic complaints
48 reports29294 MILES - 04/26/07 - ABS SENSOR REPLACED AGAIN AT RUSS DARROW DEALER IN MILWAUKEE, WI. SAME PROB FROM 01/13/07 DID NOT GET REPLACED IN JAN. PROBLEM OCCURRED THIS TIME ONLY ABOVE FREEZING TEMPERATURES. ONCE TEMPS ABOVE 32, OCCURRED EVERY DAY. ABS BRAKES ENGAGED WHEN BRAKES WERE APPLIED. BRAKING BECOMES UNSURE. CAN'T TELL I…
Read full complaint
29294 MILES - 04/26/07 - ABS SENSOR REPLACED AGAIN AT RUSS DARROW DEALER IN MILWAUKEE, WI. SAME PROB FROM 01/13/07 DID NOT GET REPLACED IN JAN. PROBLEM OCCURRED THIS TIME ONLY ABOVE FREEZING TEMPERATURES. ONCE TEMPS ABOVE 32, OCCURRED EVERY DAY. ABS BRAKES ENGAGED WHEN BRAKES WERE APPLIED. BRAKING BECOMES UNSURE. CAN'T TELL IF CAR WILL STOP. DEALER SAYS PROBLEM IS NOT COMMON. I DISAGREE. GOOGLED "ABS SENSOR REPLACEMENT ON CHRYSLER PACIFICA" AND FOUND MANY INSTANCES OF PROBLEM ON THE INTERNET FORUMS AND BLOGS. 01/27/07 ABS INDICATOR LIGHT IS ON. ABS BRAKES BEGIN ENGAGING AGAIN WITHOUT REASON. CONTACTED CHRYSLER SERVICE DEPT AND TALKED TO BOB IN SERVICE. EXPLAINED THIS IS THE 6 OR 7TH TIME I HAVE HAD A PROBLEM WITH THE CAR BRAKES, EITHER THE ABS OR THE ACTUAL BRAKES. WOULD LIKE TO CONTACT THE CHRYSLER COMPANY TO FIND OUT IF THIS IS A KNOWN PROBLEM. BOUGHT USED WITH 13K MILES FROM A CHRYSLER DEALER IN APRIL 2006 AND IT HAS BEEN IN THE SHOP AT LEAST 7 TIMES. OTHER TIMES WERE NOT THE BRAKES RELATED. 26000+ MILES 01/13/07 - ABS INDICATOR LIGHT COMES ON AGAIN. INTERMITTENT. DOES NOT STAY ON. ABS BRAKES ENGAGING WHEN LIGHT COMES ON AND BRAKES ARE APPLIED. 25593 MILES - 12/30/06 - ABS BRAKES ENGAGING WITHOUT ICE/RAIN/WATER OR OTHER REASON TO ENGAGE. ABS SENSOR REPLACED BY DEALER SERVICE DEPT. 21715 MILES - 08/06/06 - PULSATING PROBLEM WITH ABS BRAKES - ABS SENSOR REPLACED BY DEALER SERVICE DEPT. 06/06 - REPLACED RADIO. 17000 MILES - 05/06 - RESURFACED ROTORS - SQUEAKING. *JB
TL*- THE CONTACT OWNS A 2005 CHRYSLER PACIFICA. WHILE DRIVING 65 MPH THE CONTACT DEPRESSED THE BRAKE PEDAL AND IT STARTED TO MOVE UP AND DOWN. THE CONTACT HEARD THE COMPUTER MAKE A LOUD NOISE, AND THE ABS WARNING LIGHT ILLUMINATED. THE DEALER STATED THAT THE DRIVER'S SIDE FRONT HUB AND THE BEARINGS SHOULD BE REPLACED. THERE HAD…
Read full complaint
TL*- THE CONTACT OWNS A 2005 CHRYSLER PACIFICA. WHILE DRIVING 65 MPH THE CONTACT DEPRESSED THE BRAKE PEDAL AND IT STARTED TO MOVE UP AND DOWN. THE CONTACT HEARD THE COMPUTER MAKE A LOUD NOISE, AND THE ABS WARNING LIGHT ILLUMINATED. THE DEALER STATED THAT THE DRIVER'S SIDE FRONT HUB AND THE BEARINGS SHOULD BE REPLACED. THERE HAD NOT BEEN ANY OTHER OCCURRENCES SINCE THE REPAIR. THE CURRENT MILEAGE WAS 8,000.*AK
SINCE 2006, I'VE HAD TO TAKE MY CAR TO THE SERVICE DEPARTMENT BECAUSE OF ABS LIGHT TURNING ON AND OFF. AT THE TIME THIS OCCURS, THE BRAKES ALSO LOCK UP AND MAKE NOISES WHEN PRESSED. EACH TIME, THE SERVICE DEPARTMENT TELLS ME ITS A SENSOR AND WHEN REPLACED, IT STOPS DOING IT UNTIL THE NEXT TIME A "SENSOR" NEEDS TO BE REPLACED. TH…
Read full complaint
SINCE 2006, I'VE HAD TO TAKE MY CAR TO THE SERVICE DEPARTMENT BECAUSE OF ABS LIGHT TURNING ON AND OFF. AT THE TIME THIS OCCURS, THE BRAKES ALSO LOCK UP AND MAKE NOISES WHEN PRESSED. EACH TIME, THE SERVICE DEPARTMENT TELLS ME ITS A SENSOR AND WHEN REPLACED, IT STOPS DOING IT UNTIL THE NEXT TIME A "SENSOR" NEEDS TO BE REPLACED. THE SAY THERE ARE MULTIPLE SENSORS, AND EACH TIME IT APPEARS TO BE A DIFFERENT ONE. *JB
DATING BACK TO THE SPRING OF 2006, I HAVE BEEN HAVING PROBLEMS WITH THE "ABS" LIGHT SYMBOL CONSTANTLY COMING ON IN MY CAR. I TOOK IT TO THE DEALERS ON SEVERAL OCCASIONS AND TOLD THEM THAT WHEN I'M TRAVELING FOR 10-15 MINUTES OR LONGER IT COMES ON. THEY TOLD ME THAT THEY COULDN'T FIND ANYTHING WRONG AND THEY EVEN TEST DROVE MY …
Read full complaint
DATING BACK TO THE SPRING OF 2006, I HAVE BEEN HAVING PROBLEMS WITH THE "ABS" LIGHT SYMBOL CONSTANTLY COMING ON IN MY CAR. I TOOK IT TO THE DEALERS ON SEVERAL OCCASIONS AND TOLD THEM THAT WHEN I'M TRAVELING FOR 10-15 MINUTES OR LONGER IT COMES ON. THEY TOLD ME THAT THEY COULDN'T FIND ANYTHING WRONG AND THEY EVEN TEST DROVE MY VEHICLE. I'M VERY CONCERNED ABOUT THIS PROBLEM. I'M AFRAID THAT THE BRAKING SYSTEM IS GOING TO FAIL ON ME ALL TOGETHER. *JB
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH ON NORMAL ROAD CONDITIONS, THE FRONT PASSENGER SIDE DOOR OPENED. THE DOOR WAS LOCKED BUT THE DOOR LIGHT THAT SIGNALED THE DOOR WAS OPEN WAS ILLUMINATED. THIS WAS THE FIRST INCIDENT WITH THE VEHICLE, WHICH ALSO HAVE HAD AN ENGINE THAT STALLED. THE ENGINE FAILURE LIGHT ALERTED THE CO…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH ON NORMAL ROAD CONDITIONS, THE FRONT PASSENGER SIDE DOOR OPENED. THE DOOR WAS LOCKED BUT THE DOOR LIGHT THAT SIGNALED THE DOOR WAS OPEN WAS ILLUMINATED. THIS WAS THE FIRST INCIDENT WITH THE VEHICLE, WHICH ALSO HAVE HAD AN ENGINE THAT STALLED. THE ENGINE FAILURE LIGHT ALERTED THE CONTACT FOR THE ENGINE PROBLEM. THE ABS LIGHT ALSO ALERTED THE CONTACT FOR THE BRAKES FAILURE; THE SENSORS WERE REPLACED. THE DEALERSHIP HAD HONORED THE EXTENDED WARRANTY BUT THE CONTACT WAS VERY UPSET BECAUSE OF THE SIX TIMES THE VEHICLE HAD TO BE TAKEN TO THE DEALERSHIP.
ABS LIGHT CONTINUES TO COME ON, VEHILCE HAS BEEN IN FOUR TIMES FOR REPAIRS TO ABS SYSTEM. *JB
ABS YELLOW CAUTION LIGHT CAME ON IN MARCH 2006. BRAKES WERE GRINDING AND CAR DIFFICULT TO STOP. RETURNED CAR TO DEALERSHIP. LEFT WHEEL SENSOR WAS FAULTY AND REPLACED UNDER WARRANTY. NOVEMBER 26, 2006 ABS LIGHT ON AGAIN. BRAKES AGAIN GRINDING AND CAR BECAME DIFFICULT TO STOP. CAR ONLY HAS 29,000 MILES. *NM
DRIVING CAR THE ABS LIGHT COMES ON, FIRST OCCURRENCE FEB. 2006 SINCE THEN 3 ADDITIONAL TIMES WITHIN ONE MONTH. RECENTLY NOTICED WHEN ABS COMES ON BRAKING IS AWKWARD AND ON SEPT. 12 WHEN ABS CAME ON FELT AS IF/SOUNDED SOMETHING WAS BREAKING/CRACKING. RIGHT/LEFT SENSORS HAVE BEEN REPLACED BUT PROBLEM KEEPS OCCURRING. *NM
I HAVE A 2005 CHRYSLER PACIFICA AND THE ABS LIGHT IS ON. HAS TO 2 REPAIR SHOPS AND NO ONE CAN TELL ME WHAT THE PROBLEM IS. THEY HAVE TRIED TO PULL THE CODES BUT NO CODE WAS AVAILABLE. AND THE LIGHT IS STILL ON. ONE SHOP REPLACED THE LEFT REAR HUB ASSEMBLY BECAUSE IT WAS NOT READING. THE PROBLEM IS STILL THERE AND I AM OUT 200.00…
Read full complaint
I HAVE A 2005 CHRYSLER PACIFICA AND THE ABS LIGHT IS ON. HAS TO 2 REPAIR SHOPS AND NO ONE CAN TELL ME WHAT THE PROBLEM IS. THEY HAVE TRIED TO PULL THE CODES BUT NO CODE WAS AVAILABLE. AND THE LIGHT IS STILL ON. ONE SHOP REPLACED THE LEFT REAR HUB ASSEMBLY BECAUSE IT WAS NOT READING. THE PROBLEM IS STILL THERE AND I AM OUT 200.00 DOLLARS FOR THE HUB ASSEMBLY. THE CODES HAVE BEEN CLEARED SEVERAL TIMES BUT THE LIGHT KEEPS COMING ON WITH NO CODE STORED IN THE COMPUTER. *JB
Official recalls
206V432000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Nov 9, 2006
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE AND THE POWER TRAIN CONTROL MODULE (PCM) SOFTWARE MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN OPERATING CONDITIONS.
Consequence & remedy
Consequence: THIS COULD CAUSE A CRASH TO OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE FUEL PUMP MODULE WILL ALSO BE REPLACED ON VEHICLES BUILT FROM AUGUST 1, 2004 THROUGH SEPTEMBER 30, 2004. THE RECALL BEGAN ON NOVEMBER 21, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
05V066000 · Exterior Lighting:headlights
Mar 1, 2005
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HALOGEN HEADLAMPS MAY EXPERIENCE AN INTERMITTENT AND EVENTUAL TOTAL LOSS OF HEADLAMP FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT, AND REPLACE IF NECESSARY, THE WIRING HARNESS AND LOW BEAM BULB ON BOTH HEADLAMP ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA06013 · Engine Stalling
Opened Jun 22, 2006 · Closed Nov 29, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Power Train; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Vehicle Speed Control
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Additional source detail variants (7)
Engine And Engine Cooling
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline:delivery
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline:delivery:fuel Pump
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Power Train
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Vehicle Speed Control
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
EA06010 · Fuel Tank Punctures
Opened Jun 15, 2006 · Closed Oct 11, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage; Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Fuel System, Gasoline:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ06002 · Engine Stalling
Opened Feb 27, 2006 · Closed Jun 22, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline; Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Additional source detail variants (3)
Engine And Engine Cooling
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Fuel System, Gasoline
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
PE06009 · Fuel Tank Punctures
Opened Feb 22, 2006 · Closed Jun 15, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
ON FEBRUARY 22, 2006, ODI OPENED PE06-009 TO INVESTIGATE REPORTS THAT THE FUEL TANKS ON MODEL YEAR (MY) 2004 TO 2005 CHRYSLER PACIFICA VEHICLES MAY BE PUNCTURED BY CONTACT WITH ROAD DEBRIS.THE NUMBER OF REPORTS SUBMITTED BY CHRYSLER WAS SIGNIFICANTLY HIGHER THAN THOSE SUBMITTED BY OTHER MANUFACTURERS WHO WERE REQUESTED TO SUBMIT DATA AS PART OF INVESTIGATION PE05-050 INTO MY 2003 TO 2006 NISSAN MURANO VEHICLES THAT MAY HAVE HAD INSUFFICIENT SHIELDING OF THE FUEL TANK TO PREVENT PUNCTURES AFTER CONTACT WITH ROAD DEBRIS.NISSAN ISSUED RECALL 06V-003 INVOLVING INCREASING THE SHIELDING OF THE FUEL TANKS TO REDUCE THE LIKELIHOOD OF TANK PUNCTURES. CHRYSLER HAS NOTED THAT THEY HAD IN PLACE FROM JANUARY 2003 TO JUNE 2005 A PARTS RESTRICTION PROGRAM ON PACIFICA FUEL TANK REPLACEMENTS WHICH MAY HAVE MADE THE NUMBER OF REPORTS ARTIFICIALLY HIGH IN COMPARISON TO MANUFACTURERS WHICH DID NOT HAVE A SIMILAR PROGRAM IN EFFECT.CHRYSLER ALSO QUESTIONED WHETHER MANY OF THE FIELD REPORTS OF FUEL TANKS REPLACED DUE TO DAMAGE FROM UNKNOWN CAUSE WERE ACTUALLY PUNCTURED. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-010) TO GATHER ADDITIONAL INFORMATION CONCERNING THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.